Chevrolet Volt loss of power problems

Filed Nov 2, 2026 · Electrical, Engine · UT

My 2018 Chevy Volt is experiencing the EXACT same symptoms as GM's Battery Energy Control Module (BECM) Warranty Extension Program N232432680 AND Program N202307990 AND TSB 19-NA-206. My vehicle falls within the guidlines of affected vehicles, yet GM will not honor their program specifications. My vehicle has stalled while driving on the highway, not started, reduced power, and will not charge or depletes a full charge within 30 minutes. I stalled while driving 75 mph on a freeway. My car also would not allow me to shift into park while returning home, then tells me to shift into park when I am trying to tleave for work. GM tells me that "Your VIN does not fall within the repair requirements, even though your vehicle exeriences everything taking place and meets the standard requirements." The dealership tells me that I have to take it up with GM. I have children I drive to school, I drive to work, and I do not think that something of this nature, with the EXACT SAME symptoms that GM claims is happening, with the EXACT SAME codes related to the issue, with very possible safety issues being experienced should be overlooked. This has been happening for months, and I have been trying to explain to GM and the service department at the dealership what is going on, they have proof of what is going on, but I do not qualify because of my VIN even though, as stated by GM, "This specific program extends coverage to 15 years or 150,000 miles regardless of whether your specific VIN shows an active safety recall."

Filed Oct 24, 2026 · Electrical, Fuel system · UT

While driving through a canyon to get home, my check engine light came on and I saw the message "Propulsion Power Reduced" on my dash. The speed limit on that road is 65 mph, and I lost power going up a hill and went from 65 mph on cruise control to 48 mph. There are a lot of cars on that road, and it could've caused a serious accident. My vehicle does exactly what the GM extended coverage describes and is within the parameters, but somehow my vehicle does not qualify. This could've been bad on that road is it was raining or snowing.

Filed Oct 20, 2026 · Engine · 124,000 miles · OR

The contact owns a 2017 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the vehicle suddenly lost power. The check engine warning light illuminated, and the message "Propulsion Power Reduced" was displayed. The manufacturer was notified of the failure. The failure mileage was 124,000.

Filed Oct 9, 2026 · Electrical, Fuel system · NC

My 2017 Chevrolet Volt, with 97,758 miles, experienced a failure that rendered the vehicle inoperable. The vehicle would not start or operate normally. The vehicle was taken to an authorized Chevrolet dealership for diagnosis. After several days, the dealership confirmed that the Battery Energy Control Module (BECM) had failed. The dealership quoted approximately $2,500 for replacement, including parts and labor. This failure presents a serious potential safety concern because BECM malfunctions can result in loss of propulsion, reduced power, or an inability to restart the vehicle, potentially leaving drivers stranded in unsafe locations. General Motors has previously recognized BECM failures in certain Chevrolet Volt vehicles and established a special coverage adjustment for affected vehicles. However, despite my vehicle experiencing the same diagnosed component failure, GM informed me that my VIN was excluded from the coverage program. I contacted General Motors directly and opened a case. GM confirmed that my repair would be considered an out-of-pocket expense and advised me to report the failure to the federal safety agency. I believe this failure warrants investigation because vehicles experiencing the same defect should be evaluated regardless of whether their VINs are currently included in GM’s existing special coverage program. The failed BECM has been diagnosed by an authorized Chevrolet dealership. The vehicle’s current repair status and availability for further inspection can be confirmed with the servicing dealership.

Filed Jul 21, 2026 · Electrical, Fuel system · WA

In March 2026, our 2017 Chevrolet Volt (89,300 miles) would not charge nor start, and had to be towed to an authorized Chevrolet dealership in Portland, Oregon. The dealership diagnosed an internal fault in the Battery Energy Control Module (BECM) producing U26XX diagnostic trouble codes, per GM bulletin #18-NA-261, and replaced the BECM under GM Special Coverage N232432680 — GM's field remedy for a known BECM defect affecting 2016–2019 Volts that causes reduced power, no-start, or no-charge conditions (the subject of the federal safety agency investigation PE23022).The remedy failed immediately. On the day the vehicle was returned to us (March 26, 2026), the check engine light illuminated while driving home on public roads, and the vehicle failed to charge that same night — the identical condition it had before. It was towed back to the dealership. The dealership's second work order confirms in writing that the vehicle "will not start after previous repairs and is having the same issues," and attributes the failure to the high-voltage battery contactor. The dealership informed us the part is no longer produced and cannot be obtained, advising that the vehicle be scrapped. Safety concerns: (1) after the repair, the dealership returned the vehicle to us as fixed, and we drove it approximately 26 miles home on public highways in traffic, unaware the defect was still present — the check engine light illuminated during that drive. This defect is the subject of the federal safety agency investigation PE23022 into sudden loss of propulsion, we unknowingly operated a defective vehicle in conditions where that failure could have occurred at highway speed; (2) GM's official field remedy for this known defect (Special Coverage N232432680) failed within hours of being performed; and (3) the parts required to complete the remedy are reportedly discontinued, leaving a known safety defect permanently unrepairable. Supporting documents uploaded: dealer repair orders, and the GM warranty history of the N232432680 repair

Filed Jul 6, 2026 · Electrical, Fuel system · TX

The car suddenly lost power and produced error messages on the screen. I had to quickly change lanes to get out of traffic on the highway. My dealer diagnosed the issue as a BECM malfunction and quoted a repair cost of approximately $3500. However, due to my car originally being registered in California, this failure is not covered under GM Special Coverage Bulletin N232432680 (issued March 2024), which provides an extended warranty for BECM issues on affected 2016-2018 Volts up to 15 years or 150,000 miles. My VIN does not qualify for this coverage despite the vehicle being within the model years affected by known BECM soldering/connection failures. This appears to be part of a broader pattern of BECM defects in 2016-2019 Volts that can lead to sudden loss of propulsion, as previously investigated by the federal safety agency. GM should extend coverage or issue a recall for all affected vehicles, as this defect compromises vehicle safety and leaves owners with expensive out-of-pocket repairs for a known issue.

Filed Jun 30, 2026 · Fuel system · TX

The Battery Energy Control Module (BECM) on my 2016 Chevrolet Volt has failed. The vehicle and the component are currently located at my home address and are available for inspection upon request. As of writing this now. This failure caused the vehicle to enter a "reduced power mode" and subsequently resulted in a no-start and no-charge condition. The sudden loss of propulsion power presents a severe safety and crash risk, as the vehicle can lose motive power and stall unexpectedly while in transit. Prior to the complete failure, the vehicle displayed a Check Engine Light and a "Reduced Propulsion Power" message on the dashboard. The local Chevrolet dealership has inspected the vehicle, pulled the associated diagnostic trouble codes, and officially confirmed that the BECM has failed. General Motors has already acknowledged this specific safety defect through Special Coverage Bulletin N232432680, which extends BECM warranty coverage to 15 years or 150,000 miles to prevent sudden loss of propulsion. However, GM corporate and the dealership are refusing to honor this bulletin. They are denying coverage due to an administrative database flaw because my vehicle's under-hood VECI label designates it as an original California (CARB/PZEV) vehicle, GM's system excluded my VIN from the Special Coverage bulletin automation. Furthermore, because the vehicle is currently registered in a non-CARB state (Texas), the original CARB warranty is considered void. GM is using this internal database loophole to deny repairing a documented safety defect.

Filed May 1, 2026 · Acceleration, Fuel system · NC

I was driving my 2018 Chevy Volt at about 30 mph on EV mode. The battery was at 50%, the car was performing normally. Then the battery jumped to 100%, the check engine light came on, and the vehicle lost power. I was in rush hour traffic and unable to get the vehicle to go faster than 5-10 mph. I switched to "normal" mode to engage the gasoline engine, hoping this would help but it did not. The gas engine RPM fluctuated wildly and did not restore the ability to accelerate the vehicle. I was still unable to go faster than 5-10 mph. I was a few blocks from home and managed to get home safely. The engine code was P1E00. I put the vehicle on the charger and it seemed fine the next day. This exact situation I ran into - reduced engine power - is addressed in Special Coverage N232432680, which includes this vehicles VIN. I took the car to the GM dealer today and they are telling me that the car is fine, they can find no problems. I mentioned that this issue is covered under Special Coverage N232432680, and was told that unless they can reproduce the issue in the shop, that they cannot apply Special Coverage N232432680.

Filed Mar 20, 2026 · Electrical, Fuel system · MI

Failure of Battery Energy Control Module (BECM), within the high voltage battery. Vehicle is unable to charge and sets “reduced power” message. GM released special coverage bulletin for this issue (N232432680), but this vehicle is not listed due to which state it was registered. Continued failure of the BECM will lead to inoperability of the vehicle.

Filed Mar 11, 2026 · Fuel system · OR

After experiencing loss of power and loss of propulsion on the highway, took the car to Tropical Chevrolet in Miami Shores, FL. after diagnosing the car for $287.37 (credited to the estimate total of $3101.20), the dealership replaced the Battery Energy Control Module and bled the battery pack cooling system. We paid the bill ($2665.89). On January 4, 2026 the check engine light came on again when the propulsion was reduced again, while driving on a highway. Tropical reported that the cause of the failure was their failure to replace or do the original repair at all. They replaced the exhaust gas recirculation valve and refilled the cooling system. The parts should be covered by warranty. We filed a claim with GM 2 months ago and still have not been reimbursed.