2002 Dodge Intrepid engine problems

Filed Jul 7, 2017 · Engine, Fuel system · 105,208 miles · NM · fire

An oil plug front left of engine block blew out pumping oil onto catalytic converter. Open flames melted wheel well, back bumper, and fuel hoses off of gas tank. Fire went out went all the oil was pumped out of engine and car stopped moving. I contacted chrysler safety, they referred me to dodge customer care; they initially created a case #31892226 but then sent a letter saying they were not responsible because the car was out of a three-year warranty period and also unspecified environmental factors. Although my wife and son were almost immolated, it wasn't important enough for them to check into. The car remains parked at a local garage awaiting investigation.

Filed Jun 10, 2016 · Engine, Fuel system · 145,000 miles · IN

Tl* the contact owns a 2002 dodge intrepid. The contact stated that fuel fumes were emitting in and around the vehicle. After inspecting the vehicle, the contact noticed that fuel was leaking from the top of the engine and the check warning light illuminated. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure. The vehicle was not repaired. The VIN was not available. The failure mileage was 145,000.

Filed Aug 2, 2014 · Engine · 111,000 miles · CA

Engine failure 2.7l 2002 dodge intrepid vehicle owned over 10 years 111k miles current odm, oil change was not due at the time of engine failure.

Filed Aug 2, 2014 · Engine · 111,000 miles · CA

Engine failure sludge , engine design.

Filed Feb 28, 2013 · Engine, Fuel system · 129,000 miles · CA

Tl* the contact owns a 2002 dodge intrepid. The contact stated that when driving approximately 55 MPH or less, she would hear a loud knocking noise with the illumination of the low oil warning light. The vehicle was taken to a dealer where they advised her that there was sludge in the motor, which needed to be cleaned. The vehicle was repaired by cleaning the sludge out of the engine however, the failure recurred. The vehicle was taken back to the dealer where they advised that the fuel and the cam sensor could have been the cause of the failure. The vehicle was repaired for both components. The manufacturer was contacted and offered no assistance. The failure mileage was approximately 129,000. The current mileage was approximately 130,000. Updated 04/02/13

Filed Jan 17, 2012 · Engine · 186,000 miles · FL

Tl* the contact owns a 2002 dodge intrepid. The contact stated that while having repairs on the vehicle, she was advised by the technicians that the valve gasket was covered in oil sludge. The mechanic advised that the valve gasket cover needed to be cleaned and the oil needed to be replaced. The manufacturer was not made aware of the failure and the vehicle was not repaired. The failure and the current mileage was 186,000. Updated 02/0812 *bf updated 03/16/12

Filed Jul 28, 2011 · Engine · 104,260 miles · MN

Noticed antifreeze leaking from under center area of car, attempted to pit in antifreeze, leaked out right away. I checked the oil and it was full of antifreeze. The motor is shot. There was no warning no service lights the car has not been over heated, it was very well maintained by a local dealer.

Filed Jul 10, 2011 · Engine · 140,000 miles · WI

2002 dodge intrepid 2.7 engine car sudenly overheated. Anti freeze went out on ground and into oil. Repalced water pump, tensioner, timimg chain, several sensors, gaskets and more.always maintained oil changes at 300k and oil filters. Bad engine- parts saved.

Filed Jun 20, 2011 · Engine · 105,675 miles · OH

Tl* the contact owns a 2002 dodge intrepid. The contact was driving 50 MPH when the vehicle stalled without warning. The vehicle was taken to the dealer who advised that there was an internal engine failure but was unable to provide a concrete diagnosis. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure and current mileage was 105,675.

Filed May 31, 2011 · Engine · 71,010 miles · NC

Engine coolant: car ran hot without warning. Temperature gauge blew off of radiator and coolant exploded all over the engine.