Chevrolet Volt won't shift problems

Filed Jan 8, 2026 · Electrical · WA

Following a day trip involving sub-freezing temperatures and full depletion of the traction battery, the vehicle was plugged in at home and appeared to be charging. The following morning, I enable the preheat via the remote before leaving the house for work, and notice the CEL/MIL before starting the car. Car was cold, charging indicator was flashing green as if it was accepting charge. I went to investigate and was met with the following list of codes: P1E00, U2603, U2604-U2606, U2617-U2624, P1FD2, P1FD3, P3042, C326C, P0096. Car turns on but seems to only be accessories; no power steering. Seems like the state of charge indication kept transitioning from empty to full. I unplugged the car to see if it could still drive, but no luck. getting "Shift to Park" when I put it in drive. Switching to HOLD does not engage the engine. After plugging it in again, the car no longer receives charge and simply holds the orange charge indicator light. In an attempt to get the car into limp mode, I tried clearing the codes, but no luck. After reading the codes again in the afternoon, the following codes posted: P1E00, U2622, U2623, P1FD4, P0AFA. These codes and behavior are consistent with the following NTSB service documents, which call for the replacement of the BECM: Special Coverage N232432680 Technical Service Bulletin 18-NA-261 However, the vehicle in question does not appear to be one of the 19,000 vehicles covered under the special coverage, per GM’s warranty look-up. The vehicle has not yet been serviced for the above events, but it is assumed the BECM is failing, which is available for inspection. My safety was not put at risk this time, but it is possible for the BECM to fail in an unsafe manner. Additionally, the associated repairs are costly since the BECM is not easily accessible, requiring lifting the car and removing the entire traction battery.

Filed Jan 6, 2026 · Electrical, Fuel system · IL

The BECM (Battery Energy Control Module) failed. The vehicle illuminated the MIL and the driver display to show a "Reduced power". When restarted, the display showed "shift to park", which I did several times. After a couple of restarts it displayed the "Reduced power" message, but would not go into drive. THE MIL was illuminated the entire time. Through numerous key cycles I got the VIN operable and took it to the dealer for repair. The BECM part is at the dealer or on its way back to GM as a core return. While this occurred while I was leaving my garage, it could have occurred in traffic, which would put me or others at risk. The problem was investigated by my local dealer (Currie Chevrolet in Forest Park, IL) and it was determined to be both a bad Battery Energy Control Module (BECM) and a bad shifter assembly. The shifter had been replaced (or repaired?) for an earlier Shift to Park failure per TSB 23-NA-119. The dealer kept the BECM as a core. I have pictures of the core. The dealer or GM should have that core. The above described warning lamps and messages and systems first appeared at the time of the event that lead me to take it other dealer ASAP. Note the condition and model year is described in GM special coverage letter "N232432680 Battery Energy Control Module Malfunction". the federal safety agency investigation PE23022 lead to this coverage letter. Per GM, while my vehicle experienced the conditions and is in the model year coverage of the letter, its VIN is not covered. I think the federal safety agency should re-open the investigation and consider a recall. There could be other VINS susceptible this failure condition. There could be operators of those VINs who cannot afford the expense (~$3000 or more) or downtime of the repair, and will keep operating the vehicle, putting people at risk again. If a recall is not supportable, I'd request that the VIN list be expanded to cover all possible defective BECMs.

Filed Aug 7, 2025 · Electrical · CA

When shift lever is moved to Park, the car often does not recognize it is in Park and can't be shut down. It takes a lot of time of moving the selector in and out of Park to finally get the car to recognize it is in Park. During an occasion when the car would not go into Park, the car ran for hours while the driver was at work. This seems to be a known issue (micro switch) with this model. This is available for inspection upon request. Safety is at risk because this condition leads to not being able to shut the car down, which leads to the potential for a dead battery and getting stranded. While I have not yet had my car's problem reproduced or confirmed by a dealer or independent service center, there is a lot of evidence in online forums of the prevalence of this problem. The vehicle/component has not yet been inspected by the manufacturer, police, insurance representatives or others. There weren't any warning lamps, messages or other symptoms of the problem prior to the failure as long as we've owned the vehicle. We purchased this vehicle less than a week ago, on August 2, 2025. The issue presented itself once on our test drive and again intermittently in the six days we've owned the vehicle.

Filed Aug 4, 2025 · Electrical, Fuel system · TN

On [XXX], our 2018 Chevy Volt experienced a critical BECM (Battery Energy Control Module) failure while being driven by our [XXX] daughter. The failure caused the vehicle to enter limp mode, resulting in a severe loss of power and the inability to shift properly. Most alarmingly, the brakes failed to function correctly—despite being fully engaged, the car continued to move forward at a red light, placing our daughter in immediate danger. She was only able to safely stop the vehicle by maneuvering it off the road into a parking lot. This BECM defect is a well-documented issue for Chevy Volts from 2016 to 2018. However, Chevrolet has refused to cover our VIN under the existing special service bulletin, despite our vehicle using the same faulty part number as those included in the recall, and has provided no explanation for this exclusion. As a result, we are being forced to pay $2,100 out of pocket to replace a part that GM knows is defective. This is an unacceptable financial burden for a safety-critical issue. GM should immediately issue a recall for all vehicles equipped with this faulty part number to ensure the safety of all drivers and prevent further undue costs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 10, 2024 · Electrical, Fuel system · WI

Automation-On 10.1.24 my car stopped working. It would turn on, but would not shift. It was also showing my EV was fully charged but the EV miles read 0. My husband came and plugged my car in and saw that when I turned the car on it read "shift to park" Also the codes from my OnStar app read "Lithium Ion Battery"- Issue found in High Voltage battery. "12 volt battery needs attention" 10.2.24 we called GM to report issues and referenced N232432680 (BCEM). We were informed that even though we can read diagnostic reports on OnStar it needed to be confirmed from a certified GM dealership that they could not confirm this is the warranty issue if they did not 1st had the certified dealership share their diagnostic report. Bergstrom shared it sounded like BECM that is under warranty. They continued to share it didnt look good and the VIN was not in the system to be covered. Shared the minimum amount we would pay was $440 for the 2 issues for labor/diagnostics.10.4.24 we called GM to file a report we were given a case manager to work our case. 10.8.24 received call from case manager shared no warranties seen on file. I asked for this to be documented and emailed to me, I was told she could not share this information other than this phone call. Bergstrom called saying the car was ready to pick up, cleared codes/no issues, drove 26 miles with no codes. Shared GM never seen/heard anything like this and had no advise/help to offer. Shared only charged for 1 hour of labor. Asked for trade in for car. Was given price $1,200 under trade in value. Cause due to car not safe, potential issues. No documentation shared, nothing to show issues, car is clean/cleared to drive they had no answer than my car was fine but was not able to give lowest amount for trade in due to issues

Filed Oct 4, 2024 · Fuel system · AZ

Our BECM failed while we were driving. It went into limp mode, not allowing the car over 35mph and with no AC in 109 temps. It was a very scary experience. This is a known issue, but the dealer said it isn’t covered under special warranty.

Filed Aug 7, 2024 · Electrical · CA

Car had not properly charged for the last 2 nights despite saying it was charging the entire time. When leaving my residence the car suddenly stopped working and I had to pull off to the side of the road with no power. The car was then stuck in park and would not turn off.

Filed Mar 7, 2024 · Airbags, Electrical · CA

Chevy Volts from 2016 - 2019 all have a manufacturing defect which can prevent the driver from powering - the error message is "Shift to Park". GM released a Volt Service Bulletin in May 2021 but offered no assistance to replace the defective part. On [XXX] I was driving home on [XXX] headed [XXX] from Santa Cruz in fair weather in the afternoon. This highway can be dangerous with limited shoulders and poor visibility, making it an unsafe place to pull over. While traveling at about 55 mph, the car made an alert sound and illuminated the check engine light and presented a message "Shift to Park". I was running out of room on the shoulder to pull off safely so I had to make the quick decision to pull off to the left-hand shoulder. I followed the instructions on the display which said to shift into park, followed by shifting back into drive. During this time I had my foot on the brake, but after removing my foot from the break, the vehicle began to roll towards traffic, so I put my foot back on the break. I tried powering the car off/on multiple times and tried to get the car to go back into drive but was unsuccessful. Eventually, I put the car back into park, called a tow truck driver, and waited for over an hour to have my car safely towed off [XXX]. Prior to this, I had not experienced any of these or similar symptoms. An OBD code scan was done (screenshot attached). Once at the Chevy dealership, they confirmed that the car could, at that time, shift into park and were not able to reproduce the "Shift into Park" issue. However, they reported that the car was revving high and the transmission would not shift into the proper gear ratio. The dealership was not able to fully diagnose the problem and instead suggested to replace the entire transmission as assembly and then continue investigating. We reached out to the manufacturer, Chevrolet/GM, about the issue(s) and were ed case # [XXX] while they work with the dealership to investigate further. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F

Filed Dec 8, 2023 · Electrical, Engine · VT

The Battery Energy Control Module needs to be replaced (BECM). The car is available to be inspected at Key Chevrolet in South Burlington, VT. The car was parked when it failed. The car wouldn't start (lights on the dashboard came on) and it wouldn't turn off. I got a "shift to park" error message, regardless of which gear I was in. The car wouldn't go into Drive to go forward with either the drive battery or the gas generator. I had the car was towed to the dealership. It was inspected and diagnosed by them. When they did the diagnosis, they said the BECM had failed and there were cells in the drive battery that needed to be replaced. The BECM failure is a common problem with Chevrolet Volts and is covered by the Voltec warranty. There were no warning lights or other warnings (e.g., reduced propulsion) whatsoever. The car had shut off like normal but would not start or turn completely off. I was fortunate to have had the BECM fail while the car was parked. My understanding is that BECMs can fail while the car is moving and the power will stop and you won't have any control.

Filed Dec 5, 2023 · Electrical, Fuel system · OH

The car started stating "put in park" every time I would try to put the car in drive. I would shift back and forth from park to drive over and over and I could get it to clear. One time it lost all power and had zero control. Sat on the side of the road for an hour. Shifting back and forth until it stopped and let me engage the drive. The last time it happened in a parking lot and it would just say"shift to park" I couldn't get it out of park. Had to have the car towed. Tow driver had to drag the car on the flat bed with a wench because it was stuck in park. Had the vehicle repaired. Replaced an electronic control module that had previous service bulletins on but GM would not cover the repairs. I was lucky I was not injured our involved in a wreck when I experienced these issues. I was not aware I could file a report about this until I read there was an open investigation on the same issue I had.