2005 Chevrolet Venture problems

Filed Mar 6, 2026 · Fuel system · 116,000 miles · CA · fire

The contact owns a 2005 Chevrolet Venture. The contact stated that while his father was driving at an undisclosed speed on the highway, the vehicle suddenly lost automotive power. No warning lights illuminated. In addition, the contact stated that his father managed to pull over to the shoulder of the road, and upon further inspection, white/blue smoke was seen coming from under the vehicle, and the vehicle later caught on fire from the fuel pump/tank. The fire had leaked onto the floor; however, it had extinguished on its own. A police report was not filed; however, Law Enforcement arrived on scene to direct traffic. The local fire department did not arrive on scene. No injuries were sustained, nor medical attention was sought. The vehicle failed to restart. The vehicle was towed to a local tow yard, where it was deemed a total loss by the insurance provider. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 116,000.

Filed Oct 26, 2022 · Steering, Suspension · 236,000 miles · WV

The contact owns a 2005 Chevrolet Venture. The contact stated that while driving at various speeds, the vehicle was making a rattling sound coming from the front passenger’s side of the vehicle. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who replaced the wheel bearing hub assembly, brakes, rotors, struts, and tires. The failure persisted. The contact took the vehicle to another certified mechanic who performed a front-end alignment however, the failure persisted. The vehicle was taken to a third mechanic who identified that the noise seemed to be coming from the steering wheel; however, the mechanic could not verify the cause of the failure. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 236,000.

Filed May 23, 2017 · Airbags · 130,000 miles · OK · crash · 1 injury

Tl* the contact owned a 2005 chevrolet venture. While driving approximately 35 MPH in the rain, the vehicle hydroplaned to the left and then back to its lane. The rear tires rolled off the road and caused the vehicle to crash into a ditch. The air bags did not deploy. A police report was filed. The contact sustained injuries that required medical attention. The vehicle was towed to a body shop and deemed destroyed by the insurance company. The failure mileage was 130,000.

Filed Aug 11, 2015 · Body, Lights · 49,357 miles · WA · crash · 1 injury

My wife hit a old style van that had stopped for a dog crossing a the road. The whole front end had to be replaced. Hood, grill, lights, both fender had to be repaired, also the steal tube under the radiator frame had to be cut out and replaced. On 11/5/2010 I hit a deer going 30 MPH, again front end damage. Both times the air bags didn't deploy, and on star didn't respond. I asked two different chevrolet dealers if the air bag sensor could be tested, answer was no.

Filed Feb 15, 2015 · Fuel system · 225,000 miles · MI

We have been smelling gasoline fumes in and outside our van. Sometimes it is very potent and other times faint. When we walk into our garage, we can smell it also. It occurs often when making a left-hand turn. When we inspect it, we can't find any leak. We smell this from a half tank to empty.

Filed Nov 10, 2014 · Airbags · MI · crash · 1 injury

2005 chevrolet ventura. Consumer writes in regards to non-deployment of air bags. *smd the consumer stated his father and step-mother were involved in an accident. His father died from his injuries and his step-mother was injured. The consumer stated his father hit a dirt bank head-on and the air bags failed to deploy. As a result, his father hit the steering wheel with his chest causing damage to his lungs, spleen, kidneys and ribs. His step-mother hit the dash and center console with her head, cutting her across the forehead.

Filed Aug 7, 2014 · Seat belts · 90,000 miles · CO

Tl * the contact owns a 2005 chevrolet venture. The contact stated that the front passenger side seat belt buckle release mechanism fractured. The dealer ordered a seat belt mounting kit to perform the repair. The manufacturer was not notified. The VIN was unavailable. The approximate failure mileage was 90,000. Updated 10/24/2014*lj updated 7/14/2015

Filed Jul 3, 2014 · Fuel system · 85,000 miles · NC

Tl* the contact owns a 2005 chevrolet venture. While driving at an unknown speed, the contact smelled fuel within the cabin of the vehicle. The dealer was unable to diagnose the cause of the fuel odor. The vehicle was not repaired and the manufacturer was notified. The failure mileage was 85,000.

Filed Jul 2, 2014 · Fuel system · 85,000 miles · NC

The van fills with fuel fumes. The fumes can be smelled inside and outside the vehicle. Gm has recalled chevy venture 2001-2004 for specific VIN#'s but no 2005's and my specific VIN# is not included. I have talked with gm but their response is just your VIN# is not included. You can go to the dealership and pay for it to get fixed. This is a specific fire hazard according to their reports. I have had to park my vehicle for safety reasons. I can not allow my children to be subjected to the fuel fumes or the potential of a fire. I am not in a position at this time to pay for the work or trade due to the economy. If gm knows that have this problem then why would they let a potential hazard to loyal customers continue. Regardless of the VIN# if the problem is present then gm should be responsible. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Jun 8, 2014 · Airbags, Steering · MI · crash

The driver was slowing or stopped when she was rear ended. The front driver seat airbag deployed. It is unclear whether the airbag deployed prematurely or whether it deployed after the vehicle was rear ended.