The vehicle was idle for about 4 months. I took it to a carwash to clean the dust off. Upon returning (abt a 2 mile trip) the brakes failed and steam was coming out from under the hood. I opened the hood and brake fluid was sprayed all over the driver's side of the engine and wheel well. A brake line had rusted through and burst. Fortunately, I made it home carefully because I had noticed the brakes were soft.
The worst 2005 Chevrolet Suburban problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical36
- Brakes25
- Transmission15
- Body11
- Airbags10
- Acceleration8
- Engine8
- Fuel system8
- Locks6
- Steering5
- Visibility5
- Seats3
- Tires3
- Suspension2
- Wheels2
- Driver assistance1
- Lights1
- Seat belts1
Specific symptoms reported on the 2005 Chevrolet Suburban
Recalls 6
Engine and engine cooling
- What is wrong
- On certain trucks equipped with an 8.1l v8 (rpo l8-VIN g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper.
- Risk
- If the damper comes loose, a fuel leak may result. Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Dealers will replace the engine fuel rail pulse damper retainer clip free of charge. The recall began on august 31, 2006. Owners may contact chevrolet at 1‑800‑630‑2438 and gmc trucks at 1‑866‑996‑9463.
Recall number 06V289000 · Recall details
Seat belts: rear/other
- What is wrong
- On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
- Risk
- A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
- Remedy
- Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on july 21, 2005. Owners may contact cadillac at 1‑866‑982‑2339, chevrolet at 1‑800‑630‑2438, gmc at 1‑866‑996‑9463, or hummer at 1‑800‑732‑5493.
Recall number 05V163000 · Recall details
Service brakes, hydraulic: pedals and linkages
- What is wrong
- On certain sport utility vehicles, the brake pedal pushrod retainer may be missing. If the retainer is missing, the brake booster pushrod could disengage from the brake pedal.
- Risk
- This could result in a loss of brakes which could result in a crash.
- Remedy
- Dealers will inspect the vehicles for the brake pedal pushrod retainer and install one if it is missing free of charge. The manufacturer began contacting owners by telephone on march 10, 2005. Owners may contact chevrolet at 1‑800‑630‑2438 or gmc at 1‑866‑996‑9463.
Recall number 05V103000 · Recall details
Power train: manual transmission: shift pattern indicator
- What is wrong
- Certain sport utility vehicles equipped with an automatic transmission, fail to comply with the requirements of federal motor vehicle safety standard no. 102, "transmission shift lever sequence, starter interlock and transmission braking effect." under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. If the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in.
- Risk
- The vehicle may move in an unintended direction resulting in possible injury to others outside of the vehicle.
- Remedy
- Dealers will reprogram the instrument panel cluster free of charge. The recall began on february 14, 2005. Owners may contact cadillac at 1‑866‑982‑2339, chevrolet at 1‑800‑630‑2438, and gmc at 1‑866‑996‑9463.
Recall number 05V055000 · Recall details
Service brakes, hydraulic
- What is wrong
- Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.
- Risk
- If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. The presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.
- Remedy
- Dealers will test the hydro-boost assembly for functional operation of the two-function valve. If the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. The recall began on march 23, 2005. Owners may contact chevrolet at 1‑800‑630‑2438, gmc trucks at 1‑866‑996‑9463 and hummer at 1‑800‑732‑5493.
Recall number 05V043000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- On certain sport utility vehicles and pickup trucks equipped with 5.3l (rpo l59) v8 engines, the engine fuel rail crossover tube retainer screws were not manufactured to specifications and may break.
- Risk
- If the tube retainer screw breaks, fuel could leak from the fuel rail crossover joint, the engine may stall and, if an ignition source were present, an engine compartment fire could occur.
- Remedy
- Dealers will inspect the fuel rail crossover tube and, if necessary, replace the retainer screws. Owners were notified by telephone on july 30, 2004, with a followup owner letter began august 5, 2004. Owners should contact chevrolet at 1‑800‑630‑2438 or gmc at 1‑866‑996‑9463. Note: the gm bulletin lists the tahoe and yukon models because canadian vehicles are included in the bulletin. No u.s. Tahoe or yukon vehicles are included in the u.s. Campaign.
Recall number 04V376000 · Recall details
Technical service bulletins for the 2005 Chevrolet Suburban 791
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
- Unknown or other
- This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
- Unknown or other
- This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.
- Unknown or other
- Electrical system
- Unknown or other
- This service bulletin provides information for dealers/technicians on When and How to Submit a Field...
- Unknown or other
2005 Chevrolet Suburban fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 5.3L 8‑cyl | 4WD | 13 | 17-18 | 14-15 |
| 5.3L 8‑cyl | RWD | 14 | 18 | 15 |
What 2005 Chevrolet Suburban owners say
Most recent owner complaints, unedited.
This vehicle has less than 84,000 miles on it, and the chassis or frame is rotted. The rear anti sway bar already rotted off it, and the front bar is hanging down on the passenger side. I have photos of this, but don't know how to download them. The body has a little rot here, and there, but that is repairable. I spent a lot of money in purchasing this vehicle, and I expected it to last a very long time. The interior is almost like new. I am thinking about putting a tort claim about this to GM. Please help me all you can. I forgot to write that I also spent extra money for it to be undercoated, and it is supposed to be a lifetime warranty. I called that company, and they said it was only for 10 years. When I buy a new vehicle, I expect it to last.
Air bag sensors went out making air bag inoperable.
This defect pertains to gear indicator on the instrument panel. During the daylight hours the light indicating the gear the car is in (park, neutral, drive, etc.) is impossible to read. At night you can just barely read the gear indicators. The dimness of the lights behind this gear indicator gauge is a safety hazard because you cannot tell what gear you are in during the day. It is an expensive repair because the instrument panel needs to be removed to fix the problem.
Speedometer stops working intermittently. This is a safety hazard as the operator cannot tell the speed that the vehicle is operating. It seems to occur randomly.
The contact owns a 2005 Chevrolet Suburban. The contact stated upon taking the vehicle to an independent mechanic for tire replacement, he was informed that the entire chassis was severely corroded. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline. The vehicle was not diagnosed or repaired. The failure mileage was approximately 84,000.
Started with driver side heated seat randomly turning on and off. Going from high, medium, low. No way to turn it off just comes back on. Can hear clicking coming from under dash. Lift gate wiring that goes into body, ground wire burnt. (Replaced) but ground wire has power. (Wiring issue) so rear wiper doesn’t work. “Reading” Lamps only work when door is open. After replacing life gate connector, says lift gate open. Started the repair, which leads to more wiring issues! Needs a recall! Unsafe
The speedometer issue started 1 year ago, the speedometer shows needle stuck on 0 or all the way down to right side. Now issues with the gas gauge and oil gauge are happening also Mechanic has checked on this and stated that replacement needed.
Heated seats randomly turn on and off and goes thorugh the diffeent levels of heat and then off and then back on repeat for hours while driving and is very distracting as have to turn off every 10 sec and have almost crashed multiple times taking me eyes off the road but have to turn off as heat is too much in summer months, this is a known issue in almost ever suburban 01 to 05, how is this not a recall yet, there is massive amount of documentation of this issue online.
Gear status indicator does not display selected gear.
Compare the 2005 Chevrolet Suburban
Suburban vs Chevrolet TahoeSuburban vs Ford ExpeditionSuburban vs GMC YukonSuburban vs Toyota SequoiaSuburban vs Nissan Armada
Other model years
19901991199219931994199519961997199819992000200120022003200420052006200720082009201020112012201320142015201620172018201920202021202220232024
Questions about the 2005 Chevrolet Suburban
Is the 2005 Chevrolet Suburban reliable?
Owners have filed 129 complaints about the 2005 Chevrolet Suburban, close to a typical Suburban model year.
What is the 2005 Chevrolet Suburban year score?
The 2005 Chevrolet Suburban scores 72 out of 100 (average). The score compares it with the other model years of the Chevrolet Suburban: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2005 Chevrolet Suburban?
Electrical system, with 36 complaints, typically around 69,720 miles. Next is brakes (25).
How many recalls does the 2005 Chevrolet Suburban have?
6 recalls, covering engine and engine cooling, seat belts and service brakes, hydraulic.
What year does the Chevrolet Suburban have the most electrical problems?
The Chevrolet Suburban model years with the most electrical complaints are 2003 (81 complaints), 2004 (72 complaints) and 1999 (58 complaints).
What gas mileage does the 2005 Chevrolet Suburban get?
Official estimates for the 2005 Chevrolet Suburban range from 14 to 15 mpg combined. The most efficient version (5.3L 8-cyl, 4WD) gets 13 city and 17-18 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Chevrolet Suburban?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history