Chevrolet Volt jerking problems

Filed Aug 7, 2026 · Transmission · CA

What component or system failed? When the BCEM failed on my car, it led directly to the transmission failing as well as the PIM. I was driving normally then had a completely inoperable car with no warning. I was told to pay over $17k for repairs by the dealership because there is no recall on the transmission, but I see proof that this is a common issue among Volt users. There needs to be a recall and repair to keep the road safe. How was your safety or the safety of others put at risk? I was driving on a busy road to school when my car fully locked up, jerked like crazy, and became inoperable. If I had been somewhere like a freeway instead of in front of a school, I likely would have become badly injured when the wheels stopped even turning. The tow truck even had to use wood under my wheels to get it onto the tow truck. Has the problem been reproduced or confirmed by a dealer or independent service center? I took it to the dealership and worked only with them. They replaced the BCEM without charge but have left me with an inoperable vehicle because I am unwilling to pay twice the cost of the car to repair it. Has the vehicle or component been inspected by the manufacturer? Dealership. But also, as mentioned, this is clearly common and needs to be recalled. A 2018 car with 117k miles of gentle driving on a well maintained vehicle shouldn't be failing, and there shouldn't be so many Volts being sold for parts because their transmission failed. This is clearly a dangerous issue related to production and should have a recall. Were there any symptoms of the problem prior to the failure, and when did they first appear? I bought the car with just under 16k miles in 2021 and within 3 months I had symptoms, but the dealership couldn't figure them out, as they happened intermittently and only in heat, and the dealership always sent me away without repairs. The failure itself happened at 62°, but was foreshadowed by lesser versions of its demise.

Filed Jan 15, 2026 · Fuel system, Transmission · TX

My car started having issues with the hybrid system, with fault alerts related to the drive motor control module, hybrid powertrain control module, and battery energy control module in the transmission, and the vehicle is available for inspection if needed. The engine light had been on for about a week, and I was waiting for availability at work to take it to a mechanic. While driving around 70 mph on the highway, a “Propulsion Power Reduced” message suddenly came on and the car started limiting its speed. As I kept driving, the power continued to drop, making it unsafe to stay at highway speeds and putting both me and other drivers at risk since the car couldn’t keep up with traffic and could slow down unexpectedly. I took it to an independent mechanic who confirmed the issue and warned me it was dangerous to drive because the speed would keep decreasing as power dropped. So far, only an independent mechanic has inspected it. After doing some research, I found this is a very common problem with 2016–2018 Chevy Volts, with many people reporting similar situations where their cars lost power or started jerking at high speeds and they had to pull over.

Filed Oct 14, 2025 · Electrical, Fuel system · MO

The car can't decide if it wants to use the battery or the engine. It shows zero charge even though it is full. It lurches at stop lights as it tries to decide whether to use battery or engine. It says "propulsion power reduced". "Not able to charge". "Shift to park". Check engine light is on.

Filed Dec 24, 2024 · Fuel system · GA

This is a reoccurring problem that is worsening. It is difficult to replicate (but becoming easier to replicate as the problem worsens). The problem conditions are as follows: -The car is fully charged The following drive conditions are required: - The beginning of a drive, with the car in the fully charged state, is driven in the “L” mode (aggressive regenerative braking), AND the beginning (first mile or two) of the trip includes some conditions that would NORMALLY engage regenerative breaking and redirect energy flow back to the high voltage battery. (E.g.: Beginning a drive by going up a small incline; then proceeding to drive down a decline.) OR - The beginning of a drive, with the car in the fully charged state, is driven in the “D” mode, AND the beginning (first mile or two) of the trip includes almost exclusively conditions that would NORMALLY trigger regenerative breaking and redirect flow back to the high voltage battery. IN BOTH cases: the instrument cluster, during conditions that would reflect regenerative breaking and energy flow back into the high voltage battery, instead reflects suddenly INCREASED electrical OUTPUT despite there being no increased demand for output from the driver. Expected behavior in these conditions would reflect a negative power output while the car is driven in regenerative conditions (e.g.: going down hill). In either of these cases, the final condition is that you fully stop the vehicle (via brake) during the regenerative conditions. DESPITE full depression of the brake, the car jerks forward violently and erratically, attempting to accelerate. Engaging the emergency brake does not cure the condition while the car is still in L or D driving mode, and it will continue to attempt to accelerate while held in place. Shifting in to neutral does stop the behavior. Shifting back to L or D from neutral will cause the vehicle to continue to attempt to accelerate. There are no error codes/lamps and sensors appear normal.

Filed Sep 16, 2024 · Brakes, Electrical · 89,800 miles · UT · crash

The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.

Filed Aug 7, 2024 · Electrical, Engine · MA

While driving my 2017 Chevy Volt on the highway, a “Propulsion power is reduced” message appeared accompanied by the CEL. Prior to this there had been no indication that anything was wrong. The warning was quite vague and it wasn’t at all clear what it actually meant so I continued driving. Shortly after this, I began to notice a bit of a “chuggle” or lurching sensation (particularly on hills). This made the acceleration slightly unpredictable, and at one point even triggered the forward collision warning when the car accelerated a bit after I took my foot off the gas pedal (coming up behind another car at a traffic light). I pulled over and attempted to figure out what the issue was. I had a notice regarding the BECM recall in my glove box which listed a reduced power mode as a potential symptom, so I scheduled a service appointment (figuring it was that) and continued my trip. I stopped to get gas, then a mile or two down the road the engine overheated and shut off. By sheer luck I had a few miles of range left in electric mode which allowed me to pull over safely, but I was now stranded over 100 miles from home. I managed to get the vehicle to a dealership in Danvers, MA where they diagnosed the problem as a failed EGR valve. My understanding is this is related to a defect in the valve electronics.The valve failed and blew the F3 fuse, which also supplies power to the engine cooling system. It doesn’t take long for the engine to overheat and it seems this can lead to a complete loss of power while driving when the electric range is already depleted. The valve is currently unplugged while I await a replacement but there is no word on how long that might be. Other Volt owners have had to wait months or even years to get a new valve. The repair quote I received is also unreasonably expensive (> $4,000). I failed my state emissions inspection and am in the process of applying for a waiver. Given how common this is, I'm surprised this isn't already a recall.

Filed Mar 20, 2024 · Engine, Fuel system · MA

On [XXX] my 2017 Chevrolet Volt with just 24,000 miles on it suddenly jerked/lost power/revved up while on the highway while using the gas engine--frightening/dangerous -- and continued to do that until I got to my destination. The error read "reduced propulsion". I was afraid of pulling off the highway for fear the car wouldn't restart and I had my 91 yr old mother in the car so we bucked along in the slow lane, the car revving fast, then losing power. It was very frightening and i proceeded with the flashers on. Took car to dealership balise in warwick ri. Tech said it was a bad EGR valve. They told me that GM would cover the repair under warranty but the part was on backorder. I opted to leave the car at the dealership hoping for the best but they said another customer had been waiting since September. They told me to take the car home, but i didnt feel the car was safe to drive. Web search reveals this is a common problem and people are waiting all over the U.S. for this part for over a year. Subsequent phone calls revealed that the part may or may not be manufactured ever again, and the dealership suggested I buy a refurbished part on ebay and have it installed at a local repair shop at my cost --- but that would null the warranty, and seemed risky to me. I asked the dealership to buy my car and they offered me $5k less than fair market value-so I declined. Opened a case at GM and they also had no answer, and offered to give me "points" to buy another GM car. Havent had use of the car since because I'm afraid to drive it with the car revving forward and at the next moment losing power. My car has been sitting in the dealer's lot for over 3 months, while I continue to pay registration, insurance and watch the value of the vehicle decline. Dangerous and GM will not buyback or rectify!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 2, 2024 · Electrical, Transmission · TN

My car is lurching very dramatically while on battery-only. Especially over 35-40 miles an hour. I was run off the road last week and am becoming fearful for my safety in this car. I have heard that there may be something wrong with the battery or. BECM.

Filed Dec 31, 2023 · Electrical, Engine · CA · crash

I bought my car and I had no idea about a known issue that this car has. Unsuspecting and trusting, I noticed my car had a reduced propulsion and it would like lose power and just slowly jerk and then really drastically reduce speed without anyway to fix it and on the freeway I got scared as I have never in my life has this happen in any car. So it happen a couple more times and I took a picture of it and took it to the dealership where I purchased it. They told me they couldn’t do l as they can’t repeat the issue. Well that only usually happens when I’m driving but now it’s more. The propulsion thing loses power and I as a driver going up a hill or anywhere now will lose speed and it’s dangerous, I feel like I may not make it home and I took it to the dealership many times and they told me there’s no issue. I took it again recently now that I’m out of warranty because it also had some high voltage issue and a sensor coolant issue that misreads. I like the car but very unhappy about dealership and manu not fixing this issue that every volt owner I talk to has, read about. I lose power, my car randomly heads up when it’s been cold all night and not driven now I have the same issues. I have the same issues and I use 91 gas, I have inspected my car and I had to learn about cars or more than I ever did which was like zero all because of this car. I even took it to the dealership 3-4 times (documented) to get it fixed and they just said there isn’t anything wrong nor did they say there’s a known issue and watch out for this or that. I had to look up the issue and learn about it on my own. Very dangerous date happening this is happening now almost everyday but was frequent 1.5 years ago but last 8 months it’s like the standard. I’m afraid my car will lose power on freeway, which it does and I have to take toll to stay away from others for everyone’s safety

Filed Dec 17, 2023 · Driver assistance, Fuel system · GA

Consistent BCEM failure with volt. Power Reduced even if battery has full charge and gas is in tank. Forward Collision made unavailable without reason whilst driving. I rely on the forward collision system while driving at night in my area because of drivers cutting each other off constantly, so losing this feature without knowing why it failed feels unsafe to me. Forward collision would also activate when no vehicle is infront of me causing the car to suddenly stop and jerk on the road. Propulsion power is reduced is an extremely common occurrence in my volt. It happens randomly while driving and even while charging. When I'm on the highway the car would slow down when the warning came on; even with cars right behind me. I'm scared one day the car's system will cause an accident because of it's unpredictability. Regular maintenance has been performed and no issues have been found. The problem continues to persist.