2023 Ford Bronco suspension problems

Filed Jun 3, 2026 · Steering, Suspension · CO

-Complete steering and suspension failure occurred while driving on highway. Vehicle is currently sitting at Ford dealer. - The safety of all passengers was put at risk and nearly caused a fatal accident. -Dealer and another shop are saying it was lower control arm and bushing failure. They are unclear on path forward for repairs and it seems like something bigger is going on they do not want to disclose. They deny problem has been reproduced on this model, however a similar recall for this type of failure has occurred on other bronco models under recall number 26S36. That recall report matches what happened to my vehicle. -It has been inspected by Ford and Bronco Barn in Las Vegas. I will be getting a third opinion for a clear path forward since none has been supplied by ford or the third party company. -There were no warning lamps, check engine lights, or messages prior to failure. There was a slight misalignment of tires felt while driving just prior to losing full steering control.

Filed Apr 13, 2026 · Electrical, Seats · OR

I am reporting unresolved safety recalls and unreasonable delay in repair for my 2023 Ford Bronco (VIN: [XXX] ). This vehicle currently has two open safety recalls issued by Ford Motor Company     •    the federal safety agency Recall 25V721 (issued October 2025) – seat frame defect that may increase injury risk in a crash. There is currently no available remedy, and Ford has notified me that a repair is not expected until April 2027.     •    the federal safety agency Recall 26V124 (issued March 2026) – APIM defect that may overheat and cause the rearview camera to fail while reversing, increasing crash risk. In addition, this vehicle has had prior recalls (25V025 and 25V273) that remained unresolved for extended periods. One of these recalls had no available repair for approximately 10 months. These recalls affect critical safety systems including suspension, rear visibility, and seat safety. The delay for Recall 25V721 is expected to exceed 18 months, which I believe is an unreasonable delay for a safety recall repair. Ford has continued issuing new recalls while prior recalls were still unresolved, indicating a pattern of repeated safety defects and delayed remedies. Due to these active recalls, I have been unable to use my vehicle commercially. Rental platforms such as Turo prohibit listing vehicles with open safety recalls. This has resulted in financial losses exceeding $80,000. This situation forces consumers to choose between operating a vehicle with known safety defects or suffering significant financial loss due to lack of repair availability. I am requesting that the federal safety agency investigate whether Ford is complying with its obligation to provide timely safety recall remedies and whether delays of this length are reasonable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 21, 2026 · Suspension, Transmission · WA

Front differential mounts are cracking and breaking leading to insecure front differential and damage to adjacent suspension and power train components. This is a significant risk to both the driver/occupants and potentially other vehicles on the road. This problem is appearing with increasing frequency on the Ford Bronco forums to the point that Ford now has a TSB out relating to this known engineering failure. It require an extensive repair including rewelding the mounting brackets. There appears to be inadequate guidance to the repairing dealers, however, as there is a large degree of uncertainty as to how to approach executing the weld repair, according to my dealer, Corwin Ford, in Spokane, Washington.

Filed Dec 25, 2025 · Driver assistance, Electrical · NC

My vehicle has both cracked and leaking rear shocks as well as issues with the rearview camera and infotainment system. I have gone through two Ford Dealerships to remedy this issue and was told parts are on back order. I attempted to remedy this issue when I first received notification that parts were available in August 2025. When I drive, I can feel the suspension is not providing support and continued use will cause other issues with the vehicle that may not be covered under warranty or the recall. My vehicle will also trigger the collision avoidance feature when there is physical trigger. This has caused my brakes to lock up in traffic.

Filed Aug 16, 2025 · Suspension · TX

My rear shocks have been corroding on the external resevior attached to the lower shock body and is rusting really bad in the exact place where the manufacturer of this vehicle says that it's breaking down ( rusting ) at. I called the dealership and the service department and they REALLY gave me the impression that they really don't want to repair my vehicle and is why I'm filling this report with the federal safety agency . I want the dealership of the manufacturer to replace my rear shocks with new shocks and not put RTV sealant and a retention clamp on this external resevior as stated as one of the remedies the manufacturer has listed in a letter sent out to all of it's dealerships about the manufacturers recall on the rear shocks . In the manufacturer's letter it does state that one of the remedies is replacing the shocks but ONLY if the shocks are leaking oil from the shock resevior/ flange damper area . The corrosion on my shocks are bad . The manufacturer is not SERIOIS about fixing this problem and is why I trust the federal safety agency to help me and thank you the federal safety agency .

Filed Jul 9, 2025 · Suspension · TX

I was driving on the back of my property and a loud pop and clanking sound occurred right where the rear shocks are ; also there was/is a thin oil film all around the area where the shocks are . FORD is not fixing this problem is why I'm filing this report . I've also tried reaching out to Ford a few times with no success. THIS has been a problem for four years with Ford and no one has held Ford accountable. Lawsuits it seems are the only method that works I hope NHSTA proves me wrong. Sincerely [XXX] , thank you the federal safety agency INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 27, 2025 · Suspension · MA

Driving down the interstate with cruise control set to 65mph, I went over a seam in the pavement and the vehicle began to swerve violently. I had to fight to maintain control as the TCS kicked in. I was able to regain control, but upon getting home saw the driver's rear shock has blown and lost all the fluid inside. I have contacted Ford over this near crash and they have told me that my only option on this open recall is to wait or pay to fix this myself. The part is available, I can buy it, but Ford is claiming there is no part available and that patience is the best course of action on this safety issue.

Filed Feb 19, 2025 · Suspension · SC

Despite many attempts Ford or any of its local dealers will not assist in providing me a remedy for this issue. This is a rental vehicle that has been decommissioned indefinitely due to the recall. Ford and its dealers will not provide me any fair way to trade the vehicle in for one without a recall. They will not provide me any sort of rebate to counter the discount in value I am getting with any dealer.

Filed Feb 5, 2025 · Suspension · 12,842 miles · GA

The contact owns a 2023 Ford Bronco. The contact received notification of the federal safety agency Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that upon inspecting the rear shock absorbers, the contact became aware that the rear shock absorbers were leaking. The contact had previously noticed that the front shock absorbers were leaking. Additionally, the contact stated while driving at various speeds, the vehicle was bouncing, and the ride was rough. The local dealer was contacted and advised the contact to take photos of the failure and send the pictures to the manufacturer. The manufacturer was contacted, and a case was opened; however, the manufacturer declined to receive the photos of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 12,842. VIN tool confirms parts not available.

Filed Feb 4, 2025 · Suspension · 14,000 miles · OH

The contact owns a 2023 Ford Bronco. The contact received notification of the federal safety agency Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle was bouncing while driving. The contact stated that the failure was more pronounced while driving over potholes or on uneven pavement. The dealer was contacted. The manufacturer was made not aware of the issue. The failure mileage was 14,000. VIN tool confirms parts not available.