1999 Chevrolet Silverado 1500 body problems

Filed Apr 25, 2023 · Body · 134,000 miles · MI

The contact owns a 1999 Chevrolet Silverado 1500. The contact stated that there was a gap between the cab and the bed of the vehicle, and that the subframe of the vehicle was corroded. The check engine warning light was illuminated. The vehicle was taken to an independent dealer and the contact was informed that the catalytic converter needed to be replaced. The contact did not believe that the diagnostic result was not relative to the failure. Additionally, the contact stated that there were rust spots underneath the vehicle. The manufacturer was not notified of the failure. The failure mileage was approximately 134,000.

Filed Sep 27, 2021 · Body, Suspension · MI

The frame and suspension has overly corroded. The frame is falling apart so bad that when I shut the driver's door chunks of metal fall to the ground. I've had it assessed and they say it should not be this bad. Even in Michigan

Filed May 17, 2019 · Body · 104,000 miles · CT

I went to have an oil change and when the garage went to lift the truck the frame buckled. There was so much rust damage that the frame was soft in numerous places. The 1999 silverado z71 1500 truck is an lt with only 104,000 miles. It has been garaged since I purchased it new. It looks and runs great! The brake lines rusted out 10 years ago and I replaced with stainless steel lines.

Filed Apr 12, 2018 · Body · KY

The frame broke right over the rear end. . I seen the bed of the truck was not lining up with the cab one day.

Filed Dec 26, 2017 · Body · 118,362 miles · WI

The full size spare tire that is mounted under the rear of vehicle fell off into traffic while making a slow turn, on a flat, smooth concrete city street at 4 MPH.the tiny cable that holds the wheel rusted completely through. This is a deadly hazard! Someone will get killed by this flaw eventually

Filed Oct 28, 2017 · Body · 198,800 miles · NY

The frame rail on the left side is broken in 2 places under the cab area. The frame broke while driving. Now the cab sags 1 in lower where the cab meets the box. Body lines no longer match up. There is no reason a 18 yr old truck with a mint condition body and only driven approx 17500 km per year should break the way it did. This perfectly good step side truck is now useless and completely unsafe to drive.

Filed May 31, 2017 · Body · 77,000 miles · IN

A couple months ago, I bought a 1999 chevy silverado 1500 z71 with 77,000 actual miles that was for sale on craigslist. The gentleman advertised the truck in excellent condition, with no rust. When I test drove the truck, I noticed it needed new a exhaust, and shocks. The fog lights were broken, and the turn signal lenses were extremely cloudy. This is normal on a older vehicle. The truck has been setting in the garage, since I drove it home. The gentleman told me that all the receipts are in the glove box, from work that was done on the truck. I went through the receipts, and most of them were from oil changes. Since I don't know the history of the truck, it's a good idea to do a tune-up, and change all the filters and fluids. I spent over a $1,000 not including labor, on shocks, exhaust system, turn signal lenses, fog lights, filters, fluids, spark plugs, and ignition wires. I jacked the truck up, so that I could replace the exhaust. When I crawled under the truck, I noticed the frame and frame cross members were extremely rusty. The truck was advertised in excellent condition, with no rust! I started removing the old exhaust, and my hand went through one of the frame cross members. The gas tank hangs from this particular frame cross member. How can the truck body be so nice, but the frame be completely rusted out? If we had state inspections, there's no way the truck would pass inspection! I have a 1995 gmc sierra that's never had any body rust, or rust on the frame! I did some research on the internet, and found out it's common for the frames to be completely rusted out on the gm trucks build from 1999 - 2007. There's millions of these trucks on the road, and the fuel tank, spare tire, or rear-end could easily fall off! Why isn't gm recalling these trucks, and replacing the rusted out frames? I have a 2007 ford f150 that doesn't have any body rust, or frame rust!

Filed Oct 25, 2015 · Body, Brakes · 105,000 miles · WV

Was driving and noticed that the brake pedal felt sloppy. Upon investigation I had to replace all rear brake lines, and one of the front do to rust. As I was replacing these I noticed that the frame was rusted and cracked on the drivers side under the door. I had a patch put in, but just the other day I also noticed a new spot on the frame where it bends on the passenger side right behind the motor. The frame is so weak in this spot, I don't believe that it can be repaired.

Filed Jun 16, 2015 · Body · OH

After all the rusted parts; fuel tank that strap tank fell out. Brake line rusted through lost brakes and now we are told frame has rusted that cause our fuel line to ruptured. When will general motors step up and take care of these trucks that are rust buckets.

Filed Mar 16, 2015 · Body, Suspension · 102,000 miles · NY

Tl* the contact owns a 1999 chevrolet silverado 1500. While driving approximately 55 MPH, the vehicle drove over a bump and a loud noise emitted from the rear of the vehicle without warning. The contact observed that the rear shock detached from the vehicle. The vehicle was taken to a dealer, where it was diagnosed that the frame was fractured and the vehicle needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was 102,000.