Fully charged. Goes from electric to generator/gas propulsion and abruptly slowes about 1/2 speed. Very dangerous.
The worst 2013 Chevrolet Volt problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Airbags161
- Electrical63
- Fuel system57
- Engine38
- Seats31
- Transmission24
- Brakes20
- Acceleration6
- Body6
- Tires6
- Steering5
- Seat belts4
- Visibility4
- Driver assistance2
- Wheels2
- Lights1
- Suspension1
Specific symptoms reported on the 2013 Chevrolet Volt
Airbag light 61Stalling 12Check engine light 10Loss of power 9
Trouble codes owners of the 2013 Chevrolet Volt mention
B0081 2
Recalls 3
Air bags: frontal: driver side: inflator module
- What is wrong
- General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
- Risk
- An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
- Remedy
- Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1‑800‑521‑7300 and Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is N232413120.
Recall number 23V516000 · Recall details
Hybrid propulsion system
- What is wrong
- General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.
- Risk
- If the voltage drops, the vehicle may lose propulsion, increasing the risk of crash.
- Remedy
- GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The recall began July 24, 2018. Owners may contact Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is 18215.
Recall number 18V397000 · Recall details
Electrical system: ignition
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
- Risk
- If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
- Remedy
- GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is 14617.
Recall number 15V145000 · Recall details
See all 3 recalls for the 2013 Chevrolet Volt
Defect investigations
Pedestrian alert sounds
the federal safety agency received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, the federal safety agency opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified the federal safety agency he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by the federal safety agency regarding the subject matter of the petition.
DP22005
Passenger Sensing System
In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated. Many of the complaints noted the malfunction occurred after the warranty period expired and mentioned high repair costs as a major deterrent to the repair of the vehicle.The PSS sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the frontal passenger air bag. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same location. Over time, the repeated folding can cause an increased resistance in the sensor mat. An increased resistance in the PSS sensor mat is detected as a fault in the air bag system diagnostic. If this fault is detected, a diagnostic trouble code will be stored in the air bag control unit and the air bag MIL will illuminate.Further, if the fault is detected, the passenger frontal and knee air bags will be suppressed in a crash of sufficient severity to warrant a commanded deployment regardless of the nature of size of the occupant of the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the PSS sensor mat. Reports alleging only that the air bag light is on with no cause stated, or where a different cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than a PSS malfunction.The subject vehicles have been in service for approximately ten (10) years. An analysis of General Motors (GM) warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar occupant detection system failure investigations, indicates the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program as well as:1) a comparatively low warranty rate; 2) no reported injuries, deaths or asymmetric deployments; and 3) the age of the vehicles; ODI is closing this Preliminary Evaluation. The closing of this investigation does not constitute a finding by the federal safety agency that a safety related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI complaints cited above can be viewed at under the following ODI identification numbers in a separate attachment.
PE19013
Technical service bulletins for the 2013 Chevrolet Volt 1,953
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This PI provides Diagnostics tips on how the LIN bus works and how to diagnosis it.
- This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
- This preliminary information communicates information about how to determine if a wheel and tires size...
- This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a...
- This Preliminary Information communication provides information to the technician about vehicles that have...
- New Vehicle Monitoring Programs Section in IVH
- This Warranty Administration service bulletin provides Lithium-Ion battery Exchange Process and...
- This Preliminary Information communication provides information to the technician about vehicles that have...
- This service bulletin provides information on Tire Sidewall Irregularities.
- This Preliminary Information communication provides information to the technician about the use of...
2013 Chevrolet Volt fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 1.4L 4‑cyl Plug-in hybrid | FWD | 35 | 40 | 37 |
What 2013 Chevrolet Volt owners say
Most recent owner complaints, unedited.
The passenger presence sensor is failing or failed because every time someone sit in there the airbag turns on and off repeatedly every 2-3 mins and gives a service airbag warning and if no one is sitting in the passenger seat then it just stays on. Could be really dangerous if a wreck happens while it’s glitching in the off mode and could cause death. Multiple people have had this problem with the volts and there is even a thing you can by to completely bypass the airbag going off which shows how common the problem is if there is a solution to eliminate it in an unsafe/not factory manner
I received the "Propulsion Power is Reduced" Alert engine light while driving in "Normal" mode on the freeway at around 60mph with 8-9 miles of Battery capacity, it showed 0 miles of Battery forcing the Gas Engine on and the vehicle hesitated upon applying the accelerator for the remainder of the drive. My safety and that was others was at risk because the acceleration dropped quickly and I was on a busy freeway at the time when the Alert happened causing further hesitation. Upon stopping I could not get the vehicle to take a charge nor would it start up until a mechanic arrived and was able to confirm the problem.
The contact owns a 2013 Chevrolet Volt. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The Check Engine warning light was flashing, and the messages "No Propulsion Power" and "No Power To Engine" were displayed. The contact stated that two individuals pulled over and assisted the contact in pushing the vehicle to the side of the road to prevent a crash. The vehicle was towed to an independent mechanic, who made the contact aware of an unknown the federal safety agency Campaign Number; however, the VIN was not included. The vehicle was towed to a dealer, but the vehicle was not diagnosed or repaired. The contact requested vehicle rental assistance, but the dealer was unable to provide assistance. The manufacturer was contacted and referred the contact to the federal safety agency Hotline for assistance in initiating a recall. The failure mileage was approximately 141,323.
The passenger occupancy sensor gives a false positive. The only way I can get rid of the beeping is plug in the seatbelt. I have read on Reddit forums that this is a very common problem with 2013 volts, but for some reason there isn't a recall. This is a safety issue. Thank you!
Propulsion power reduced error has happened many times but the recall lookup shows that there are no active recalls on our car. There was a recall on this problem in 2018 so I think it may have been done my the last owner but it is still having this problem.
The drivers side front seatbelt pretensioner assembly contains a braided steel cable. The cable, through normal use, has become damaged to the point that individual wires have broken free from the crimped connector. The damaged wires of the cable have penetrated through the plastic sheath covering the cable causing a needle sharp poking hazard when reaching one’s hand toward the seat back adjustment lever. My wife had a minor laceration to her finger and I was also poked when trying to identify the cause. Upon further inspection I found that approximately 80 percent of the diameter of the pretensioner cable had broken free from the crimped connector. In the event of a collision, the cable would likely break free from the seatbelt, possibly causing serious injury to the driver. I tried to obtain a replacement part through the GM dealer parts network, but the part is listed as discontinued and unavailable. This leaves the vehicle unsafe in the event of an accident. The damaged components are available for inspection. The vehicle has not been inspected by anyone but myself. There were no warning lamps or symptoms of the problem prior the the injury. I am the original owner of the vehicle and it has never been involved in a collision. The vehicle has been properly maintained and is used only for personal transportation.
Fuel leaking from fuel tank at filler inlet. Defect in fuel tank assembly. Large puddle of gasoline formed under car after refueling causing buildup of fumes in closed garage. Vehicle has not been inspected by anyone other than owner. There were no warning lamps prior to failure.
Front passenger seat sensor intermittently fails, causing the Passenger Airbag indicator to switch to OFF (even if a passenger is present) with an accompanying "Service Airbag" message on the dashboard and illumination of the service airbag light. This occurs usually driving above 25mph, but can happen stationary, and lasts for anywhere from 5 seconds to a minute (more commonly shorter). The issue appears some weeks more than others, usually activating most days a week but sometimes have a week or two where it does not happen.
The contact owns a 2013 Chevrolet Volt. The contact stated while driving approximately 76-77 MPH, the vehicle experienced reduced power. The message "Low Propulsion" was displayed, and the engine revved significantly. The contact moved over to the far-right lane to pull over to the side of the road as needed. The contact stated that the failure had been recurring temporarily. The contact had researched the failure online and became aware that the release of the accelerator pedal while the failure was occurring could temporarily correct the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 61,000.
Compare the 2013 Chevrolet Volt
Other model years
Questions about the 2013 Chevrolet Volt
Is the 2013 Chevrolet Volt reliable?
Owners have filed 308 complaints about the 2013 Chevrolet Volt, 1.8 times a typical Volt model year.
What is the 2013 Chevrolet Volt year score?
The 2013 Chevrolet Volt scores 51 out of 100 (below average). The score compares it with the other model years of the Chevrolet Volt: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2013 Chevrolet Volt?
Airbags, with 161 complaints, typically around 76,000 miles. Next is electrical (63).
How many recalls does the 2013 Chevrolet Volt have?
3 recalls, covering air bags, hybrid propulsion system and electrical system.
Was there a recall on the 2013 Chevrolet Volt airbags?
Yes, 1 recall: 23V516000. Check your VIN to see if your car still needs the free repair.
What year does the Chevrolet Volt have bad airbags?
The Chevrolet Volt model years with the most airbags complaints are 2013 (161 complaints), 2012 (86 complaints) and 2014 (32 complaints).
What gas mileage does the 2013 Chevrolet Volt get?
Official estimates for the 2013 Chevrolet Volt range from 37 mpg combined. The most efficient version (1.4L 4-cyl plug-in hybrid, FWD) gets 35 city and 40 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2013 Chevrolet Volt?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history