I was driving in town through a stoplight when I noticed my brakes stopped working. Also when I had stopped the car still in drive and the car had shut off completely in the middle of the road and was not able to turn back on. The car would keep trying start but none were successful. My car also stated that there was reduced power to the engine and the car would hesitate to gain speed as well. My safety and others were put to risk because my brakes stopped working so I could’ve caused an accident. When we trying to find what was wrong with it through a code reader we had noticed the piece had shattered inside of the engine. No insurance, police or manufacturer has inspected the issue.
Chevrolet Malibu brake failure problems
178 of the 19,367 owner complaints about the Chevrolet Malibu describe brake failure, most of them for the 1998 model year.
- owner complaints
- 178
- worst model year
- 1998
- typical repair cost reported
- $1,200
- typical mileage
- 70,000
Is there a fix? There are 4 recalls for this area of the car. See below
By model year
Often reported together
ABS 19Loss of power 14Check engine light 12Power steering loss 9Grinding brakes 9No deployment 9Stalling 8Engine failure 6
Trouble codes mentioned
U0415 1
What owners say
The contact owns a 2020 Chevrolet Malibu. The contact stated that while attempting to depress the brake pedal, the brakes failed to respond and seized, causing the contact to engage the parking brake. The contact was able to pull over while awaiting tow truck assistance. The vehicle was towed to a dealer to be diagnosed. The contact stated that a Lexus engineer retrieved the EDR; however, there was no failure found with the braking system. The failure mileage was 120,000.
While driving my 2022 Chevrolet Malibu on the freeway, I experienced a loss of braking. This created a serious safety hazard because I was unable to stop the vehicle normally. The vehicle had previously displayed a check-engine warning. I brought the vehicle to the Chevrolet dealer. The dealer is requesting approximately $4,000 for repairs and has refused to perform the turbo-related recall/special coverage repair unless I pay for those repairs. I am requesting that the federal safety agency review this incident as a potential vehicle safety defect and review whether the braking problem may be related to the known turbo/engine issue Break vacuum pump is broken and diagnose by the dealer . Check engine light was on prior to incident due from Turbo charger failure
I was driving and all of a sudden all the warning lights start going off on my vehicle’s dashboard and the car jerks back and forth while decelerating. This has happened twice on the highway putting me in danger of crashing or making cars around me crash. On a seperate occasion my brakes failed, causing the car to jerk abruptly in traffic, thankfully I was able to pull over. Some times the car will limit my speed to below 60mph for “safety” reasons. The same set of issues have happened to me at least six different times. Every time I take it into the dealership for repair they always charge me for something new saying they finally fixed it and yet I always keep coming back for the exact same thing. This car is not safe to drive and I’ve taken it to two dealerships with two very smart teams of people and none of them have been able to figure this out.
I own a 2018 Chevy Malibu. At approximately 57,000 miles, the original engine experienced a vacuum pump failure that resulted in catastrophic engine damage. The engine was replaced by General Motors under the vehicle's warranty. I then drove the vehicle for approximately another 52,000 miles with the warranty replacement engine. At that point, I experienced a sudden loss of braking while driving. My vehicle was again diagnosed with a vacuum pump failure, and the vacuum pump was replaced. Approximately one week after the vacuum pump replacement, the warranty replacement engine suffered catastrophic failure. The repair facility diagnosed cylinder #3 scoring and informed me that the engine required replacement. I was told that the engine failure was related to the vacuum pump failure. Because the warranty replacement engine was no longer covered under warranty, General Motors initially declined to cover the repair. Initially, neither General Motors nor the Chevrolet dealership was willing to accept responsibility for the issue. After continued discussions, General Motors ultimately agreed to provide partial financial assistance as a goodwill adjustment. However, I was still left responsible for paying a substantial amount out of pocket to purchase and install a third engine. The cost has created a significant financial burden that I have struggled to afford, especially because the repair involved a component that I was informed has a known history of failure. I was also informed that vacuum pump failures are a known issue with these vehicles and that General Motors is aware of the problem, although no recall has been issued. I am submitting this complaint because I have experienced multiple vacuum pump failures, two catastrophic engine failures, and have now required three engines in the same vehicle. This has resulted in significant financial hardship, loss of use of my vehicle, and serious concerns about the safety and reliability of this vehicle.
While coming down McClure pass in Colorado my brakes failed. The the car went to engine power reduced mode. After getting the car to an independent mechanic I was told that the vacuum pump failed and exploded the parts into the camshaft. After 2 days of repairs I was finally able to get my car back to working order. This could have been a fatal car accident coming down a mountain pass. I was able to get stopped safely because I know the road. I had just driven 700 miles over Eisenhower Pass, Vail Pass, Glenwood Canyon, and then the final pass being McClure pass where it failed. I bought this car brand new and I probably won't buy another Chevy after this. This was a terrifying experience that I will have lasting trauma from.
I have a 2017 Chevy Malibu 2.0 T. The incident involved the braking system. I was driving and as traffic came to a stop, I pressed the brake to stop and my brakes gave out. I immediately lifted my foot and press extremely hard on my brake pedal and was able to stop though the stopping distance was much further and nearly caused an accident. I have now taken the vehicle to a Chevy certified dealer and it has been identified as a brake vacuum pump failure. GM has had many issues with the brake vacuum pump across many of its models.
While driving, the brakes became hard and the vehicle was difficult to stop. The brake pedal required excessive force, brake assist was reduced, and the stopping distance increased, creating a serious safety hazard. The check engine light had been illuminated for approximately two years before the brake failure occurred. In January 2024, I reported brake-related concerns to a Chevrolet dealership while the vehicle was under warranty, but the root cause was not diagnosed. In November 2025, after the brake pedal became hard, an independent repair facility inspected the vehicle and determined the brake problem was caused by a failing engine vacuum pump. They advised that the vehicle be repaired by a Chevrolet dealership. By January 2026, the brake condition had worsened to the point that the vehicle was no longer safe to drive and had to be towed. A Chevrolet dealership later confirmed that the engine vacuum pump had seized and damaged the camshaft, requiring replacement of both components. The vehicle remains inoperable. The failed vacuum pump caused loss of brake assist, resulting in a hard brake pedal, reduced braking ability, and an increased risk of a crash. I believe this represents a serious safety defect because failure of the vacuum pump significantly impairs the driver’s ability to stop the vehicle safely. I understand GM has issued service information regarding vacuum pump failures on this engine, and I am submitting this complaint because I believe other drivers may experience the same dangerous brake failure.
The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving on the interstate and attempting to exit the ramp at 40-45 MPH, the brakes failed. After restarting the vehicle, the check engine warning light illuminated. The contact related the failure to the federal safety agency Campaign Number: 18V576000 (Service Brakes, Hydraulic). The vehicle was towed to the local dealer, where it was diagnosed that the vacuum pump had failed. The vehicle was not repaired. The manufacturer was contacted, confirmed there was no recall and referred the contact to the federal safety agency Hotline. The approximate failure mileage was 150,000.
While driving my 2013 Chevrolet Malibu (2.5L), I experienced a sudden and severe failure of the braking system. [Insert exactly what happened here—for example: 'The brake pedal suddenly went completely to the floor,' 'The brakes unexpectedly locked up,' 'The vehicle experienced a sudden loss of braking power,' or 'The brake warning lights illuminated right as the brakes failed']. This occurred while traveling at approximately 25 mph on a one-lane road. This total/partial loss of braking power created an immediate safety hazard and a high risk of a crash. The vehicle had to be shifted into manual, then safely coasted to a stop. No prior warning signs or brake issues occurred immediately leading up to this event.
Related recalls
Service brakes, hydraulic: foundation components: disc: caliper
- What is wrong
- General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.
- Risk
- A reduction of braking performance can increase the risk of a crash.
- Remedy
- GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1‑800‑521‑7300, Cadillac customer service at 1‑800‑458‑8006, Chevrolet customer service at 1‑800‑222‑1020, or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is 18279.
Recall number 18V576000 · Recall details
Service brakes, hydraulic: power assist: vacuum
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Malibu vehicles manufactured June 12, 2013, through May 2, 2014, and equipped with a 2.5L engine with the auto stop/start option. The affected vehicles may experience a complete loss of brake vacuum assist, disabling the hydraulic boost assist. As such, these vehicles do not comply with Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
- Risk
- If the hydraulic boost assist is disabled, slowing or stopping the vehicle will require additional brake pedal effort and a lengthened stopping distance. Both of these effects increase the risk of a crash.
- Remedy
- GM will notify owners, and dealers will update the electronic brake control module software, free of charge. The recall began on July 3, 2014. Owners may contact General Motors customer service at 1‑800‑222‑1020. General Motors number for this recall is 14201.
Recall number 14V247000 · Recall details
Service brakes, hydraulic: foundation components: disc
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2014 Buick Lacrosse vehicles manufactured January 29, 2014, through March 31, 2014 and 2014 Chevrolet Malibu vehicles manufactured February 7, 2014, through March 31, 2014, and equipped with 17 inch front brake rotors. The affected vehicles may have had brake rotors intended for the rear of the car accidentally installed on the front. The rear rotors, while the same diameter, are thinner and may result in a front brake pad detaching from the caliper.
- Risk
- If a brake pad detaches from caliper, there may be a sudden reduction in braking, lengthening the distance required to stop the vehicle and increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will inspect the front brake rotors, and install the correct rotors with new brake pads, as necessary, free of charge. The recall began on June 20, 2014. Owners may contact General Motors customer service at 1‑800‑521‑7300 (Buick) or 1‑800‑222‑1020 (Chevrolet). GM's number for this recall is 14128.
Recall number 14V240000 · Recall details
Service brakes, hydraulic: antilock/traction control/electronic limited slip: control unit/module
- What is wrong
- Some of these passenger vehicles have an electronic control unit (ecu) that may calculate a higher than actual vehicle speed because of an erratic rear-wheel speed sensor signal, and cause ABS activation where it is not needed or needed ABS activation to be extended during braking as the vehicle speed drops to about 3 MPH.
- Risk
- Unexpected ABS activiation could increase stopping distance up to about 11 feet dpending on the grade of the road, increasing the risk of a crash.
- Remedy
- Dealers will reprogram the ABS controller. Owner notification began on june 16, 2004. Owners should contact chevrolet at 1‑800‑630‑2438.
Recall number 04V190000 · Recall details
Questions about the Chevrolet Malibu brake failure
Which Chevrolet Malibu years have brake failure problems?
The model years with the most reports are 1998 (23 complaints), 1999 (20 complaints) and 2018 (16 complaints).
How much does it cost to fix brake failure on the Chevrolet Malibu?
Owners who mentioned a price put the repair at about $1,200 (median of 9 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Chevrolet Malibu?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history