2009 Chevrolet Silverado 1500: fuel pump failure

Filed Oct 28, 2022 · Body, Fuel system · WA

Fuel system leak at fuel pump due to corrosion. Found raw gas leaking out from under vehicle while vehicle in operation. Upon further investigation, found metal supply and return lines severely corroded and leaking. Repaired with new pump. While being repaired, noted severe corrosion on frame and cross members to include upper shock mounts and spare tire mount. Holes in frame were noted.

Filed Aug 3, 2021 · Fuel system · CT

Gas leak on top of fuel tank. When fuel pump is powered gas leaks.

Filed Aug 10, 2020 · 65,000 miles · IA

When replacing the fuel pump the mechanic noted that the frame had serious rust corrosion and also the brake lines had serious rust issues.

Filed Apr 1, 2019 · Engine, Fuel system · 115,000 miles · PA

My fuel pump control module pn20759945 shorted. Recall bulletin 14515 covers my model year and part number. However, gm claims my VIN is not covered by this. This is the same part and same failure listed in the recall bulletin, and imo it should be covered by gm. Fcpm's are poorly designed and poorly placed and fail on many many gm models over a number of years. This is an item that should be expanded to include all vehicles with that part number, especially if they are mounted externally and exposed to the environment such as on all chevy sliverados and related trucks. The fault in my case was a check engine light, and not a crank no start. I took the truck to gm for diagnosis. They said the fcpm needs replaced as it shows and internal fault. This is an expensive part and service,which should be covered by gm under the bulletin imo.

Filed Nov 9, 2018 · Engine, Fuel system · 65,199 miles · OH

Tl* the contact owns a 2009 chevrolet silverado 1500. While driving approximately 50 MPH, the check engine indicator illuminated and the engine shut down a few minutes later. The vehicle was towed to dave white chevrolet (419‑885‑4444, located at 5880 monroe st, sylvania, oh 43560) where the technician diagnosed and replaced the fuel pump control module. The manufacturer was made aware of the failure and stated that there was no recall. The vehicle was repaired. The failure mileage was 65,199. *dt consumer stated all info is correct. Updated 12/19/18

Filed Nov 14, 2017 · Electrical · 98,000 miles · MN

The check engine light came on while driving and when the codes were ran two codes popped up, p2534 (ignition 1 switch circuit low voltage 2. Ignition on/start switch low voltage.) and code p069e fuel pump control module requested mil illumination. When I had the dealer check this they said that the fuel pump control module needs to be replaced, however the VIN number of my vehicle did not match that of the recall that is currently in place (bulletin no. 14515b from january 2015).

Filed May 16, 2017 · Electrical, Fuel system · 72,316 miles · IL

The vehicle was being driven by my son when service engine light came on and I then used my actron scan tool and pulled 3x codes from the computer (ecu) codes related to the fuel pump control module , and trailer brake warning light appeared on the instrument cluster cleared these codes. 2 days later codes reappeared all were fuel pump circuit low, fuel pump module and trailer brake codes. Cleared codes then inspected the fpsm visually removed rear cover and the fpsm was full of water I them dried it out for 2x days in the sun truck ran after reassembly. But 3x days later the truck failed to start this time with computer scan tool in hand I checked the fuel pump pressure, the truck had no fuel pump pressure. I then went to my local chevrolet dealer and gave them the v.I.n. # to check the vehicle for recalls. Only recall was for safety belt recall which was done in 2009. I found out there was a potential recall for the fpsm on this website. So ii inquired to the parts department for this part,it was in stock and 183.00. I then purchased a new AC delco module on-line for 85.00 put it on and then found my local shop in town to have a tech come out to re-flash the fpsm so the (ecu) would recognize the new part. I am saving my copies of the bills so that when someone dies from this part failing when it stops the vehicle hopefully I can be reimbursed for another planned gm part failure... Sincerely mr. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *jb

Filed May 2, 2017 · Engine, Fuel system · 92,000 miles · VT

On thursdsy, april 27, 2017, I parked my 2009 chevy silverado at home in my driveway after work and shut it off for the night. It was stationary at that point. I did not restart it or move it for the remainder of the day/evening. The next morning, the engine would not start. It sounded like it was going to start, but to no avail after several tries. I determined it was not getting fuel. I called a local auto repair tech who diagnosed it on site, to be a faulty chassis electronic control module, which sends fuel to the fuel pump. Upon researching the problem, I found a recall bulletin / product safety recall #14515b issued january 2015. It clearly states that the 2007-2013 chevrolet silverado (along with many other makes/models/years) may have a chassis electronic module could have internal contamination (water, build-up causing wire and bolt corrosion). I believe this to be the case for my vehicle. According to the bulletin, the unsafe factor is that the "vehicle could stall while in motion and increase the risk of a vehicle crash." www-odi.the federal safety agency.dot.gov/acms/cs/jaxrs/download/doc/ucm472842/rcrit-14v614-0055.pdf I am the third owner so I did not receive a recall notice directly. I purchased this vehicle may 24, 2016.

Filed Mar 28, 2017 · Fuel system · 80,000 miles · OH

Tl* the contact owns a 2009 chevrolet silverado 1500. While driving 40 MPH, the vehicle experienced hesitation, a loss of power, and stalling. Also, the check engine warning indicator illuminated. The vehicle was taken to the dealer where it was diagnosed that the fuel pump module was defective and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.