- Crack at base of gas tank where fill tube attached causing fuel vapors around the car and a possible fuel leak. - Yes by independent service center. -White residue was built up around the crack in the fill tube. Independent service center confirmed the cause as - "Found plastic fuel tank leaking around the filler nipple that is plastic welded in. Also, the auxiliary pump has a dark spot like it may be sleeping as well. Need to replace the fuel tank and would recommend replacing the fuel pumps as a precaution." Final repair charge was $4437.03. Independent service center replace fuel tank and fuel pumps with Mopar parts from the closest Dodge dealer. In review with the service center they stated that fuel was dripping onto the heat shield above the exhaust and could have caused a fire. - No other agencies inspected the issue or repair. Attached a copy of the invoice and two pictures of the worn/cracked fuel tank. - No warning lights, just the smell of gasoline in my garage about 5 weeks ago. The smell would be the strongest when the tank was full but when below half tank the smell was not present.
Dodge Charger fuel smell problems
110 of the 5,741 owner complaints about the Dodge Charger describe gas smell in the cabin, most of them for the 2011 model year.
- owner complaints
- 110
- worst model year
- 2011
- typical repair cost reported
- $800
- typical mileage
- 65,000
By model year
Often reported together
Fuel pump 36Fuel leak 31Check engine light 18Fire or smoke 7Stalling 5Warning lights 3Fuel gauge 3Won't start 2
Trouble codes mentioned
P0496 1P0456 1
What owners say
The contact owns a 2016 Dodge Charger. The contact purchased the vehicle, and the vehicle was taken for the Emissions Test; however, the vehicle failed the Emissions Test. The contact notified the dealer and was informed that some unknown sensors had been replaced, and to allow for a week for the vehicle to adjust. The vehicle was taken to the dealer, and the vehicle failed to start. The vehicle was not diagnosed. The contact stopped by the dealer to pick up the vehicle. The vehicle was restarted, and the contact drove the vehicle to the residence. The contact stated that in the evening, the vehicle failed to restart. After several attempts, the vehicle restarted. The contact stated that on a separate occasion, while driving 40 MPH, there was white smoke coming from the rear of the vehicle. The contact stated that there was a plastic burning odor and an abnormal fuel odor entering the vehicle through the A/C vents. There was no warning light illuminated. The vehicle was taken to the dealer. The contact requested that the vehicle have a full inspection, and the dealer refused. The contact was informed that the spark plugs and fuel pump needed to be replaced. The vehicle remained at the dealer unrepaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,000.
Leaks fuel from top of fuel pump when parked, car full of gas fumes. It poses an immediate threat to my safety and my children. No warning lamp
Says that my car is simply just dead smells like gas when trying to start up and shakes but doesn’t start up
Gas smells in vehicle recall no remedy vehicle smells unsafe. Health hazard concerns
My 2016 Charger has the same problem described in Emissions Recall UB4, Revision 5. When filling tank with gas, there is a very strong odor of gas. After about three days of driving, it dissipates. Revision 5 by added 2015 and 2016 Dodge Chargers, but I have been told that my vehicle is not included in that recall. It most certainly is a safety issue. Again, it has the exact problem as described in that recall. The gas smell is so strong, I cannot park it in the garage. I'm not sure if the federal safety agency issued the Revision 5, or Fiat Chrysler issued it.
The contact owns a 2019 Dodge Charger. The contact stated while driving at an undisclosed speed, there was an abnormally strong fuel odor on the interior of the vehicle. Additionally, the contact stated that while the vehicle was parked in the garage, the fuel odor was extremely strong. The vehicle was not diagnosed or repaired by an independent mechanic. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.
The contact called on behalf of a customer who owns a 2013 Dodge Charger. The contact who is an independent mechanic, stated that the vehicle was driven to his place of business; however, upon arrival the vehicle was smoking with an abnormally strong fuel odor. The contact stated upon inspecting the vehicle, the contact became aware that the fuel pump was dry, and fuel was leaking onto the ground from the side of the fuel tank. The contact stated that upon removal of the exhaust, the contact became aware that fuel was leaking from the exhaust pipe. The contact stated that when the muffler was removed, there was fuel pouring out of the muffler. Additionally, the contact stated that there was a hole in the heat shield and the fuel tank. The contact stated that the vehicle had two mufflers and no resonators installed. The contact stated that the fuel tank, muffler, exhaust pipe, and heat shield needed to be replaced. The vehicle was currently being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 168,237.
Headlights go out when replacing. Fuel smell in cab. Engine ticking Front wheels knocking on bumps Inspection done by police Could cause major wreck all of the above
Car has strong smell of gas inside. Seeing by the other reports here that there is a regular problem with the fuel pump causing this issue. Is a safety hazard for obvious reasons. Drive shaft failed last year at less than 60,000 miles, but luckily had it replaced under dealership warranty. Others have not been so lucky, as I can see in these reports. Like tons of other reports here, door panels are also warping and disconnecting from the inside of the car. A completely cheap and poor design, and am shocked to see that nearly EVERY problem I've experienced with this car is COMMONLY experienced by other owners of this car. No idea how there haven't been more recalls, it's criminal that owners of this vehicle are left to foot the bill (THOUSANDS of $$$) for all of its defects.
Related recalls
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- Chrysler (FCA US LLC) is recalling certain model year 2015 Dodge Challenger SRT and Dodge Charger SRT vehicles manufactured September 18, 2014, to February 5, 2015, and equipped with a 6.2L supercharged engine. O-ring seal and fuel rail crossover hose damage may result in the fuel rail hose connection leaking fuel.
- Risk
- A fuel leak in the presence of an ignition source such as hot engine or exhaust components increases the risk of a vehicle fire.
- Remedy
- Chrysler will notify owners and dealers will replace the engine fuel rail injector crossover hose, free of charge. The recall began April 23, 2015. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is R07.
Recall number 15V114000 · Recall details
Questions about the Dodge Charger fuel smell
Which Dodge Charger years have gas smell in the cabin problems?
The model years with the most reports are 2011 (46 complaints), 2010 (12 complaints) and 2016 (12 complaints).
How much does it cost to fix gas smell in the cabin on the Dodge Charger?
Owners who mentioned a price put the repair at about $800 (median of 6 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Dodge Charger?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history