The headrest foam on my Evenflo Revolve360 Slim car seat (manufactured February 2023) is breaking apart and separating from the seat shell, even though I completed the remedy for Recall 25C010. In September 2025, after receiving the recall tape kit, I called Evenflo and told the representative the foam was already deteriorating and no longer adhering to the shell. I was told the tape would adequately fix it. I applied the tape as instructed. The foam has since continued to fail. It is now in several broken pieces, a large section has detached from the shell, and the black comfort foam near the harness area is also crumbling. The failed component is the EPS headrest foam, which Evenflo itself describes as the part that absorbs shock to protect the child. With the foam broken and no longer attached, I do not believe it can perform as designed in a crash. I also cannot confirm that the seat will stay intact for its stated 10-year service life. No crash has occurred. Because of the seat's condition, I have stopped using it and no longer consider it safe for my child. I contacted Evenflo in writing and sent photos. They responded that the seat is safe to use, that taping is an option, and that the 90-day warranty applies. They did not offer a replacement or any inspection of the seat. They also could not locate my earlier call. The seat has not been inspected by anyone else. I still have the seat and it is available for inspection on request. I am requesting that the federal safety agency review whether the recall remedy is adequate for seats where the foam has already begun to break down.
The worst 2017 Dodge Grand Caravan problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical144
- Body95
- Engine60
- Transmission37
- Locks28
- Airbags21
- Seats16
- Fuel system14
- Brakes7
- Acceleration5
- Driver assistance5
- Steering5
- Seat belts4
- Suspension4
- Visibility4
- Wheels3
Specific symptoms reported on the 2017 Dodge Grand Caravan
Door locks 97Check engine light 30Key fob 29Stalling 22Engine failure 18Misfire 16Airbag light 8Transmission failure 7Fire or smoke 6Loss of power 6Hesitation 5Jerking 5Wipers 5
Recalls 3
Equipment adaptive/mobility: wheelchair restraints/securement: latch/anchor:
- What is wrong
- Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
- Risk
- An unsecured wheelchair can move during transit, increasing the risk of injury.
- Remedy
- Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1‑800‑956‑6668.
Recall number 25V876000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
- Risk
- A fuel leak in the presence of an ignition source can increase the risk of a fire.
- Remedy
- Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1‑800‑488‑9082.
Recall number 20V278000 · Recall details
Electrical system: wiring: front underhood
- What is wrong
- Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
- Risk
- A vehicle stall can increase the risk of a crash.
- Remedy
- Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is U87.
Recall number 18V524000 · Recall details
See all 3 recalls for the 2017 Dodge Grand Caravan
Defect investigations
Active Head Rest Inadvertent Deployment
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by the federal safety agency’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
PE19014
Technical service bulletins for the 2017 Dodge Grand Caravan 102
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Sliding Door Lock(s) Inoperable Warranty Extension XV1 The
- Sliding Door Lock(s) Inoperable Warranty Extension X98 The
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Lifter
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- Suspected engine coolant leak.
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- Warranty Bulletin D-22-17
- FCA Caribbean Warranty Bulletin ID-22-23
2017 Dodge Grand Caravan fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 3.6L 6‑cyl | FWD | 17 | 25 | 20 |
What 2017 Dodge Grand Caravan owners say
Most recent owner complaints, unedited.
On XXX my 2017 Dodge Grand Caravan locked involuntarily while the engine was running and the keys were in the ignition. A [XXX] infant was locked inside the vehicle. The doors could not be unlocked from the outside, requiring emergency services from the Newnan Police and Fire Department to intervene to extract the child. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Passenger sliding doors will not open the power door actuators have failed no way to manually open them it’s available on request, safety of other at risk is incase of an accident there’s no way to open the doors it’s a safety hazard, problem was confirmed by dealer although it would cost me 3,800 to have them fix both sliding doors Ferario dodge in big flats NY tech confirmed that the manufactures of the door actuator had issues, there would be a buzz when they were failing although I had no idea what it was,
Odometer Fraud. The contact purchased a 2017 Dodge Grand Caravan. The contact stated that he had purchased a used vehicle through Facebook Marketplace. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy, and a Carfax report confirmed that the odometer had been tampered with twice. The vehicle was a private sale. The contact had reported the matter to the California State Attorney General's Office. At the time of purchase, the vehicle mileage was 138,661, and at the time of registration, it was discovered that the mileage was 177,589.
The contact owns a 2017 Dodge Grand Caravan. The contact stated that the sliding doors failed to open automatically and had to manually open the vehicle by using the interior and exterior door handles simultaneously. The vehicle was taken to the dealer, where the contact was informed that the vehicle was not covered under Chrysler Campaign Number: X98; and that any repair would be out-of-pocket. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.
The contact owns a 2017 Dodge Grand Caravan. The contact stated while driving approximately 25 MPH, the vehicle stalled in the middle of the roadway an dfailed to restart. The contact stated that there was smoke coming from the engine bay. There was not warning light illuminated. The vehicle was towed to AAMCO Transmissions, where it was diagnosed that the water pump housing had split in half. The water pump was replaced. The contact stated that shortly after the repair, the thermostat gauge started fluctuating and the vehicle overheated. The vehicle was taken to JJ Auto Repair and Collisions, where it was diagnosed with catastrophic engine block failure. A new engine was purchased and installed on the vehicle; however, the vehicle suddenly stalled while driving 40 MPH. The vehicle was restarted and driven to the dealer, where it was diagnosed with alternator failure. The alternator and the battery were replaced. The contact stated that the vehicle failed to operate as needed. The vehicle was taken to AutoZone, where the battery was replaced. Additionally, AutoZone tested the newly installed alternator and determined that the alternator was faulty; however, several mechanics determined that the alternator was in good condition. The contact related the failures to the federal safety agency Campaign Numbers:Â 20V278000 (FUEL SYSTEM, GASOLINE) and 18V524000 (ELECTRICAL SYSTEM). The vehicle was not repaired. The manufacturer was notified of the failure but denied reimbursement for the expenses. The failure mileage was approximately 90,489.
The rear power slide doors are opening on their own with vehicle in motion. The power switch on the roof is off. We have 5 children. No warming lamps or issues this is a known issues will caravans
The contact owns a 2017 Dodge Grand Caravan. The contact stated that the vehicle was shuddering, producing static electric shock, and the battery was overcharging. The air bag warning light was illuminated. The contact stated that the failure was related to the federal safety agency Campaign Number: 18V524000 (Electrical System). The local dealer was contacted and was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The contact had an ongoing issue with the local dealer. The manufacturer was contacted and informed that the vehicle was not under recall. The failure mileage was approximately 68,107.
specifics unknown check engine light came on cpl seconds before it started overheating / leaking coolant and or transmission fluid and overheating. and I'm not sure what. started last year but I don't drive very often so the issue just started last year
The driver and passenger sliding door power lock actuator is not operating for my wife's 2017 Dodge Grand Caravan with about 44,000 miles. There is a Warranty Bulletin, number D-25-03, dated January 30, 2025 that extended the warranty to coverage to 10 years/ 100,000 miles. My wife's car should have been included in the cars with the problem and it is not included in the cars affected by the problem. Please include my wife's Dodge Grand Caravan in the recall for the extended warranty.
Compare the 2017 Dodge Grand Caravan
Grand Caravan vs Chrysler Town and CountryGrand Caravan vs Honda OdysseyGrand Caravan vs Toyota SiennaGrand Caravan vs Chrysler PacificaGrand Caravan vs Kia Sedona
Other model years
1990199119921993199419951996199719981999200020012002200320042005200620072008200920102011201220132014201520162017201820192020
Questions about the 2017 Dodge Grand Caravan
Is the 2017 Dodge Grand Caravan reliable?
Owners have filed 415 complaints about the 2017 Dodge Grand Caravan, 1.2 times a typical Grand Caravan model year.
What is the 2017 Dodge Grand Caravan year score?
The 2017 Dodge Grand Caravan scores 69 out of 100 (average). The score compares it with the other model years of the Dodge Grand Caravan: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2017 Dodge Grand Caravan?
Electrical system, with 144 complaints, typically around 65,000 miles. Next is body (95).
How many recalls does the 2017 Dodge Grand Caravan have?
3 recalls, covering equipment adaptive/mobility, fuel system, gasoline and electrical system.
Was there a recall on the 2017 Dodge Grand Caravan electrical?
Yes, 1 recall: 18V524000. Check your VIN to see if your car still needs the free repair.
What year does the Dodge Grand Caravan have the most electrical problems?
The Dodge Grand Caravan model years with the most electrical complaints are 2008 (815 complaints), 2010 (550 complaints) and 2012 (337 complaints).
What gas mileage does the 2017 Dodge Grand Caravan get?
Official estimates for the 2017 Dodge Grand Caravan range from 20 mpg combined. The most efficient version (3.6L 6-cyl, FWD) gets 17 city and 25 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Dodge Grand Caravan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history