2002 Dodge Intrepid: engine knocking or ticking

Filed Feb 28, 2013 · Engine, Fuel system · 129,000 miles · CA

Tl* the contact owns a 2002 dodge intrepid. The contact stated that when driving approximately 55 MPH or less, she would hear a loud knocking noise with the illumination of the low oil warning light. The vehicle was taken to a dealer where they advised her that there was sludge in the motor, which needed to be cleaned. The vehicle was repaired by cleaning the sludge out of the engine however, the failure recurred. The vehicle was taken back to the dealer where they advised that the fuel and the cam sensor could have been the cause of the failure. The vehicle was repaired for both components. The manufacturer was contacted and offered no assistance. The failure mileage was approximately 129,000. The current mileage was approximately 130,000. Updated 04/02/13

Filed Sep 25, 2010 · Engine · 125,000 miles · OR

My 2002 dodge intrepid se began have engine troubles at 125,000 miles. I had the engine flushed in an attempt to stop a new knocking sound from getting worse. While driving with my children on the interstate two days later the engine completely failed. I have been paying the finance on this vehicle for the past year and a half. I am unable to pay the excessive engine repair costs and so the car sits.

Filed Mar 5, 2009 · Engine · 75,000 miles · NY

Tl*the contact owns a 2002 dodge intrepid. The contact heard a knocking noise in the engine and took the vehicle to the dealer. He was informed that the failure was due to an oil flush and a metal flashing, which was caused by a defect from the factory. The dealer stated that there was no guarantee that they could correct the issue. He has found numerous complaints online for his make and model vehicle relating to the engine. The dealer stated that it would be best to purchase a new engine. The failure mileage was 75,000 and current mileage was 79,541.

Filed Feb 24, 2009 · Engine · 42,000 miles · NC

I own a 2002 dodge intrepid with a 2.7l engine. The car only has 45,850 original miles.at times it will make a knocking noise that will eventually go away. I was told that the 2.7l has a problem with sludge buildup causing vital internal engine parts not to become lubricated. I have my oil changed every 1500 to 3000 miles and have only driven it 23,000 miles since buying it in 2006 I have taken it to several repair shops , but most mechanics refuse to work on it because of the so called sludge problem and the high cost of the repairs. Some suggested using full synthetic oil to combat the problem. Others have stated that the only solution is to replace the engine completely. I have also questioned chrysler as to any recalls for the 2.7l intrepid but no answer. I have also noticed that there are several complaints about this problem across north america. If chrysler knew this was a problem with these engines, they should have informed us the consumers and taken actions to correct it. I think they decided to keep their mouth shut and flood our country with a worthless product. Chrysler needs to own up to this defect. I have been a loyal customer of dodge for many years but is fading fast when it comes to american made vehicles.

Filed Dec 6, 2008 · Engine · 112,000 miles · NJ

I own a 2002 dodge intrepid always did regular oil changes. Oil light came on, started hearing a knocking sound from the engine. The dealer says I have to replace the engine, otherwise it may seize while driving, causing a serious condition.

Filed May 12, 2008 · Engine · 76,000 miles · PA

Tl*the contact owns a 2002 dodge intrepid. While driving 25 MPH, she heard a knocking noise then the vehicle shut off without warning. The dealer stated that sludge inside the engine caused the failure and recommended a new engine. As of may 12, 2008, the dealer had not repaired the vehicle. The current and failure mileages were 76,000.

Filed Nov 20, 2007 · Engine · 53,000 miles · MI

2002 dodge intrepid engine failure from oil sludge. Driving down the street and the car started making knocking sound and started bogging out. Took it to dealer who said the engine needed to be replaced which will cost $6100.00. Chrysler said that we would have to pay a $2500.00 deductible since the car was out of warranty. We bought the car in 2003 with 19,000 miles on it from a dealer and the car now only has 53,000 miles on it. Chrysler needs to own up to this. There is hundreds of complaints on this very same problem. Please make them issue a recall on this 2.7l engine. Toyota did with less complaints.

Filed Aug 15, 2007 · Steering · 30,000 miles · FL

Tl*the contact owns a 2002 dodge intrepid. While driving approximately 10 MPH around a tight curve, the vehicle jerked to the right without warning. Sludge was removed from the vehicle on three occasions. The contact heard a ticking sound coming from the steering. He stated that the passenger side front tie rod is bent, but the bolt is still attached. The tire has excessive wear and had to be changed three times. The VIN was unknown. The current mileage was 62,000 and failure mileage was 30,000.

Filed Apr 19, 2007 · Engine · 11,400 miles · NC

I own a 2002 intrepid and the engine lock up 100,000 miles . Check engine light came on check came up gas cap. Was driving and low oil light came on had just check oil it was full. Drove about 10 miles stop check again still full .checked for leaks none. Went about 2 miles and start knock and locked up. Talked to mechanic said he has rebuilt over `100 of them that have done same thing. Chrysler knew engine was not going to last. Only hold 4.5 qaurts of oil and oil port holes not big enough for that motor a 2.7 thanks lyman underwood.

Filed Apr 19, 2007 · Engine · 105,783 miles · MI

Engine started knocking, so I stopped at a service station. They said that they do not repair 2.7 liters for chrysler. Had it then towed to the chrysler dealership and they said that the motor was blown due to oil sludge and needed to be replaced at a cost of $5700.00. Contacted impartial services group, sent them all information on the car, including oil changes. Was made an offer by chrysler of $1080.00. Turned it down as they have had the same issue with mercedes owners and have taken care of them. Talked to the owner of the chrysler dealership in my area and he said "the 2.7 is a junk motor and I wouldn't have one on my lot". He also went on the tell me that the oil ports are to small to allow proper oil flow and the "v" shape in the oil pan does not allow for all of the oil to drain out during oil changes. I contacted chrysler by letter and e-mail and they said sorry, but there is nothing we can do. I am in the process of creating a web site in which will be called the national push my dodge. It will include a date in which I will push my dodge intrepid as far as needed to create awareness that chrysler has turned its back side to middle class americans.

Filed Apr 9, 2007 · Engine · 755,000 miles · UT

Tl*- while driving the 2002 dodge intrepid at 70 MPH with failure mileage 79,500 the contact heard a loud knocking noise coming from the engine. She took the vehicle to the dealer, and had them service the vehicle. The vehicle has now been salvaged due to the extent of the repair needed.

Filed Mar 14, 2007 · Engine · 70,800 miles · NV

I began having trouble with my heater in my car and I took it into pep boys and they replaced the water pump and seals. Then it began again and then the check engine light came on and I was told that I had a transmission sensor going out. Soon after the car stalled and would not start. Before the car stalled the engine had a loud knocking coming from it.