Tl*the contact owns a 2005 dodge durango. The contact stated that when he added gasoline to the fuel tank, the automatic shutoff valve did not function and the fuel spilled out of the filler neck. The failure occurred every time the tank was full. The vehicle was taken to an authorized dealer who stated that the vehicle was not included in recalls 05v034000 (fuel system, gasoline:storage tank assembly:filler pipe and cap) and 09v003000 (fuel system, gasoline:storage:tank assembly). The vehicle was not repaired. The contact called the manufacturer and filed a complaint. The current mileage was approximately 43,200. The failure mileage was approximately 42,000. Updated 07/08/11 *bf updated 11/23/11
2005 Dodge Durango fuel system complaints
Page 15 of 26: complaints 401 to 430 of 751, newest first, as owners wrote them.
My 2005 dodge durango st started spewing fuel out the filler neck when I'm filling the tank. It usually occurs when the tank reaches about half full. I contacted chrysler and they told me my car isn't covered under any campaigns and I should take it to a local dealer to have repaired at my own expense. This condition is a serious safety condition every time I try to fill the fuel tank. I know there have been two related recalls of similar faults, but I don't think it's fair that chrysler won't stand behind this safety issue. I'm now always concerned for my safety when I have to fill my gas tank.
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, fuel would leak back out of the fuel tank. The contact referenced the federal safety agency campaign id number: 09v003000 (fuel system, gasoline:storage:tank assembly) but the vehicle was not included in the recall. The contact stated the fuel spitting out of the vehicle can cause a fire. The vehicle was not repaired. The failure mileage was 77,000. Updated 05/26/2011
When filling fuel tank, after automatic shutoff by pump the fuel tank spews fuel out. This is, apparently, a fairly common problem with dodge durangos.
My 2005 dodge durango splashes gas out of the tank when refueling. It has been diagnosed by the dealership and the gas tank needs to be replaced. This is an $1111 repair on an issue addressed in a limited recall. Why is my vehicle not part of this recall when it is having the recall problem? This is a major safety issue, gas splashing out of the tank, onto the truck, the ground and myself.
When fueling, as the truck reaches a full tank it will spew gas after the pump has shut off. My vehicle was initially included in the first recall, and my replaced tank worked well for a few years. A few months ago the problem recurred and has continued at each fill. For me it's not an issue because I know how much I can put in before hitting full. But my wife and I just switched vehicles and it is a real concern for her.
Tl*the contact owns a 2005 dodge durango. The contact noticed that the bottom of her gasoline tank was covered with rust. The dealer advised the contact to have it repainted and offered no further assistance since there were no related recalls. The manufacturer did not offer any assistance either. No repairs were performed. The current mileage was approximately 71,000 and the failure mileages was approximately 65,000. The VIN was unavailable.
2005 dodge durango. When filling at the gas pump, fuel splashes out all over the ground and me when it shuts off. This has been happening since 10k miles, I just put up with it. I found there was a recall, and I want this fixed. Not sure why I did not receive a notice.
My 2005 dodge durango sprays gas out of the gas tank everytime I fill up my car. Despite that fact that there is a open recall on the fuel tank filter for the 2005 dodge durango, chrysler/dodge said that my SUV does not qualify for the recall since it has a different part number. Therefore, even though my car exhibits the exact same issue as the outstanding recall and also presents a significant safety issue chrysler/dodge is unwilling to include my SUV and countless others in the recall and instead is saying that I need to fix the safety issue and the charge is $1665.00.
Summary: fuel escapes from vehicle at the end of refueling. Consequence: fuel leakage in the presence of an ignition source can result in a fire. Remedy requested: have dealer replace the fuel tank assembly free of charge, as in the recall of the same description for other 2005 dodge durangos - the federal safety agency campaign id #09v003000, chrysler recall #h45. Previously made a few attempts to get chrysler dealer in burlington, nj to effect repair, but customer service manager [xxx]claimed he couldn't duplicate problem. I was not with the vehicle when he allegedly attempted to duplicate problem. [xxx] was untruthful when I confronted him last year about chrysler corporate knowing of the problem and that it should be repaired at no charge to customer. No that I've found the federal safety agency website info and the h45 recall info, I made another attempt: I contacted chrysler. Case manager "[xxx]assigned me case #[xxx] on april 25, 2011, but told me on april 28, 2011 that I would have to pay a copay for the repair. I objected to a copay, and told him that I would be contacting the federal safety agency. This complaint is that contact. Can you assist me? Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
I own a 2005 dodge durango which has had a fuel issue from the day we got it. Almost every time we fill the tank, gasoline continues to spill out of the nozzle. This is especially noticeable when we fill up with the older style pumps that do not have the plastic sleeves on them. My investigation revealed a recall for the inlet valve but chrysler/dodge says my VIN series is not covered. This issue obviously encompasses more vehicles than the recall indicates. Chrysler stated they would look into the matter but I would have to pay a 95 dollar diagnostic and if it was the fuel inlet valve.. It would require "customer participation" to fix. They are willing to assist but tell me I will be responsible for between 100 and 500 dollars of the repair costs plus the 95 dollar diagnostic fee. I wish to add my complaint to the list of individuals who have already complained about this very concern. Dodge needs to be held accountable for all of the vehicles experiencing this issue. It makes little sense that some 2005 durango's are recalled but my particular one is not when the issue is the same. Please help.
Tl* the contact owns a 2005 dodge durango. The contact stated that fuel began to leak from the vehicle through the fuel filler neck while the contact was refueling the vehicle. The failure recurred whenever the vehicle was refueled to capacity. The manufacturer was notified and the contact was told that the vehicle was not included in the recall associated with the federal safety agency campaign id number: 09v003000 (fuel system, gasoline:storage:tank assembly). The vehicle was not repaired. The failure mileage was 24,000 and the current mileage was 35,000.
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, gasoline would spew back from the filler neck and the fuel pump would not shut off when the fuel tank was full. The contact referenced the federal safety agency campaign id number: 09v003000 (fuel system, gasoline: storage tank assembly but was advised by the manufacturer that the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was 90,000 and the current mileage was 105,000.
Tl* the contact owns a 2005 dodge durango. The contact stated that when attempting to refuel the vehicle, gasoline would spew back out. The failure was similar to that which was described in the federal safety agency campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The dealer was notified and the contact was awaiting a response. The contact did not inform the manufacturer nor was the vehicle repaired. The current mileage was 66,000 and the failure mileage was 64,000.
Tl*the contact owns a 2005 dodge durango. The contact noticed that when attempting to add fuel to the vehicle, gasoline would spill back out onto the ground similar to the federal safety agency campaign id number: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap). The dealer advised the contact to bring the vehicle in for diagnostic testing. The manufacturer informed the contact that there were no open recalls for his vehicle. The vehicle had not been diagnosed or repaired. The current mileage was unknown and the failure mileage was 60,000.
When fueling vehicle after the fueling nozzle is cut off several ounces of fuel spills/squirts out from the tank. Failure began occurring around 40k miles. Using different fueling sites still has same result. Stopping fueling as tank nears full has same results. This will occur every time vehicle is fueled unless fueling is stopped prior to tank becoming close to capacity. Recall e01 completed on vehicle on 7/15/2005 shortly after purchase. However, vehicle tested and no repairs were made/indicated at the time. The symptoms mentioned above are the exact same as mentioned in the recall. Numerous other similar complaints are listed with the federal safety agency. Dealer indicated they would perform test again for a fee and consult manufacturer regarding repair coverage. My feeling is this is a result of the same defective part indicated in the recall and it was just not detected during initial recall inspection. Vehicle has not been repaired. Currently I only fill tank to about three quarters full to avoid fuel spilling/squirting out. Dangers from the fuel include possibility of fire or fuel contacting skin/face/eyes.
2005 dodge durango. Each time vehicle is refueled fuel continues to spill back out of the fuel tank. This happens every time the vehicle is filled up. The dealer was contacted and informed me that my VIN was not included in the recall associated with the federal safety agency campaign id number: 09v003000 (fuel system, gasoline: storage: tank assembly). The manufacturer was also contacted and confirmed that the vehicle was not covered under the recall, and is also not covered under the extended warranty I purchased when I purchased the vehicle and offered no further assistance. This causes an environmental hazard, I am getting covered in gasoline as is my vehicle and the ground. Not to mention the loss of gas the vehicle is receiving and I am paying for.
Tl* the contact owns a 2005 dodge durango. The contact stated that after dispensing fuel to the full capacity, the fuel would spew out of the filler neck and onto the ground. The contact referenced the federal safety agency campaign id nummer: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap) and stated that the VIN was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 206,000. Updated 05/05/11
2005 dodge durango - approximately a pint to a quart of fuel overflows from fuel filler tube when filling up. There was an apparent recall on this problem but chrysler/dodge stated that my VIN number is not covered under the recall. Took vehicle in for inspection to a dealer. Quoted over $1100 for replacing whole fuel tank assembly in order to fix problem. Chrysler said they would cover all but 369.50 and that the company normally does not cover any amount of repair outside of warranty or a recall. Clearly, this should be a recall issue as many other 2005 durango owners are experiencing the same problem. Problem has persisted since purchasing from a friend's lease turn-in (approx 42k mi). Currently have approx 78k miles. Chrysler should cover this defect in full in that it is a serious safety issue and is not a problem stemming from wear and tear or abuse.
2005 dodge durango spills large amounts of gas when tank is filled.
Every time I fill the fuel tank on my 2005 dodge durango, when the pump shuts off, approx a pint of fuel shoots out of the fuel tank. Sometimes up to a few feet away. There are currently 2 recalls for this issue, but the email I received from dodge last week states my vehicle is not in need of repair. See video here: http://www.youtube.com/watch?v=b0-_9wg6dw4.
Fuel spews out of filler neck when refueling before tank is full unless fuel is added very slowly and pump is stopped and handle is removed from filler neck each time after adding 2-6 gallons depending on how much fuel is currently in tank.
Tl* the contact owns a 2005 dodge durango. The contact stated that after refueling the vehicle, fuel would continue to spill back out of the fuel tank. The dealer was contacted and informed him that his VIN was not included in the recall associated with the federal safety agency campaign id number: 09v003000 (fuel system, gasoline: storage: tank assembly). The manufacturer was also contacted and confirmed that the vehicle was not covered under the recall and offered no further assistance. The failure mileage was 128,000.
Tl* the contact owns a 2005 dodge durango. The contact noticed that when fueling the vehicle, gasoline fuel would spew back out onto her clothing. The dealer was contacted but did not offer the contact any assistance. The manufacturer advised the contact to take the vehicle to a local dealer for diagnostic testing. No repairs were performed nor was the vehicle diagnosed for the failure. The current mileage was 97,000 and the failure mileage was 0.
Tl* the contact owns a 2005 dodge durango. The contact stated that while refueling the vehicle, gasoline fuel would spew from the filler neck before the tank was able to be filled. The failure had been an ongoing recurrence for two years. The vehicle was not taken to a dealer or mechanic for the failure. The local dealer was contacted and advised that the vehicle was not included in the recall relative to the failure under the federal safety agency campaign id number: 09v003000 (fuel system, gasoline:storage:tank assembly). The vehicle was not repaired. The approximate failure mileage was 55,000 and the current mileage was 73,200. Updated05/04/11 *bf updated 11/18/11.
Tl* the contact owns a 2005 dodge durango. The contact stated that when refueling the vehicle, gasoline would immediately spill back out from the fuel tank. The failure recurred whenever the vehicle was refueled. The vehicle was neither inspected nor repaired for the failure. The dealer stated that the vehicle was not included in either recall associated with the failure (the federal safety agency campaign id numbers: 05v034000 (fuel system, gasoline:storage:tank assembly:filler pipe and cap) and 09v003000 (fuel system, gasoline:storage:tank assembly). The contact called the manufacturer who took a complaint and advised her to have the vehicle diagnosed by a local dealer. The vehicle was not repaired. The current mileage was approximately 113,000 and the failure mileage was approximately 111,000.
Fuel began spraying from neck of gas tank when filling up in fall of 2010. We tried refilling at large number of service stations across utah, nevada and california, with the same result when the nozzle clicks off, fuel gushes out of the fuel tank. I took it to the local dodge dealer in, and after spending $260, they were not able to fix the problem. It will cost another $500 to $1000 to fix this dangerous problem. There was a recall of lower VIN # durangos to fix this, but not for our VIN #. This is a serious safety issue as well as a waste of gas and a pollution problem.
We have been having trouble fueling our durango for the last 5 months. When the tank is full the pumps shuts off and then gasoline spews out of the filler tube. On myself or the attendant, the truck, and the ground. It does not matter the station or speed of fill. There are two open recalls for this same issue but I have been told by local dealer my VIN is not included. I request that chrysler/dodge be forced to expand the effected vehicles VIN numbers and do there part to protect their customers and the environment but stopping the spill of gas on us and the ground.
When refilling the vehicle gasoline squirts out of the recovery tube. The happens after every fill up, it doesn't matter if you fill up quick or slow. After the shutoff engages fuel spills all over you, the durango and the ground.
I got a recall letter for my 2005 dodge durango at around 60,000 miles. I was told that the recall did not match my SUV VIN and that nothing was wrong. I now have 76,000 miles on the durango and it started throwing up fuel when completing a fill up. This happens everytime now. Dodge already said my truck was good and that nothing was wrong with it. I am sure you they will try and tell me to cover the cost on my own. I will not cover the cost I promise you that. Dodge you are responsible for this, so fix it. You are selling junk and I have been a true customer for many years this is my 5th durango and my last. I hope it starts a fire so I will no longer have to pay for crap your selling.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Dodge Durango?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history