2002 Dodge Intrepid: engine failure

Filed Aug 2, 2014 · Engine · 111,000 miles · CA

Engine failure sludge , engine design.

Filed Aug 2, 2014 · Engine · 111,000 miles · CA

Engine failure 2.7l 2002 dodge intrepid vehicle owned over 10 years 111k miles current odm, oil change was not due at the time of engine failure.

Filed Jun 20, 2011 · Engine · 105,675 miles · OH

Tl* the contact owns a 2002 dodge intrepid. The contact was driving 50 MPH when the vehicle stalled without warning. The vehicle was taken to the dealer who advised that there was an internal engine failure but was unable to provide a concrete diagnosis. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure and current mileage was 105,675.

Filed Jul 25, 2010 · Engine · 82,000 miles · NY

Engine failure on 2002 dodge intrepid se 2.7l v6. Per mechanic - timing chain failure and other engine damage due to poor oil flow/overheated oil causing sludge and subsequently clogged oil ports and excessive degradation of oil. This happened even though used full synthetic for entire life of car and changed oil regularly (~ every 5-8k miles) oil.

Filed Feb 12, 2010 · Engine · 78,240 miles · OH

My 2002 dodge intrepid stopped running while I was headed uphill in traffic I managed to make it to the side of the road my mechanic towed it and ran a diagnostic check on it which cam back cam sensor and crankshaft sensor ... Replaced both.. Car still wont start.. Was told that I possibly flooded the spark plugs while trying to restart it... Replaced spark plugs... Car still wont start after further investigation was told that the 2.7 engine is defective and needs to be replaced which if I can find a decent used engine will be atleast $3500 but I cannot find a used dodge intrepid engine because they are all bad! I still owe more than $2000 on the car and cannot afford a new engine.. I am behind on payments because I have no transportation to work... Or to the grocery store.. Or the doctor or to my 3 kids school for that matter.

Filed Aug 18, 2009 · Engine · 101,000 miles · PA

Stopped at a stop sign, engine failed with no warning.

Filed Jul 31, 2009 · Engine · 90,000 miles · CA

I have a 2002 dodge intrepid. It has 90,000 miles on it. I have taken good care to change the oil on a regular basis. Due to oil sludge the engine failed while I was driving. It now needs a new engine at a cost of $4,000. I still owe $3,000 on the car. It is not worth it to fix it. This car is known for engine failure at 80-90k miles. I almost got in an accident.

Filed Jun 20, 2009 · Engine · 128,000 miles · CO

2002 dodge intrepid with 2.7 engine. Engine failed due to oil sludge as 16yr old driver came to stop sign at a major highway. Cost to replace was 5200.00.

Filed Mar 12, 2009 · Engine · 73,000 miles · AZ

2002 dodge intrepid thermostat radiator cap stopped working and I got that fixed and we were test driving the car and it worked fine, for a bit. As we were driving the car started shaking and then the engine blew. It stopped working in the middle of december 2008. We need to buy a new engine. It was sudden, and we took the car to get the oil change and the entire vehicle checked every 3 months.

Filed Mar 5, 2009 · Engine · 75,000 miles · NY

Tl*the contact owns a 2002 dodge intrepid. The contact heard a knocking noise in the engine and took the vehicle to the dealer. He was informed that the failure was due to an oil flush and a metal flashing, which was caused by a defect from the factory. The dealer stated that there was no guarantee that they could correct the issue. He has found numerous complaints online for his make and model vehicle relating to the engine. The dealer stated that it would be best to purchase a new engine. The failure mileage was 75,000 and current mileage was 79,541.

Filed Mar 3, 2009 · Engine · 158,000 miles · OK

Due to oil sludge build up the engine has failed on my 02 dodge intrepid. We have had all major parts replaced (computer, fuel pump, transmission, etc). Only a month after replacing the computer the engine seized up and left my husband stranded.

Filed Feb 24, 2009 · Engine · 42,000 miles · NC

I own a 2002 dodge intrepid with a 2.7l engine. The car only has 45,850 original miles.at times it will make a knocking noise that will eventually go away. I was told that the 2.7l has a problem with sludge buildup causing vital internal engine parts not to become lubricated. I have my oil changed every 1500 to 3000 miles and have only driven it 23,000 miles since buying it in 2006 I have taken it to several repair shops , but most mechanics refuse to work on it because of the so called sludge problem and the high cost of the repairs. Some suggested using full synthetic oil to combat the problem. Others have stated that the only solution is to replace the engine completely. I have also questioned chrysler as to any recalls for the 2.7l intrepid but no answer. I have also noticed that there are several complaints about this problem across north america. If chrysler knew this was a problem with these engines, they should have informed us the consumers and taken actions to correct it. I think they decided to keep their mouth shut and flood our country with a worthless product. Chrysler needs to own up to this defect. I have been a loyal customer of dodge for many years but is fading fast when it comes to american made vehicles.