2024 Chevrolet Trax engine problems

Filed Nov 7, 2026 · Engine · VA

Engine connecting rod failure. GM has photos of the damage. Engine had a catastrophic failure on the highway while traveling at approximately 60 mph. All engine power was lost. Debris and oil from the engine was all over the road. Defect was confirmed by dealer. Engine was inspected and replaced by dealer. No warnings or diagnostic trouble codes prior to catastrophic engine failure. There was an intermittent misfire like symptom prior to the event.

Filed Oct 7, 2026 · Engine · 100,000 miles · PA · fire

The contact owns a 2024 Chevrolet Trax. The contact stated that while driving approximately 65 MPH there was a popping sound coming from the engine compartment and the message to shut off the vehicle was displayed. The vehicle was immediately parked, and there was smoke coming from under the hood. The contact opened the hood of the vehicle and discovered flames coming from the engine. The fire department was called to the scene and the fire was extinguished. A Police report was filed at the scene. The vehicle was deemed destroyed and was towed to a nearby storage facility. The cause of the failure was not yet determined. The local dealer was contact about the failure. The failure mileage was approximately 100,000.

Filed Oct 1, 2026 · Engine · 20,000 miles · AZ

The contact owns a 2024 Chevrolet Trax. The contact stated that while driving 45 MPH, there was an abnormal sound and smoke coming from the front of the vehicle. The contact stated that there was oil leaking from the vehicle and the engine seized. The vehicle was driven to the shoulder of the road. The dealer was contacted by phone and made aware of the failure. The vehicle was towed to the dealer; however, the report from the diagnostic test was not provided. The contact was informed that the engine needed to be replaced. The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 20,000.

Filed Sep 26, 2026 · Engine · AZ

I bought a brand new 24’ chevy Trax 2RS in November of 2023. By August of 2024 the Trax was already leaving orange coolant on the ground. I took it into the dealership August 22nd 2024 for service and repair; after a few hours they called me and let me know that they could not find the leak so they changed the oil and sent me on my way. Come September 2024 my 3 small children and I were on a road trip in Mexico La Rumorosa Mountains highway 2 when I noticed my car overheating on the temperature gauge; pulled over immediately found the coolant reservoir completely empty, the radiator was empty from coolant as well, so I filled it up with drinking water. Took it to the dealership on September 19th 2024 were they found the culprit to be a bad radiator a cracked thermostat housing & a bad coolant reservoir (all covered by warranty) car only had 12,000 when I started to notice the documented leak. By 13,400 miles is when the radiator failed completely. Most of the parts were on national back order, got a rental car for the time being until October 8th of 2024 when my car was fixed. Prior to all of that issue happening there was another issue while driving the car; after an auto start / stop event the car would run sloppy, (secondary power surge). Took it into the dealership they “fixed” it with a recall number (A242435780). I Strongly believe the motor suffered way more damage from the overheating than they are leading me on to believe. This is my second complaint filed here regarding the same vehicle.

Filed Sep 26, 2026 · Engine, Transmission · MD

Over the last 18 months the check engine light has come on multiple times while driving. Each time the check engine light came on, the vehicle was taken to the dealer. I was initially told by the dealer that they could not figure it out but to bring the car back if it happens again. Each time after taking the vehicle to the dealer for the check engine light, the dealer added oil to the vehicle. On one occassion the vehicle decelerated suddenly while driving. I reported the incident in a survey that I received from the dealer after an oil change. In April 2026, the dealer said that the engine appears to be consuming too much oil and an oil consumption test is needed. In September 2026, the vehicle was taken to the dealer after the check engine light came on and the dealer stated that an engine rebuild is needed and GM would be contacted.

Filed Sep 26, 2026 · Driver assistance, Engine · AZ

September 20th 2026: I was driving my 2024 Chevrolet Trax up a grade (Mountain) approximately 11AM, Driving Normally at Highway speeds, normal highway conditions, temp outside was close to 100 Degrees Fahrenheit, suddenly with no warning half way up the mountain the car lost power, check engine light turned on (Engine Power Reduced) came on, I had no option but to pull over on the highway with only 41,500 miles on the odometer. Being over 200 miles away from my home I felt devastated. Made an appointment the next morning to have the car checked out by the Chevrolet Technicians at the dealership, they stated the Turbo completely failed, the part was on a slight back order they pushed through and it took a week to get this repair done. Previous to the Turbo failing, approximately at 36,000 Miles on the odometer on or about January of 2026: I get in my Trax and the A/C will not blow cold air, took it in for service at the same dealership come to find out the A/C condenser failed or ruptured leaking Freon, I paid $1,800.00 on an expense out of pocket that was not covered by any warranties.I Even purchased the extended warranty when I bought the car with 0 miles in November of 2023. Previous to the A/C condenser failing with no warning what so ever, on November 2025 I go open my car and the remote unlock feature does not work due to a completely dead battery car would not start or open. The car had to be towed to the dealership because after they jump started it the transmission started clucking really hard when shifting into Drive. The culprit according to Chevrolet Dealer Service Advisors was just a dead battery(covered by warranty) , yet the car gave no signals of a dying battery.after picking up Car I noticed rough idle and performance after this incident, I took it back to get checked out the same day and they could not “replicate” the symptoms, they stated that they can only fix it when the car blows up since it wasn’t showing any Check engine lights. Continued…

Filed Aug 31, 2026 · Engine · LA

2024 Chevrolet Trax 1RS, approximately 66,000 miles. I was driving on the interstate at approximately 77 mph when I suddenly heard a very loud bang from the engine area. Immediately afterward, the vehicle began smoking both inside and outside, and there was a large black cloud of smoke behind the vehicle. The engine stalled and I lost propulsion while traveling at highway speed. I was able to move the vehicle to the side of the interstate. The vehicle then displayed a warning stating, “Oil pressure low, turn car off immediately.” I shut the vehicle off and did not continue driving. The vehicle had to be towed to an authorized Chevrolet dealership. The Chevrolet repair order dated August 10, 2026 documents the concern as a loud engine noise and notes that the tow/wrecker driver reported a hole in the engine block. Chevrolet’s inspection marked the engine oil, fluid leaks, and cooling system as “Alert.” At the same inspection, the engine oil-life monitor showed 93%. Chevrolet recommended removal and replacement of the engine long block. The dealer estimate lists $11,106.14 for the long-block replacement and approximately $13,420.89 in total pending recommendations. GM has agreed to provide partial financial assistance toward the engine replacement, leaving me responsible for approximately $5,200. The replacement engine is currently on backorder, and the vehicle remains inoperable while awaiting an engine. I am filing this complaint because the engine failed suddenly while I was traveling approximately 77 mph on an interstate. The loud mechanical failure, smoke, engine stall, and sudden loss of propulsion created a serious safety risk. I am concerned that this may be related to similar engine failures being reported in Chevrolet vehicles equipped with the 1.2L turbocharged engine. I have retained the Chevrolet inspection report, repair estimate, photographs of the engine following the failure, GM case information, and documentation concerning the replacement.

Filed Aug 22, 2026 · Engine · NV

My 2024 Chevrolet Trax is currently operating with a suspected internal engine defect tied to active Safety Recall A242435780. On 7/27/2026, Michael Hohl Chevrolet performed the software patch for this recall. However, severe internal engine noise remains. On my official repair order, the Shop Foreman test-drove the vehicle and explicitly documented: 'suspects could be something internal will need further diagnostics. Despite this documented internal engine concern tied to a federal safety recall, GM Corporate (Case #[XXX] (tel:[XXX])) and the dealership refuse to cover the diagnostic engine teardown. GM Customer Assistance formally told me to stop driving if the noise worsens, shifting the safety liability to me while refusing to remedy the defect. A sudden internal engine failure while driving will result in an immediate loss of motive power, power steering, and braking assistance, creating a severe crash hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 16, 2026 · Engine · KY

We were driving on the highway when the Trax suddenly made a popping sound, all the electric went off, and then the engine cut off. We lost control of steering for a bit, we're able to get to the side of the road. We had the car towed to the local Chevrolet dealer for diagnostics. The service manager informed me the engine is unrepairable due to a hole in the engine block, likely where the engine threw a rod. In order to get the engine replaced we have to have it towed to a second dealership, which we are in the process of doing now. I just purchased this vehicle 3 weeks ago without knowing this issue was a possibility

Filed Jul 13, 2026 · Electrical, Engine · 29,000 miles · NJ

The contact owns a 2024 Chevrolet Trax. The contact stated that while driving approximately 35 - 50 MPH, the message that an update was needed was displayed. The contact selected to complete the update later; however, the computer system continued to perform the update, causing all indicators, screens, and displays to black out. The contact was able to drive to the residence. The following morning, the systems operated correctly, and the update had completed. While attempting to turn off the vehicle, the radio failed to turn off at the same time. The contact had to first turn off the radio manually. While driving approximately 40 MPH, the message “Power Steering Fluid Low - Drive with Care” was displayed. The contact was able to make it to a stoplight after idling and then attempting to make a left turn, but the vehicle failed to exceed 6 MPH. The contact drove to Auto Zone. A certified mechanic confirmed that the power steering fluid was low. The certified mechanic diagnosed the vehicle, and the check engine warning light was displayed. The contact confirmed that the warning light was illuminated; however, when the mechanic inspected the vehicle, the warning light was no longer illuminated. The vehicle was not repaired. The dealer was informed of the issue and was unable to provide a cause for the failure. The manufacturer was not informed of the failure. The failure mileage was approximately 29,000.