The hard top is cracking and letting water into the cargo area. It seems to be right outside the parameters for recall number 26S32. Talk to dealer over a month ago and have not heard back yet.
2022 Ford Bronco body complaints
Page 2 of 2: complaints 11 to 30 of 30, newest first, as owners wrote them.
Cracks in left rear of roof theirs a recall ones that painted but not on the matt finish one. My 2022 Ford Bronco 2 door is showing the same problems as the paint ones. And Ford Dealership said they at least a dozen or more around his dealership with the same issue. And online I have been told of 100s. Have the same thing happening to their Broncos the years 2021 to 2024 even ones sit on lots for with the same problems.
Ford has issued a recall for 2021- Jan 2022 hard tops. Mine is a June 2022 with the same issues but not listed in the recall. This has been a known issue for the life span of the Bronco.
The Molded-In-Color (MIC) hard top shows signs of delamination and cracking on the exterior skin of the roof panel. Models from the same production year were called under the federal safety agency Recall No.: 26V299. My vehicle was not included on this recall. I have attempted to have Ford inspect the issue and have refused since it is out of warranty. I am concerned that the delaminating sections will detach while driving.
Noticed that my hardtop was cracking around the rear windows. This is a know issue with Ford and is being replaced under warranty. Unfortunately, my vehicle is outside of the original 3 year 36,000 mile warranty period by just over 6,000 miles that would qualify for replacement. The dealer quoted over $10,000.00 to replace the entire top since all roof panels appear to be affected. This is almost 1/4 the cost of my vehicle on the used market and is unacceptable for a know issue that would normally be replaced under warranty.
The hardtop developed cracks early on during the life of the vehicle. It leaks water. It’s a known issue with Bronco owners with the factory hardtop. Some people have had it replaced more than 3 times due to the same thing continuing to happen.
When closing the lift gate, the pistons did not compress and the glass shattered while still holding the lift gate. This resulted in cuts to two fingers on the left hand, ring and middle, cut across the knuckles with bleeding. Support struts are remove and are available for inspection. Not reported to dealer or police. Insurance notified, for replacement glass.
The rear hardtop panel on my 2022 Ford Bronco has developed serious cracking and surface separation after only three years of light, garage-kept use. The fiberglass is fracturing near the seams, exposing the underlying material. Water is now visibly collecting in the openings, which will lead to internal moisture intrusion, mold, and eventually corrosion of structural components underneath the hardtop mounting area. This poses a serious long-term safety concern, especially in the event of rear impacts or rollover situations. A Ford dealer inspected the issue and submitted a warranty claim, which was denied. The Ford representative acknowledged the damage but said they could not act without a recall or broader investigation. No warning lights or messages appeared; the issue is external and has progressed gradually. The damage began well before my bumper-to-bumper coverage expired, but has recently worsened. Ford’s own General Service Bulletin GSB 23-7174 lists rear hardtop panel cracking and edge delamination as warrantable conditions. My panel clearly fits those descriptions. Still, I was quoted nearly $10,000 for a full replacement, which is unreasonable. This is not an isolated case. Many 2021–2022 Bronco owners have posted identical problems online. Ford is clearly aware of this issue—which is why they issued that bulletin—but is denying claims unless pressured through complaints. I believe this is a materials or manufacturing defect and ask the federal safety agency to investigate this clear and ongoing failure.
The D-pillar clips are flimsy and break easily resulting in a soft top back panel that is no longer water proof and could fall apart.
Stitching and seals on the soft top have separated creating concern over large tear that could separate the soft top material from the frame and cause a safety issue. Brought this to the attention of the local dealer and said it would be addressed but they failed to address issue with return communication from dealer. Took to another dealer and Ford refused to repair despite it being approved previously and the stitching separating even further. The vehicle has been well maintained and not abused in any form or fashion. This is a concerning issue
The contact owns a 2022 Ford Bronco. The contact stated that while the vehicle was parked in the garage, the contact observed condensation under the front bumper. The vehicle was taken to a dealer where it was diagnosed that the front bumper needed to be replaced due to it filling up with gallons of water up to the fog light. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 5,115.
The contact owns a 2022 Ford Bronco. The contact stated while driving at approximately 55 MPH, the driver's side windshield pillar trim separated from the vehicle. The vehicle was taken to a local dealer, where it was determined that the windshield pillar trim needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 18,880.
Hard top is unlaminating around rear fixed windows at around 40000 miles ford offered to pay a portion this is not an isolated issue
Hard top rear section delaminating due to unfinished edges allowing moisture to enter ford offered to cover all but $1200.00 being the vehicle now has over 40000 miles believe it's a manufacturer defect should cover all cost
4 door hardtop roof leaks. It is available. There is nowhere, including Ford website, to report non-safety defects.
The contact owns a 2022 Ford Bronco. The contact stated while driving 65-70 MPH, the contact stated that the soft top of the roof made abnormal popping sounds, causing uncomfortable ear pressure. The contact rolled down the windows for the popping sound to cease. The vehicle was taken to the dealer, but no assistance was provided. The manufacture was contacted, and no assistance was provided. The failure mileage was 67.
My 2022 Ford Bronco 2 door hard top has wind (air leak) noise where the T-top joins the hard top. The weatherstripping does not properly seal causing wind noise, possible water intrusion (potential mold issue). This wind noise has been brought to the attention of the dealer and Ford's regional field engineer. The wind noise can cause hearing problems but not hearing emergency vehicles, and potential heating loss. The voids in the weather stripping can allow water to enter interior causing a mold issue. The factory has replaced the hard top once, but the issue still persist. This is a common problem with hard top Broncos.
Soft top leaks when it rains. Contacted local Ford Dealership and they have advised a design flaw from Ford, that they cannnot fix. Contacted Ford Motor Co. to advise of problem. They claim they are unaware of such issue and no fix at this time.
After exposure to rain, driver's side floods with water coming from A-Pilliar, Air Bags or Windshield.
Passenger and driver windows severely rattle/vibrate/shack when windows are open.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Ford Bronco?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history