Dodge Charger fuel pump problems

Filed Sep 5, 2026 · Fuel system · AZ

The Chapman Dodge service department has diagnosed the vehicle with an active, leaking fuel pump assembly and provided a repair estimate of $1,600.00. Stellantis Corporate has offered a "goodwill" gesture of only $200.00, leaving me with a $1,400.00 out-of-pocket bill. I have formally rejected this baseline offer.An active fuel leak on a 485-horsepower performance vehicle is an immediate, catastrophic fire hazard. A fuel pump module is a lifetime structural component—not a wear-and-tear item—and a complete material failure at 41,000 miles is an egregious manufacturing defect. Furthermore, because this vehicle is well under the 5-year/60,000-mile mark, it should be heavily considered under powertrain safety accommodations.Because an active fuel leak represents a severe risk to life and property, I cannot and will not safely drive this vehicle off their lot until it is repaired. Dodge Corporate and Chapman Dodge should not refuse to close the remaining $1,400.00 balance via manufacturer or dealership goodwill funds,

Filed Dec 31, 2025 · Fuel system · AZ

- Crack at base of gas tank where fill tube attached causing fuel vapors around the car and a possible fuel leak. - Yes by independent service center. -White residue was built up around the crack in the fill tube. Independent service center confirmed the cause as - "Found plastic fuel tank leaking around the filler nipple that is plastic welded in. Also, the auxiliary pump has a dark spot like it may be sleeping as well. Need to replace the fuel tank and would recommend replacing the fuel pumps as a precaution." Final repair charge was $4437.03. Independent service center replace fuel tank and fuel pumps with Mopar parts from the closest Dodge dealer. In review with the service center they stated that fuel was dripping onto the heat shield above the exhaust and could have caused a fire. - No other agencies inspected the issue or repair. Attached a copy of the invoice and two pictures of the worn/cracked fuel tank. - No warning lights, just the smell of gasoline in my garage about 5 weeks ago. The smell would be the strongest when the tank was full but when below half tank the smell was not present.

Filed Sep 30, 2025 · Electrical, Engine · 97,000 miles · CO

The contact owns a 2016 Dodge Charger. The contact purchased the vehicle, and the vehicle was taken for the Emissions Test; however, the vehicle failed the Emissions Test. The contact notified the dealer and was informed that some unknown sensors had been replaced, and to allow for a week for the vehicle to adjust. The vehicle was taken to the dealer, and the vehicle failed to start. The vehicle was not diagnosed. The contact stopped by the dealer to pick up the vehicle. The vehicle was restarted, and the contact drove the vehicle to the residence. The contact stated that in the evening, the vehicle failed to restart. After several attempts, the vehicle restarted. The contact stated that on a separate occasion, while driving 40 MPH, there was white smoke coming from the rear of the vehicle. The contact stated that there was a plastic burning odor and an abnormal fuel odor entering the vehicle through the A/C vents. There was no warning light illuminated. The vehicle was taken to the dealer. The contact requested that the vehicle have a full inspection, and the dealer refused. The contact was informed that the spark plugs and fuel pump needed to be replaced. The vehicle remained at the dealer unrepaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,000.

Filed Jul 16, 2025 · Electrical, Fuel system · TX

Vehicle: 2013 Dodge Charger R/T I’m reaching out because my car has been showing signs that seem to match the symptoms of the V62 recall that FCA issued for the fuel pump relay issue. I have a 2013 Dodge Charger R/T with the 5.7L HEMI engine. Lately, the car has been having trouble starting, especially after it’s been driven and sits in the heat. Sometimes it cranks but won’t turn over, and other times it randomly dies or stalls when I’m coming to a stop. It recently sat for a couple of days and then started again like nothing happened. This keeps happening on and off, and I’ve noticed it’s worse when it’s really hot outside or after it’s been driving a lot I took it to the dealership and they said my specific VIN isn’t part of the recall, but I wanted to report this because it really seems like the same issue. From what I’ve read, the V62 recall had to do with a faulty fuel pump relay that’s built into the TIPM and causes exactly these kinds of problems. I understand not all vehicles were included, but since I’m having the same symptoms and my car matches the year, make, and engine that recall applied to, I think it’s something that should be looked into. I’d really appreciate it if this could be reviewed. I just want to make sure my vehicle is safe and functioning properly, especially since the stalling can be risky depending on where and when it happens.

Filed May 6, 2025 · Fuel system, Suspension · FL

My car was leaking gas from the fuel pump and I guess my car from the backseat almost caught fire cause I seen smoke coming from the back seat behind the driver. I went to two Dodge dealerships to let them know about this incident that reason why my fuel pump caught on fire because Dodge put the negative and the positive wire close to each other on the fuel pump, which could cause a fire or your car to explode. I let Dodge know about this incident and let them know that my car almost caught on fire smoke came out and I could’ve died. They totally brushed me off and brushed off my incident. I told him hey this is a recall that you guys need to take serious before someone really gets hurt from Now. I am carless with no vehicle to drive. No way to pick up my daughter from school. I need you guys help ASAP so I could be able to father my child and be able to go to work to provide for my child. Thank you.

Filed May 2, 2025 · Fuel system · VA

Smelled fuel leaking inside car towards rear seat. Electrical connector to fuel pump had fuel surrounding it (located under back seat, on left side of car). Upon disconnecting connector, I notice two right most pins of connector (on pump) had a burn mark which cause a hole and allowed fuel to leak out.

Filed Mar 5, 2025 · Electrical · 150,000 miles · GA

The contact owns a 2009 Dodge Charger. The contact stated that while driving at various speeds and while the vehicle was idling, the vehicle had shut off unexpectedly. The vehicle was restarted and operated normally, but the failure persisted. The contact replaced the spark plugs, battery, and fuel pump but the failure persisted. The cause of the failure was not yet determined. The contact stated there was a ticking sound coming from the engine compartment. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 150,000.

Filed Feb 27, 2025 · Fuel system · TN

Leaks fuel from top of fuel pump when parked, car full of gas fumes. It poses an immediate threat to my safety and my children. No warning lamp

Filed Jul 15, 2024 · Engine, Fuel system · 168,237 miles · VA

The contact called on behalf of a customer who owns a 2013 Dodge Charger. The contact who is an independent mechanic, stated that the vehicle was driven to his place of business; however, upon arrival the vehicle was smoking with an abnormally strong fuel odor. The contact stated upon inspecting the vehicle, the contact became aware that the fuel pump was dry, and fuel was leaking onto the ground from the side of the fuel tank. The contact stated that upon removal of the exhaust, the contact became aware that fuel was leaking from the exhaust pipe. The contact stated that when the muffler was removed, there was fuel pouring out of the muffler. Additionally, the contact stated that there was a hole in the heat shield and the fuel tank. The contact stated that the vehicle had two mufflers and no resonators installed. The contact stated that the fuel tank, muffler, exhaust pipe, and heat shield needed to be replaced. The vehicle was currently being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 168,237.

Filed Jun 4, 2024 · Engine, Fuel system · CA

I purchased a 2012 Dodge Charger shortly after tha it just stopped working. It was perfectly fine and then it just wouldn't start. It only turned on to accessory mode. The lights ,radio,ac, ect. turned on but the vehicle did no. The brake pedal was very hard couldn't be pushed down. On the dashboard a red lightning bolt symbol with two parentheses appeared. I got it towed the dealership send the problem was the battery and the key fob. I picked it up it was fine and then a few days later while driving on the highway it suddenly started to lose power and completely stopped. same red lightning bolt symbol appeared.I barely made it to the side of the road. I had my son with me. It was a very scary situation our lives were in danger as well as the other drivers behind me because of the sudden decrease in speed. I had to get it towed for the second time. The dealership said that they changed the fuel pump. It was fine after that then couple weeks later I noticed the check engine light come on for about half a day then turn off. 2 Days later I went to turn it on and it did not start, same red lightning bolt symbol appeared again. I got it towed to the manufacture dealership for a recall and they did diagnostic and are telling me that it is the starter switch. They didn't mention anything about the red lightning bolt and it still doesn't turn on