Dodge Charger fuel leak problems

Filed Sep 5, 2026 · Fuel system · AZ

The Chapman Dodge service department has diagnosed the vehicle with an active, leaking fuel pump assembly and provided a repair estimate of $1,600.00. Stellantis Corporate has offered a "goodwill" gesture of only $200.00, leaving me with a $1,400.00 out-of-pocket bill. I have formally rejected this baseline offer.An active fuel leak on a 485-horsepower performance vehicle is an immediate, catastrophic fire hazard. A fuel pump module is a lifetime structural component—not a wear-and-tear item—and a complete material failure at 41,000 miles is an egregious manufacturing defect. Furthermore, because this vehicle is well under the 5-year/60,000-mile mark, it should be heavily considered under powertrain safety accommodations.Because an active fuel leak represents a severe risk to life and property, I cannot and will not safely drive this vehicle off their lot until it is repaired. Dodge Corporate and Chapman Dodge should not refuse to close the remaining $1,400.00 balance via manufacturer or dealership goodwill funds,

Filed Mar 9, 2026 · Fuel system · OH

The car is a 2022 with only 17k miles it started by smelling like gas really bad in the car and outside of it and eventually leaking gas badly so i took it into the dealership and it turns out there is a defective weld on the fuel filler neck and it had been leaking for a while. It was a major fire hazard not just for myself, but others on the road. Filling my garage up with fuel vapors and it was 1 spark away from catching on fire. So I contacted Stellantis to see if they would make it right and they refused to and told me things like that happen. It doesn't sit right with me. There was no warning lamps , messages anything of that sort. The leak was directly next to the exhaust as well.

Filed Dec 31, 2025 · Fuel system · AZ

- Crack at base of gas tank where fill tube attached causing fuel vapors around the car and a possible fuel leak. - Yes by independent service center. -White residue was built up around the crack in the fill tube. Independent service center confirmed the cause as - "Found plastic fuel tank leaking around the filler nipple that is plastic welded in. Also, the auxiliary pump has a dark spot like it may be sleeping as well. Need to replace the fuel tank and would recommend replacing the fuel pumps as a precaution." Final repair charge was $4437.03. Independent service center replace fuel tank and fuel pumps with Mopar parts from the closest Dodge dealer. In review with the service center they stated that fuel was dripping onto the heat shield above the exhaust and could have caused a fire. - No other agencies inspected the issue or repair. Attached a copy of the invoice and two pictures of the worn/cracked fuel tank. - No warning lights, just the smell of gasoline in my garage about 5 weeks ago. The smell would be the strongest when the tank was full but when below half tank the smell was not present.

Filed May 6, 2025 · Fuel system, Suspension · FL

My car was leaking gas from the fuel pump and I guess my car from the backseat almost caught fire cause I seen smoke coming from the back seat behind the driver. I went to two Dodge dealerships to let them know about this incident that reason why my fuel pump caught on fire because Dodge put the negative and the positive wire close to each other on the fuel pump, which could cause a fire or your car to explode. I let Dodge know about this incident and let them know that my car almost caught on fire smoke came out and I could’ve died. They totally brushed me off and brushed off my incident. I told him hey this is a recall that you guys need to take serious before someone really gets hurt from Now. I am carless with no vehicle to drive. No way to pick up my daughter from school. I need you guys help ASAP so I could be able to father my child and be able to go to work to provide for my child. Thank you.

Filed May 2, 2025 · Fuel system · VA

Smelled fuel leaking inside car towards rear seat. Electrical connector to fuel pump had fuel surrounding it (located under back seat, on left side of car). Upon disconnecting connector, I notice two right most pins of connector (on pump) had a burn mark which cause a hole and allowed fuel to leak out.

Filed Feb 27, 2025 · Fuel system · TN

Leaks fuel from top of fuel pump when parked, car full of gas fumes. It poses an immediate threat to my safety and my children. No warning lamp

Filed Jul 15, 2024 · Engine, Fuel system · 168,237 miles · VA

The contact called on behalf of a customer who owns a 2013 Dodge Charger. The contact who is an independent mechanic, stated that the vehicle was driven to his place of business; however, upon arrival the vehicle was smoking with an abnormally strong fuel odor. The contact stated upon inspecting the vehicle, the contact became aware that the fuel pump was dry, and fuel was leaking onto the ground from the side of the fuel tank. The contact stated that upon removal of the exhaust, the contact became aware that fuel was leaking from the exhaust pipe. The contact stated that when the muffler was removed, there was fuel pouring out of the muffler. Additionally, the contact stated that there was a hole in the heat shield and the fuel tank. The contact stated that the vehicle had two mufflers and no resonators installed. The contact stated that the fuel tank, muffler, exhaust pipe, and heat shield needed to be replaced. The vehicle was currently being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 168,237.

Filed May 14, 2024 · Fuel system · IL

The auxiliary fuel pump, located inside the passenger cabin under the right rear passenger seat, has been leaking fuel, leading to discoloration of the part and a strong scent of fuel inside the cabin. Additionally, a pool of gasoline sat atop the pump only separated by a thin plastic lid from the electrical cables leading to the battery in the vehicle's trunk. This gasoline could be ignited by the a spark or a short circuit. The Charger and Chrysler 300 from 2005 to 2023 has this design. I don't know if the auxiliary fuel pump cover is any more robust or fire suppressant than the 2014 model I possess. The dealer I took my vehicle to could not find the source of the leak and claimed to not being able to smell the obvious odor of gasoline permeating the vehicle cabin. I found out about it on You Tube, and then showed the obvious fuel link to the technician when I took the vehicle to them a 2nd time.

Filed May 4, 2024 · Fuel system · LA

Fuel leak at filler neck to fuel tank at fuel tank

Filed Oct 4, 2022 · Fuel system · NC

Strong smell of raw gas when fuel tank is 1/2 full(+). The smell is inside and outside the vehicle (mostly on driver's side near back door & wheel well) whether vehicle is running or not. The smell is just as strong outside as inside. When fuel level falls below 1/2 tank, the gas smell reduces. Removed rear seat, drivers side fuel tank cover have a crack in it. A puddle of gas was sitting on top of the fuel pump & a brown burn mark near the electrical plug. Google search: many complaints of fuel pump leakage. The fuel pump still works, it pumps/primes when the key is switched to the ACC position & the car cranks when pushed to turn on. The issue is fuel is leaking from the pump upward when tank is at or above 1/2 full. Tried to order new pump from local dealership (Northpoint Chrysler Dodge) who said it calls for a different part#, is out of stock with no expected date of availability, & is not available anywhere within their network. September 8th, went online to a site that provides OEM parts (World Parts Direct). They said the part was not available until September 23rd. Since they provided an availability date, I ordered the part & waited. The delivery arrived on the 29th. What arrived have a totally different part# with an electrical connector that must replace the factory connector. In order to install, the factory harness must be cut, spliced, soldered, & heat shrink a rubber sleeve to protect the soldered wires. I questioned the different part#, was told that is what their supplier sent, it is OEM, & should work. The new connector came with a diagram showing to switch the 2nd & 3rd pin from the factory connector into the new connector. The factory (+) & (-) pins are side-by-side, the new connector separates them. Fuel pump wiring is faulty, dangerous. Raw gas encountering electrical connectors is unsafe, can be explosive or deadly. Not inspected/repaired by dealer or mfg, no CEL, avail for inspection if needed. Let's not wait for someone to die for recall.