Dodge RAM 3500 stalling problems

Filed Mar 3, 2026 · Electrical · MI

A mechanic at professional auto shop diagnosed the failed TIPM. It caused the fuel sending pump in the fuel tank to stop pumping. The truck stalled while driving on the highway leaving me stranded in 2-degree weather. I read online that there was a lawsuit for this issue but don't know how to file to recoup the $1200+ repair bill on top of the $200 cost to tow it to the auto repair shop. There was an electrical draw and emergency flashers randomly turning on causing the batteries to die a month prior to the failure of the TIPM. I did have the check engine light come on when the fuel pump was cutting out and stalling. The truck is currently in the shop, and they ordered a new remanufactured TIPM.

Filed Jul 30, 2021 · Transmission · SC

My husband, our son, and I were traveling down the highway at about 60-65mph when we started hearing a low winding sound. Seconds later, before my husband could get the truck over to the shoulder of the road, there was a loud banging sound coming from underneath the truck that sounded like something was coming through the floorboard. He was finally able to get the truck pulled to the shoulder of the road but wasn't able to put the truck in the park position. He had to use the park brake to get the truck to completely stop. Once the tow truck safely lifted the truck, you could clearly see gears hanging amd what looked to be remains of the transfer case. The truck was towed to a body shop where several codes were discovered, which all pertained to the truck going into 4wd by itself without any warning and unknowing to the driver. This glitch is what appears to have caused the transfer case to grenade, further causing damage to the drive shaft and smashing the fuel line. We, as owners, had the transfer case serviced and fluids flushed just two weeks prior to this happening After further investigation and conversations with the local Dodge dealer, it appears that this has happened in several situations yet no safety recalls have been issued. There is a national backorder for transfer cases for our particular year which is a red flag. We're now left with an over $8100.00 bill and everyone pointing the finger at each other. This could have ended tragically had there been more traffic on the road when the truck began stalling on the busy interstate.

Filed Jul 13, 2021 · Electrical · CO

WIN ignition module has slowly been causing difficult starting problems. Now, over even slight bumps, the sloppiness in the connection between the key and the WIN module allows the key to move and the vehicle to shut off while driving. This is becoming more and more common and is very dangerous. Just on my 10 minute drive home from work today, it occurred 4 times. One time, I had just turned right on a red light (with plenty of space between me and oncoming traffic) and the truck shut off completely. Without the key being in the exact right position, I had difficulty restarting the truck and could have been very dangerous to me and the vehicle coming toward me.

Filed Oct 13, 2020 · Airbags, Electrical · 114,000 miles · MN

Tl* the contact owns a 2012 ram 3500. The contact stated that while driving at various speeds, the vehicle stalled without warning. The contact turned off and restarted the vehicle and the vehicle resumed normal operation. The vehicle was not diagnosed. Lithia chrysler jeep dodge of missoula (5001 grizzly ct, missoula, mt 59808) was contacted and confirmed that the VIN was not under recall. The contact mentioned the federal safety agency campaign 14v373000 (electrical system, air bags) as a possible solution to the failure however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 114,000. *ln consumer stated it happens when truck stops and also when it is moving.

Filed Aug 19, 2020 · Fuel system · 178,000 miles · IN

At 178,000 miles (approximately), the rear suspension strap rusted through and dropped the rear end of the diesel fuel tank to the pavement. The plastic tank was ground down by moving over the pavement at highway speeds, but I was able to recognize the issue by the unusual noise and thus stop the truck before the tank ruptured. Potential hazards include fuel spill, smoke, fire, and vehicle stall while moving without the possibility of restart. Fuel tank fixation to the vehicle should not rust through and fail during the lifetime of the vehicle. The fuel tank is within 2 inches of the driveshaft and within 18 inches of the exhaust system.

Filed Jul 15, 2020 · Electrical, Engine · 110,386 miles · MT

Tl* the contact owns a 2012 dodge ram 3500. The contact stated that while driving approximately 45 MPH, the vehicle stalled without warning. The contact pulled over to the side of the roadway and waited for several seconds before restarting the vehicle. The vehicle was not taken to be diagnosed nor repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency hotline to file a complaint. The failure mileage was 110,386.

Filed Apr 8, 2019 · Electrical, Engine · 118,000 miles · SD

While driving down the highway, the vehicle stalled. I lost power steering, brakes, all electrical, and engine power. Everything stopped working and went black. Luckily I was not pulling a trailer, have to stop, or turn fast. If I would have, I would have crashed.*dt consumer stated fuel pump failed and it had a bad ground. Above the rear axle. It had electrical issues. Backup camera blacked out, reverse lights come on and stay on, lights and blinkers flicker.

Filed Oct 26, 2018 · Electrical · 11,694 miles · MN

Tl* the contact owns a 2012 ram 3500. The contact stated that there was a sudden loss of power while driving various speeds and hauling a trailer. The contact also stated that the vehicle stalled without warning. The dealer (value ford & chrysler, 205 state hwy 9, morris, mn 56267, (800) 568-5431) stated that there were no recalls. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and also indicated that the vehicle was not included in a recall. The VIN and failure mileage were not available. *tt VIN is not valid updated 12/12/18*jb

Filed May 26, 2018 · Electrical · 196,000 miles · TX

Pickup electrical system will shut off while driving. Requires turning the ignition to restart. Does when driving on smooth or bumpy roads.

Filed Feb 12, 2018 · Electrical · MT

Tl* the contact owns a 2012 ram 3500. While driving over unleveled land at an unknown speed, the vehicle randomly stalled several times. The dealer (northern chrysler, 23 w railroad st, cut bank, mt 59427, (406) 873-2200) diagnosed that the win module needed to be replaced. The manufacturer issued a recall for other year, make, and model vehicles concerning the electrical system, but not for the contact's year, make, and model. The manufacturer was notified of the failure. The VIN and failure mileage were not available.