2009 Dodge Caravan problems

What is wrong

The braun corporation is recalling certain model year 2008 through 2010 chrysler town & country and dodge caravan mobility conversions which were altered by braun between january 21, 2009 and march 19, 2010. During conversion, the chassis was raised and the floor was lowered to accommodate wheelchair accessibility features. In raising the chassis, the rear spring hats come into closer proximity to the rear tires. In rough or aggressive driving situations the tires may intermittently contact the rear spring hats.

Risk

Contact between the tire spring hat may wear a hole in the tire over time. This may result in loss of vehicle control in the event of tire pressure loss increasing the risk of a crash.

Remedy

Braun will notify owners and repair the vehicles free of charge. The safety recall began on june 4, 2010. Owners may contact braun toll-free at 1‑800‑488‑0359.

Recall number 10V164000 · Recall details

What is wrong

The braun corporation is recalling certain model year 2008 through 2010 chrysler town & country and dodge caravan commercial entervans which were altered by braun between january 21, 2009 and march 19, 2010. During conversion, the chassis was raised and the floor was lowered to accommodate wheelchair accessibility features. In raising the chassis, the fuel fill pipe comes into closer proximity to the left rear tire. In rough or aggressive driving situations, the tire may intermittently contact the fuel fill pipe.

Risk

Contact between the tire and fuel fill pipe may wear a hole in one or the other components over time. This may result in loss of vehicle control in the event of tire pressure loss, or a vehicle fire in the event the fuel pipe is compromised.

Remedy

Braun will notify owners and repair the vehicles free of charge. The safety recall began on june 4, 2010. Owners may contact braun toll-free at 1‑800‑488‑0359.

Recall number 10V148000 · Recall details

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the federal safety agency to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to the federal safety agency, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V‑530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V‑115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a the federal safety agency order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize the federal safety agency's limited resources to best accomplish the agency's safety mission, the petition is den

DP14004