Randomly shuts off Says key is in the ignition when it isnt
2012 Dodge Grand Caravan electrical problems
337 complaints (58% of all complaints for this car). Typical mileage when it fails: 100,000.
- owner complaints
- 337
- of this car's complaints
- 58%
- typical mileage
- 100,000
- crashes
- 0
- recalls
- 1
Which part fails
- Ignition3
- Ignition: module2
- Ignition: anti-theft: control module1
- Alternator/generator/regulator1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Dodge Grand Caravan electrical problems in other years
Specific symptoms reported on the 2012 Dodge Grand Caravan electrical
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Electrical system
- What is wrong
- Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
- Risk
- An overheated switch may result in a vehicle fire.
- Remedy
- Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is P25.
Recall number 14V234000 · Recall details
Related investigations
Totally Integrated Power Module Failure
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the federal safety agency to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to the federal safety agency, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V‑530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V‑115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a the federal safety agency order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize the federal safety agency's limited resources to best accomplish the agency's safety mission, the petition is den
DP14004
What 2012 Dodge Grand Caravan owners say
Most recent owner complaints, unedited.
We purchased our 2012 Dodge Grand Caravan 1/2026. Only 85000 miles on it. After about a week or 2, when husband tried go start van to go to work early cold, morning, van wouldn't start easily. Sometimes he would wait up to a few hours and keep trying to start, eventually it would. But last 3 days, its gotten harder to start van.at all. Not cool. Why isn't this recalled, it seems ALOT of people have same issue..
The fuel pump would run all night and going down the road the van would cut off...had it checked the tipm was bad
My van tipm went out..it would cut off going down the road the safety door locks was not working the fuel pump was running all the time with switch off
While driving, the vehicle will periodically shut down/lose all power. This appears to occur when a slight bump in the road occurs. The loss of power to the vehicle is obviously a significant safety issue. We have been able to restart it when switching to neutral and turning the key; however, this obviously isn't a safe solution while traveling down the highway with no power to the vehicle. This has occurred multiple times at varying speeds (30-70 mph) over the last few years - I am reporting it now as I was assuming/anticipating there would be a recall on this safety issue.
Car stalls unexpectedly with no warning or check engine light on. Intermittent occurrences. Sometimes interior lights stay on, sometimes not. Can usually get car restarted right away but not always. Has been doing this for awhile. Never know when it will do it. Has done it at all speeds, while parked and while idling. Have had battery replaced as well as starter. Suspect win module. See below - approximate date is unknown. Has been doing it for so long we don't remember.
The contact owns a 2012 Dodge Grand Caravan. The contact stated that while the vehicle was parked, unoccupied, and turned off at the residence, she noticed that sparks and flames were coming from the overhead console. The flames then spread to the front driver's and passenger's side seats. The contact did not sustain any injuries. The fire department arrived and extinguished the fire. The fire department filed a report, which determined that the fire was caused by an electrical wiring failure. The vehicle remained at the residence. The insurance company was not made aware of the fire. The manufacturer was not made aware of the failure. The failure mileage was approximately 183,000.
While driving engine was cutting out, stalling, hard to restart. Found the reason was thr TIPM. Found there was a safety recall R09 / the federal safety agency 15V‑115 fuel pump Relay, however this was for other Fiat Chrysler models and not the Dodge Grand Caravan, please help me understand why? The TIPM within this caravan is the same TIPM installed is other Fiat Chrysler models and clearly the same danger concerns. I don't believe I need to tell the federal safety agency how scary it was to be driving 65 on a freeway when this occurred putting my life and others around me in danger of possibly losing control of a vehicle. Then learn this same TIPM was part of a large recall, but only on some models and not all. Makes absolutely no sense. I would ask that this prior recall be extended to all models with this TIPM installed as I can only imagine how many others have experienced this; God forbid and accidents were caused. Thank you for your time.
On my Grand Caravan the engine randomly dies when my headlights are on bright. I haven't been able to find the problem. I have read where others are having the same problem but not sure they have associated the problem to the high beam lights. Last year when the dealership supposedly did the T33 recall it stopped doing it for two months then started happening again. It only happens with my high beams. The dangers are that, unable to use my high beams, I may not see wildlife running out into the road on dark highways until it is too late. Also, if this happens in traffic, especially in turns or curves, there is temporary loss in propulsion, power steering, power brakes, etc. I believe this to be a widespread problem that most haven't associated with the headlights. When it happens all of the dash lights come on as if the ignition was just turned on. I guess one more danger is that a driver, unaware of what is happening, may try accelerating when the engine has died which could cause sudden acceleration when the engine power restores.
I bought the car 2 weeks ago with 105k miles on it. The car has died approximately 20 times in the last 2 weeks while I am driving it. It is so insanely dangerous, you will be going down a busy street and the car completely dies without warning. There is no dash lights on, no warning. The power steering goes. It's an accident waiting to happen, it’s unacceptable. After spending 2k at the mechanic and still the same problem. They have now told me I need the TIPM replaced at the dealership. Which also affects the lights, which are erratic, they come on or come off when they want, along with the horn. It’s also pushes the motors into limp mode so it runs really hard over 20 miles an hour even while idle. The car will also die while in idle/park or when you shift gears. The car is basically an all day event to start and if you get it to stay on, if you are able to get it, don’t touch the key or it will automatically the car off. The TIPM system will also stay on, even while car is off causing your battery to drain.
Questions about the 2012 Dodge Grand Caravan electrical
Does the 2012 Dodge Grand Caravan have electrical problems?
Owners have filed 337 complaints about the electrical of the 2012 Dodge Grand Caravan, 58% of all its complaints, more than any other problem.
At what mileage do 2012 Dodge Grand Caravan electrical problems start?
The typical (median) mileage in owner complaints is 100,000 miles.
Was there a recall on the 2012 Dodge Grand Caravan electrical?
Yes, 1 recall: 14V234000. Check your VIN to see if your car still needs the free repair.
What year does the Dodge Grand Caravan have the most electrical problems?
The Dodge Grand Caravan model years with the most electrical complaints are 2008 (815 complaints), 2010 (550 complaints) and 2012 (337 complaints).
Other 2012 Dodge Grand Caravan problems
Engine 121Fuel system 74Transmission 48Brakes 38Acceleration 24Body 19Airbags 18Driver assistance 18Steering 14Visibility 13Seats 9Lights 7Tires 5Wheels 4Seat belts 3Suspension 3Locks 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2012 Dodge Grand Caravan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history