1994 Dodge Grand Caravan problems

What is wrong

Vehicle description: mini vans equipped with 2-spoke luxury wheels manufactured july 1992 through june 1993; or equipped with 4-spoke sport wheels manufactured from july 1992 through september 1993. The steering wheel armature stamping can crack and separate from the center hub attachment to the steering column.

Risk

If the steering wheel separates from the center hub attachment to the steering column, loss of control can occur increasing the risk of an accident.

Remedy

Dealers will inspect the steering wheel for cracks and any wheels with cracks will be replaced. All other vehicles will have a reinforcement plate installed to prevent steering wheel separation in the event cracking occurs.

Recall number 00V305000 · Recall details

What is wrong

Vehicle description: mini vans. The bolts used to attach the strut to the body and the rear liftgate can accumulate fatigue damage if three factors combine. If the bolt is loose, the gas strut is over-pressurized, and the frequency of opening and closing cycles is higher than for the average customer, the bolt can fail.

Risk

Personal injury could occur if the bolts break allowing the liftgate to fall suddenly.

Remedy

Dealers will inspect for loose fasteners, if the fasteners are loose, the strut (and integral bolts) will be replaced. If the bolt shows evidence of torque, the bolt will be removed, larger washers will replace the existing washer and the bolt will be reinstalled and hand tightened to the target torqued.

Recall number 99V213000 · Recall details

What is wrong

Vehicle description: mini vans. The wiring that initiates the driver and/or passenger air bag could electrically short circuit to ground. A short circuit to ground that exists immediately after turning the ignition key to the "on" or "start" position can cause the air bag(s) to inadvertently deploy.

Risk

Inadvertent air bag deployment can injure a front seat occupant.

Remedy

Dealers will perform an electronic diagnostic check. Any short circuits identified in either the driver's or passenger side air bag initiator wire circuit will be repaired.

Recall number 99V113000 · Recall details

What is wrong

Wheels with misformed lug nut seats were installed on these vehicles. This causes reduced nut to wheel contact area and limits the wheel self-centering capability during installation. This results in loss of wheel lug nut torque retention.

Risk

Loss of lug nut torque retention may lead to wheel lugfailure which may cause wheel separation and an accident.

Remedy

Inspect the wheel assembly plant code; replace wheels known to have the problem and install new lug nuts.

Recall number 93V215000 · Recall details

Mr. Larry a. Sackey submitted a petition to the federal safety agency by letter dated april 18, 2003, requesting that agencyfurther investigate the defective collapsible steering shaft system on 1987-1995 vehicles manufactured by the daimlerchrysler corporation.in part because of 49 cfr ? 30120(g), the federal safety agency has decided to limit the scope of the petition vehicles to 1993-1995 models, excluding the 1993 jeep grand cherokee and 1994-1995 dodge ram series trucks that were recalled (93v210 & 96v230) for steering column failure.if the analysis of these vehicles had identified a potential problem, the scope could have been expanded in an investigation.a review of odi's data base shows no recent complaints and a lack of a complaint trend concerning the subject issue on the subject vehicles as a whole or by individual models.therefore, the petition is denied.for details, see federal register notice volume 68, no. 130, july 8, 2003.

DP03002

There is no summary currently available

RQ00011

There is no summary currently available

PE97049

There is no summary currently available

PE96008

Liftgate latches in the subject vehicles have failed in low and moderate speed impacts resulting in occupant ejections, injuries, and fatalities.there are two failure modes associated with latch failure: fork bolt-detent lever bypass, and inertial unlatching.the federal safety agency analyses of chrysler and peer minivans took the form of static and dynamic crash testing, engineering evaluations, complaint and field analyses, and real world data analyses.a technical report discussing these analyses can be found in the engineering analysis technical report in the public viewing file.chrysler has advised the federal safety agency that it will conduct a campaign to replace the latches on all the subject vehicles.the chrysler campaign will consist of notification letters to all owners; free replacement of all latches with stronger, safer latches regardless of the age of the minivans; national advertising to promote customer awareness of the campaign; quarterly reports regarding campaign completion rates; as well as additional measures to ensure a high completion rate, above and beyond the actions that normally would be taken in a formal safety recall.these include follow up written and telephonic notifications to owners who do not bring their vehicles in for corrective action.the federal safety agency firmly believes that the crash performance of the latches on these minivans raises serious safety concerns, and that the campaign addresses these concerns.the chrysler corrective action will increase the strength of the liftgate latches and decrease the potential for inertial unlatching, thereby reducing the risk of crash-related openings of the liftgate and possible occupant ejection through the liftgate opening.owners of chrysler minivans will get a stronger, safer latch free of charge at the earliest possible time, without the need for further technical investigation and complex and time-consuming litigation with an uncertain outcome.based on the above, odi is closing this investigation.

EA94005