The contact owns a 2011 Chevrolet Volt. The contact stated that water was accumulating inside the driver's side taillight assembly. The contact stated that the water caused a short circuit in the taillight, and the passenger’s side turn signal became inoperable. The contact had taken the vehicle to an independent mechanic where it was diagnosed, and determined that the wiring harness for the driver's side taillight assembly needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the federal safety agency Hotline. The failure mileage was approximately 97,000.
The worst 2011 Chevrolet Volt problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical23
- Airbags8
- Fuel system7
- Engine4
- Brakes3
- Steering3
- Transmission3
- Seats2
- Suspension2
- Acceleration1
- Body1
- Driver assistance1
- Lights1
- Seat belts1
- Tires1
- Visibility1
- Wheels1
Specific symptoms reported on the 2011 Chevrolet Volt
Recalls 1
Electrical system: ignition
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
- Risk
- If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
- Remedy
- GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is 14617.
Recall number 15V145000 · Recall details
See all 1 recalls for the 2011 Chevrolet Volt
Defect investigations
Pedestrian alert sounds
the federal safety agency received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, the federal safety agency opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified the federal safety agency he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by the federal safety agency regarding the subject matter of the petition.
DP22005
Post-Crash EV Fire Hazard
The subject vehicles, which employ emerging technology, are range-extended electric vehicles that utilize a high voltage (HV) battery to provide energy for propulsion. The HV battery is lithium-ion based technology that has a nominal full charge of 390 VDC, a 16 kWh capacity, and a control system that incorporates liquid (antifreeze) cooling and various electronic devices (control modules, sensors, wiring, etc) to monitor and manage the HV battery. The HV battery, portions of the cooling system, and the control system are contained within a common enclosure.During an NCAP oblique side pole impact test conducted by the federal safety agency in May 2011, the pole struck and deformed the sill plate under the driver's door at a location where there is a structural member. The lateral member displaced inward, pierced the HV battery enclosure and battery, and caused a battery coolant leak. Thereafter, the Agency conducted a rollover test (the rollover test consists of four 90-degree rotate-and-hold movements about the vehicle's longitudinal axis). In that test, the HV battery and electronics were exposed to coolant that leaked as a result of the crash. The vehicle fire that occurred three weeks later and the additional testing the federal safety agency conducted are discussed in a report titled 2011 Chevrolet Volt Battery Fire Incident Report a copy of which is available in the public file. The report indicates that intrusion induced coolant leakage, and subsequent rollover that saturates electronic components, were the only test conditions which resulted in a subject vehicle HV battery fire.GM announced its intention to conduct a free-of-charge customer satisfaction campaign (CSP) on the subject vehicles on January 5, 2012. The action affects 14,735 vehicles produced prior to December 21, 2011. The CSP addresses three areas related to the issue under investigation. The first involves a modification/strengthening of the structure of the vehicle in the area where battery intrusion occurred in the May 2011 test. The second involves adding a sensor that detects excessive HV battery coolant loss, and control system software that then alerts the driver and prevents recharging of the HV battery. When the battery cannot be recharged, it will be depleted to a lower energy state as the vehicle continues to operate on the internal combustion engine. Lastly, a tamper-proofing device will be added to the system to prevent consumers from adding coolant. GM discusses these revisions in its response to an Information Request (IR) issued by the federal safety agency, noting that vehicles produced in calendar year 2012 and later will be manufactured to this condition.In December 2011, and at the same test facility, the federal safety agency repeated the May 2011 side impact test using a model year 2012 Volt modified to the structural condition described in the CSP. The test did not produce intrusion of the HV battery, a coolant leakage, or a fire (see test 7611, available at . In its IR response, GM describes four (4) additional side impact tests of modified subject vehicles it recently conducted using various build configurations and impact speeds (including higher speeds). GM reports that none produced HV battery intrusion, coolant leakage, or a fire.As noted in the complaint counts above, ODI has not identified a crash occurring in consumer's use of the vehicle that has resulted in a vehicle fire, or produced coolant leakage. ODI notes that side impact crashes with pole-like structures, such as would strike the sill plate, occur fairly infrequently, and such crashes with rollovers are even less frequent. A defect trend has not been identified at this time, and further investi
PE11037
Technical service bulletins for the 2011 Chevrolet Volt 1,715
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
- This preliminary information communicates information about how to determine if a wheel and tires size...
- This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a...
- This Preliminary Information communication provides information to the technician about vehicles that have...
- This engineering informational bulletin provides process for a GM engineering study on curtain Takata...
- New Vehicle Monitoring Programs Section in IVH
- This Warranty Administration service bulletin provides Lithium-Ion battery Exchange Process and...
- This Preliminary Information communication provides information to the technician about vehicles that have...
- This service bulletin provides information on Tire Sidewall Irregularities.
- This Preliminary Information communication provides information to the technician about the use of...
2011 Chevrolet Volt fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 1.4L 4‑cyl Plug-in hybrid | FWD | 35 | 40 | 37 |
What 2011 Chevrolet Volt owners say
Most recent owner complaints, unedited.
I was stopped at a red light with my foot on the brake. When the light turned green, I released the brake and the car suddenly accelerated forward on its own, without me touching the accelerator. As soon as the car surged forward, I immediately pressed the brake pedal hard to stop it but instead of slowing down, the car continued to accelerate. It felt like pressing the brake was making it worse. The car was totally out of my control. The vehicle collided with tow truck and even after the impact, the engine was still revving as if it was trying to keep going. I had to shut the car off to stop it completely. There were no warning lights or error messages before or during the malfunction. The front end of my car was damaged in the crash. No one was injured, but the malfunction could have easily caused serious harm or death. This was not user error it was a terrifying mechanical and electronic failure. The car accelerated on its own and the brakes failed or possibly triggered more acceleration. I have never experienced anything like this. After looking online, I found other Volt owners reporting similar problems involving brake assist failure, unintended acceleration, and stuck revving. This looks like a serious pattern that deserves urgent attention. I’m asking the federal safety agency and General Motors to immediately investigate this issue. I want to know if there are any recalls, technical service bulletins (TSBs), or known defects related to brake failure or unintended acceleration in the 2011 Chevy Volt. Please contact me with next steps. This is a major safety risk that could easily result in fatalities if not addressed.
Driver display is blank (no speed, gear position, odometer, gas tank, etc), with the exception of some warning icons like tire pressure and passenger seat belt status. Does no return after turning off power.
'11 Chevy Volt hybrid was daily driver of 100+ miles, multiple trips both highway and city for last 2 1/2 months. Breaks and rotors have been replaced all the way around, fresh oil changes as needed and filters. Warning on dash "Service High Voltage Charging System", ”Service Airbag" and check engine light have been on since I've owned it (Oct. 23). When plug car in it doesn't charge, but the EV charges while driving. Car generally switches back and forth from EV to ICE without issues. No other issues have been noted. 1/18/24 Start car and drive all day for work. Total of 129 miles between 22 trips. Last trip car sat for 30 minutes after running deliveries all day. Started as normal, turned off at gas station, filled tank with premium, restarted and drive to freeway. Drove 20 miles, pulled over to text, put car in park. 5 mins later took out of park and car wouldn't move. Inside had complete power, radio, windows, ect. Only noticable difference was car would get no acceleration, power steering went out, and heat started blowing cooler air. Absolutely no warning and car just cuts off engines. Thankfully I was parked safe. Towed home, replaced 12v. Started and drove no problem on 1/19/24. No new warnings or anything different. Started up 1/20/24 drove 7 miles and the engines cut off in the middle of a main road while accelerating, once again no warning. Luckily got into turn lane before almost getting hit. Still not sure what's wrong with car. Same codes. No battery warning or loss of power indication at all. Just up and cuts off. This is very very dangerous and needs to be looked into please. When my volt died today the truck behind me had to slam on his brakes and came inches from hitting me. If this would've happen on the freeway, I'd likely been hit.
The car quit running when my wife was driving the car when the mileage range went down to 4 miles range remaining. The car was towed to the local Chevrolet dealership who charged over $1,000 to reset the electronics so car would run. I was advised that if battery range was run down to a low mileage range that car would quit running again and that it would have to be towed back to the dealership for the electronics to be reset. I was concerned about liability if anyone drove car and it stopped on highway. It was clear to me that the only way out of potential liability, associated with the car stopping on the highway was to sell the car for salvage. I purchased this Chevrolet Volt Premier new. It was never in a collision or damaged in any way. The car was sold for with approximately 81,000 miles for $2,013.
The contact owns a 2011 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the contact heard an abnormal whining sound coming from the engine compartment. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 90,000.
The contact owns a 2011 Chevrolet Volt. The contact stated that while driving at 35 MPH, the defroster failed to operate as needed. The vehicle was taken to the dealer, and the dealer replaced the heating system module; however, the failure recurred. The vehicle was taken back to the dealer, but the dealer was unable to duplicate the failure. The failure mileage was unknown.
Several times over the 2 years I have owned this vehicle while driving an almost complete loss of braking occurs with a service notice for the ABS system. If you turn off the ignition and restart it the braking works fine. I am in the process of having the Electronic Brake Control Module - GM (84070136) and the Brake Pressure Modulator Valve - GM (23283683) replaced. i believe that there is a design flaw in this system in that a problem of the ABS should not eliminating the ability to stop the vehicle. This is costing me $3500, but the point is that loss of braking is a serious safety issue and should be addressed by the manufacturer. Thank you.
Driver instrument panel went blank. Speedometer, fuel/battery gauge, odometer, etc are all gone. The screen display light lit on and off in the background without any information.
For unknown reason check airbag light came on. No one sits in passenger seat and the seat has not been wet.
Compare the 2011 Chevrolet Volt
Other model years
Questions about the 2011 Chevrolet Volt
Is the 2011 Chevrolet Volt reliable?
Owners have filed 49 complaints about the 2011 Chevrolet Volt, fewer than a typical Volt model year.
What is the 2011 Chevrolet Volt year score?
The 2011 Chevrolet Volt scores 89 out of 100 (good). The score compares it with the other model years of the Chevrolet Volt: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2011 Chevrolet Volt?
Electrical system, with 23 complaints, typically around 64,000 miles. Next is airbags (8).
How many recalls does the 2011 Chevrolet Volt have?
1 recall, covering electrical system.
What gas mileage does the 2011 Chevrolet Volt get?
Official estimates for the 2011 Chevrolet Volt range from 37 mpg combined. The most efficient version (1.4L 4-cyl plug-in hybrid, FWD) gets 35 city and 40 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 Chevrolet Volt?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history