Fuel tank cracked at the seam, causing fuel leakage. The dealer will be notified.
1996 Dodge Grand Caravan fuel system complaints
Page 6 of 7: complaints 131 to 160 of 180, newest first, as owners wrote them.
The top of the fuel tank which is also attached to the vehicle cracked, resulting in a fuel leak which may cause a fire. Dealer need to replaced fuel tank. Please provide further information.
Filled the gas tank, drove home and parked vehicle in the garage. Smelled gas, pushed car out of the garage and ther ewas no evidence of gasoline leakage. Took car to the dealer, and was told that the nipple to the feeder line had disintegrated.
Ea99013, the valve located on top of the gas tank leaks, which may cause a fire if there is a source of ignition. Tank replaced by dealer, at half cost to the owner.
Consumer noted fumes/ gas smell within the vehicle when exiting and entering, further inspection of vehicle indicated fuel leaking. Consumer contacted the dealer, dealer determined the cause of the problem to be the gas tank which was split at the seam, dealer has replaced the fuel tank. *ak
Fuel tank leaked and dodge would not replace as the vehicle was out of warrenty
The fuel tank rollover valve can allow fuel to pass into the vapor canister. Recall remedy did not correct the problem. Recall number 95v236000.at 27000 miles with fuel tank leaking profusely, after recall performed while putting gas into vehicle the gas poured out on the ground, replaced gas tank and o-ring to solve problem. *ak.
I purchased this vehicle october of 1995, in march of 96 the fuse block had to be replaced along with a multi function switch because the wipers would come on by themselves while I was driving, a contact and plunger kit because the right sliding door would not always unlock when using the unlock button, the fuel tank was replaced because it only held 12 gallons of gas when it was supposed to hold 18 - 20, the tank was installed so that the tank was bowed in the middle and the front door panel was reattached to the door and the left sliding door was repaired because it would not unlock with the key. In august of 1997 the switch for the interior lights was replaced because the lights would flicker, the left side sliding door lock was replaced again along with the rear door latch. In sept. 0f 97 a gear was replaced for the power steering, the left sliding door had moulding replaced because the clips were broken. In august of 98 the stereo was replaced because the treble would fade, the vehicle shut off while I was driving no one could explain this phenomenon, the relay switch was replaced and the rack and pinion was replaced also the multi-function switch was replaced again. In sept. Of 98 the car was back in the shop because the air bag light came on. Evidently when they replaced the relay switch just 7 days earlier things in the dash started working that had not worked up til that point for instance I was not aware that the chime would go off if the blinker was left on for over a mile. It took 7 days to get my car back because they found out that there were never any screws holding the air bag in the module so as far as I know for the two years that my husband and I were driving this car there was no protection by and air bag. This past week july 1, we were on vacation and we had to replace the transmission to the tune of $l771. The car is back in the shop today (7/6) because it appears that the transmission continues to slip and run at high RPM.please help!!
There is a leakage within the gas tank, and consumer can smell gas within the vehicle. Rollover valve is allowing fuel to pass into the vapor canister, resulting in a leakage from the gas tank.
We had noticed the smell of gasoline for some time. Informed by carmax that this was a "common problem" with dodge caravan; I.e. Fuel tank develops a leak. Finally noticed it leaking fuel in a steady stream when we parked it facing downhill. Leak stopped when car parked at an angle facing uphill, or when level. Fuel tank is being replaced now.
Fuel tank dripped gas when filled to top. Tired of taking car to dealer and out of warranty anyway, I ran tank empty, dropped tank and found loose hose fitting in top of tank. Fitting was loose. Cleaned it up and used sealant and reinstalled. Concerned about the flimsy way fitting was fastened to plastic tank. You could just yank it out without much effort.
Defective roll over valve caused the gas tank to leak gasoline.
When getting into the vehicle consumer can smell vapors. Also transmission leaks. In addition, when putting gas into the vehicle, consumer should be able to put 15 to 16 gallons into the tank, but can only put 12 to 13 gallons into the tank.
Gas tank was leaking from the vents in the tank, resulting in strong gas fumes inside and outside vehicle. Dealer replaced the gas tank.
Ongoing problem with fuel tank leaking. Dealer notified and replaced tank at owner's expense.
Air conditioning-dealer replaced compresser,condensor and evaporator, we purchased van in march and A/C never worked when the weather warmed up. Fuel pump failed and had to be replaced at a cost of $450. Tires went next at a cost of $350 for two front tires. Transmission is slipping and won't shift consistantly. Will cost $1500-$1800 to replace on a two year old van with 45000 miles.( dot number: m30d tire size: 21565r16 )
After filling vehicle with gas it leaks fuel due to a bad gasket. Manufacturer has subsequently redesigned the gas tank to correct this problem.
Fuel is leaking from fuel tank.
Front windshield wipers come on without activating them. In addition, bench passenger seatbelt disconnects when buckled; brakes wore out when the car had 32,000 miles; left front tire blew out on the freeway at 7,000; transmission overhauled at 44,000 miles; passenger's sliding door locks do not open when unlocked, and gas tank was leaking.
Almost at stop hit small bump and both air bags deployed. No accident or damage to the vehicle other than the bag deployment.
Consumer complains that the vehicle he purchased from the dealer had apatch on the gas tank that just failed. Dealer ordering part to fix it. Consumer inquires about course of action that he might be able to take.
Fuel tank leaking at the top of the tank where sending unit is located.
Fuel pump did not fit properly, causing leakage.
Fuel tank leaks.
Vehicle was recalled for the fuel filter and the fuel pump. The vehicle has been leaking fuel . The dealer has been made aware and has replaced the fuel tank. (95v‑234).
Fuel tank split, causing fuel to leak out prior to after recall repairs. Also windshield wipers would go on intermittently bythemselves. (95v‑236).
Fuel gauge and tank failed.
Gas tank collapsed, tank reading said zero, with gas in tank, dealer replaced tank, subsequently, tank fitting became loose, causing gasoline spillage on vehicle/onto ground, could smell gas fumes. *ak
Fuel tank leaked at top of tank where it was molded to a hose outlet. Fuel leaked when tank was full. Also transmission gasket leak.
While driving the vehicle stalls intermittently which can cause an accident. Dealer cleaned out the throttle body 3 times due to carbon build up which hasn't solved the problem.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Dodge Grand Caravan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history