2021 Ford Bronco brakes problems

Filed Aug 21, 2026 · Brakes · NC

I contacted my Ford dealership, and they informed me that the recall is not currently showing as applicable to my VIN. Because my vehicle is experiencing similar issues, the dealership recommended that I contact Ford directly to have my vehicle and VIN reviewed. I would like to request that Ford review my vehicle to determine whether it may be affected by the same issue and whether my VIN could potentially be included in the affected vehicle population. My vehicle intermittently displays a “Check Brake System” warning, with the red brake warning light remaining illuminated. I have also experienced intermittent changes in braking, particularly when initially applying the brakes, where the brake pedal feels harder than normal and requires increased effort to slow or stop the vehicle. This is meaningful overlap between what I am experiencing and the recall description. Now I’m being told to reach back out to Ford, which I’ve done, or file a claim which is this

Filed Aug 13, 2026 · Brakes, Electrical · GA

While driving, I experienced the brakes beginning to fail, followed shortly by a complete loss of engine power. My 2021 Ford Bronco is subject to recall 25S75 (the federal safety agency 25V455) for a low pressure fuel pump defect that can cause loss of fuel pressure or flow and engine stall. I was stranded on the side of the interstate in 100 degree heat with my newborn in the vehicle. This was a dangerous situation, not a minor inconvenience. I had the vehicle towed to an AAA Car Care Center in Charlotte, NC, where the fuel pump failure was diagnosed. AAA could not perform a repair because the issue falls under an open safety recall. I contacted the Ford Recall Assistance Center and was told no remedy is currently available for recall 25S75. I also visited Capital Ford Charlotte, who confirmed the same, that no remedy exists yet. With the vehicle inoperable and no repair available anywhere, I paid out of pocket for private transport to move the vehicle to my home in Newnan, GA, since Ford could not confirm coverage for towing to my home dealership. As of August 12, 2026, the federal safety agency materials still list the remedy for 25S75 as under development. My vehicle remains inoperable with no path to repair. This is now also preventing me from selling or trading the vehicle. A dealership (Buford Toyota) declined to even appraise it because it will not run. I am filing this complaint to document that an open, unremedied safety recall directly caused a vehicle failure that endangered myself and my infant child, and continues to leave the vehicle unusable and unsellable months later.

Filed Aug 5, 2026 · Brakes · PA

There is multiple anti lock braking faults that pop up while driving and then go away the next time the vehicle is used. Brake fluid, pads, rotors and calipers all seem to spec and are working at the moment, but major concerns with the software or possible release and reengagement of the emergency brake.

Filed Jun 14, 2026 · Acceleration, Brakes · AZ

I was driving on the highway with standard cruise control (I don't have adaptive cruise) and I went to press the brakes and the brake pedal was SUPER stiff and I had to press unreasonably hard to disengage the cruise control and slow down. When the pedal finally gave, I ended up slamming on the bakes so much that my passenger was startled and we both lurched forward due to our momentum. Afterwards, my brake light light came on, on the dashboard. I went to AutoZone to get a reading and it said it was the brake assist vacuum or something like that. This could have caused a very bad accident in too different ways. One, if I didn't stop in time due to the delayed braking from the stiff pedal or getting rear ended due to inadvertently slamming on the brakes at highway speed.

Filed Feb 20, 2026 · Brakes · TN

Brake fault warning occurring continuously. Seems to be a wide issue with Broncos 2021-2025. The brakes become “squishy” and have to push them to the floor to stop.

Filed Dec 30, 2025 · Brakes · DE

Brake Light issue: Red Brake Light appears when driving over 40 MPH. To fix issue Tube Vacuum had to be replaced. Part# MB3Z 2420 This seems to be an on going issue with 2021 Broncos.

Filed Oct 22, 2025 · Brakes, Fuel system · 40,000 miles · WV

The contact owns a 2021 Ford Bronco. The contact received notification of the federal safety agency Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE). However, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The failure had occurred while driving from a stop or while driving uphill. No warning lights were illuminated. The contact stated that on a separate occasion, an unknown message about the brake system was displayed on the instrument panel. The local dealer was not contacted after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 40,000.

Filed Jul 11, 2025 · Brakes, Engine · 14,000 miles · PR

The contact owns a 2021 Ford Bronco. The contact stated that water was entering the vehicle through the roof. While the vehicle was parked, the vehicle started rolling down the hill. The contact stated that the brake pedal was continuously pumping while being depressed. The contact stated that the brake lights were illuminated. Additionally, the vehicle occasionally failed to start. The vehicle was taken to an independent mechanic who replaced the battery. The vehicle was taken to the local dealer where the battery was replaced. The vehicle was returned to the contact with rust and mold throughout the vehicle. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, who opened a case and discussed a buyback. The failure mileage was approximately 14,000.

Filed Apr 9, 2025 · Brakes, Electrical · SC

Car began flashing multiple warnings including power steering, brakes, basically all warnings. Power steering and brakes both failed. Took to dealership. Found wires and wire harnesses burnt and melted. Delaliship says it was due to a pinched wire on an after market winch however the winch was installed in 2022 and never had any issue before. They cited damage underneath on the skid plate which is very minor in nature and should not be able to cause such egregious errors.

Filed Apr 7, 2025 · Brakes, Lights · 30,000 miles · TX

The contact owns a 2021 Ford Bronco. The contact stated that while operating the vehicle, the brake warning lamp remained illuminated. The vehicle was taken to the local dealer, who diagnosed that the brake booster vacuum line was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 30,000.