2023 Ford Bronco body problems

Filed Nov 3, 2026 · Body · 18,000 miles · FL

The contact owns a 2023 Ford Bronco. The contact stated that while driving, the front driver side fender flare detached from the body of the vehicle. The contact associated the failure with the federal safety agency Campaign Number: 26V403000 (Structure); however, the part to complete the recall repair was not yet available. The dealer was contacted and the manufacturer was notified of the failure, and confirmed that recall remedy parts were unavailable and on backorder. On a separate occasion while driving, an exterior trim panel detached from the vehicle. The vehicle was not repaired. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair without providing a timeframe for parts availability. The failure mileage was 18,000.

Filed Oct 6, 2026 · Body · NH

The contact owns a 2023 Ford Bronco equipped with an aftermarket Bestop Skyrider retractable rooftop, Part Number: 5246217. The contact stated that while driving, the mounting bolts on the roof loosened up. The contact was concerned that the rooftop might detach and fly off while driving at highway speeds. The contact stated that water was entering the vehicle from the rooftop. The contact was concerned that water leaking into the vehicle could cause damages to the air bag system. The manufacturer and service center were notified of the failure. The aftermarket top was replaced, and the factory roof was reinstalled.

Filed Sep 9, 2026 · Body · CA

Cracking of the roof which has caused leaks. Common issue for Broncos, but only recalled for 2021-2022 Broncos. My Bronco is 2023 and has the same issue. It should also be a recall.

Filed Sep 7, 2026 · Body · NM

Front roof panel is cracking and chipping. Rear roof panel is cracking around the side windows. Bronco is never in direct sunlight unless driving. And the vehicle is never driven off-road.

Filed Aug 11, 2026 · Body · NC

The MIC hardtop is bubbling some at the top and has a line where it looks like perhaps it is assembled on the back panel over the top that is discolored in comparison to the rest of the top. Furthermore, the middle panel is a different color than the rest of the hardtop. It is available for complete inspection upon request. The car has not been inspected by dealer but was bought used and did not show the bubbling whenever it was purchased--but rather it has happened in the months since it was purchased. It was found when the top was removed and the bubbling was noticeable when running my hand over it. Note that it is not visible to be seen via picture, and the bubble must be felt. It cannot be seen in a photo.

Filed Jul 17, 2026 · Body · TX

The MIC hard top component on my Ford Bronco is cracking. I have gotten it replaced twice through Ford for the same issue, but now this is my 3rd top and the issue keeps coming back.

Filed May 20, 2026 · Body · CO

Delamination of roof and cracking with leaks

Filed Mar 30, 2026 · Body · 18,000 miles · MN

The contact owns a 2023 Ford Bronco. The contact stated that upon inspection the hard top roof, there were several cracks formed on the roof. The vehicle was taken to the dealer where the failure was acknowledged, and it was agreed that the hard top would be replaced under warranty. After the hard top was replaced, the contact inspected the new hard top and discovered several dents and uneven surfaces on the roof. The dealer was notified of the failure, and an agent advised the contact to bring the vehicle back to the dealer. The contact was informed that he could inspect the hardtops of the newer vehicles at the dealer lot and if he found a top that he liked, the dealer would swap the hardtop and replace the hardtop. After inspecting approximately 5 vehicles, each vehicle had issues with their hardtops. Upon investigation, the contact discovered General Service Bulletin: 23-7174, which was associated with the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 18,000.

Filed Jan 7, 2026 · Body, Visibility · NV

Chronic water leak from roofline obstructing vision and causing confusion while underway

Filed Aug 18, 2025 · Body · 11,000 miles · MD

The contact owns a 2023 Ford Bronco. The contact stated that after opening the driver's side door and then closing the door, the passenger's side hard top fractured into several pieces. The dealer was contacted and informed of the failure. The dealer confirmed that the repair would not be covered for free. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The manufacturer confirmed that the repair would not be covered. The manufacturer opened a case regarding the failure. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 11,000.