Ford Bronco loss of power problems

Filed Oct 16, 2026 · Fuel system · 8,000 miles · NY

The contact owns a 2022 Ford Bronco. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline). Upon contacting the dealer and the manufacturer recently, the contact was informed that the recall repair was previously completed. The contact stated that the vehicle was never serviced for the recall, and the failure remained present, causing the vehicle to lose power and to stall while driving. The failure mileage was 8,000.

Filed Oct 16, 2026 · Acceleration, Engine · MI

My 2024 Ford Bronco repeatedly loses power without warning while driving, including on highways, suddenly slowing to approximately 32 mph. It also fails to accelerate from traffic lights, leaving me stranded in traffic. Dashboard warnings include Powertrain Malfunction, Service AdvanceTrac, Check 4x4, and Pre-Collision Assist Unavailable. On September 30, 2026, at 9:43 PM, the vehicle lost power on the road, nearly causing a rear-end collision. I have videos documenting six incidents between September 30 and October 15, 2026. This dangerous problem has continued since May 2025. Briarwood Ford has attempted repairs seven times, including replacing the accelerator pedal twice and replacing or repairing the engine wiring harness. The vehicle has been out of service for over 60 days, yet the problem continues. Ford diagnostic data from October 15–16 identified codes P2138, U0401, U0403, and U0418. I no longer trust this vehicle to transport my family to chemotherapy appointments or allow my children to drive it. Sudden power loss in traffic creates a serious risk of injury or death. I request an immediate the federal safety agency safety investigation into this recurring, unresolved defect.

Filed Sep 17, 2026 · Fuel system · TX

When attempting to accelerate from a stopped position to enter loop [XXX] in [XXX]. My vehicle experienced total loss of power due to failure of the low pressure fuel pump. This created a very dangerous situation as I was attempting to enter the highway from the access road. This event very nearly resulted in a crash that could have caused serious bodily injury or death to me. The vehicle was taken to the closest Ford dealership, Red McCombs Ford in [XXX]. The incident was described to the service representative and taken in for diagnosis. The next week, the service representative contacted me to tell me that they were able to replicate the issue in testing and that the low pressure fuel pump had experienced mechanical failure. They said, unfortunately Ford does not have an approved remedy available yet. I told them that I was aware that the failed part was indeed available and had found documented cases where Ford had chosen to approve replacing it for individuals experiencing the same problem. It isn’t a case of a replacement part being available, it is a case of Ford not wanting to replace the failed part and instead attempting to find a software fix that allows for preserving the life of the potentially defective part. However, this is not an acceptable solution once the part has already failed. The service representative stated they were trying to get Ford to authorize the repair, since one is available, but Ford was declining because the had not yet announced an “official recall remedy”. Then I opened a case with Ford Customer Care and they too declined to fix the issue. When I relayed my concern that driving the vehicle would expose me to serious injury or death, they continued to decline. I asked if it was safe to drive and they said “Ford has not issued instructions to stop driving”. Ford is refusing to repair a known safety recall where they are aware of a remedy exists. My Ford Customer Care Case is CXH-09364617-D9H7V8 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

Filed Aug 26, 2026 · Visibility · NJ

Windshield is leaking water/rain inside vehicle. I have it at All American Ford Old Bridge,NJ, for 15 days now and they want to charge me portion $256.76 plus tax. BUt, the Bronco has recall 222c12 or 25C52. I was willing to pay not knowing that there as a recall but they said if it breaks or cracks or chips while doing work they are not responsible to cover new windshield. please advise. They show on Ford recall website the recall complete, but my windshield was never removed, resealed and reinstalled. So that is a lie/fraud on All American Ford part. Please help. I have 2 other major issues with Bronco as well which are recalls that they made me pay for or did not resolve as of yet. I already paid for a middle roof panel and now front passenger roof panel must be replaced (recall 26S32) and they say it is not part of recall. And, the safety concern is the car just turned off on major highway 2 different episods one in May on NJ Turnpike I was almost hit from behind and the other was on Route 35 in Seaside Park, NJ in August. Same dealership said they can't experience it so they cannot diagnose and repair it. It is the fuel pump/loss of power issue #26V236000. the car has to be restarted and there is no warning. I am very worried about this.

Filed Aug 19, 2026 · Engine, Fuel system · TX

Loss of power or acceleration randomly, when pressing on the pedal. A recall was issued that it was a fuel pump failure June of 2025. One year and two months later there is still no solution to this recall. I am mostly submitting this covering all bases and am filing a complaint with Ford motor company as well. This is a serious safety concern as without warning the car basically dies so turning in front of oncoming traffic or pulling out onto a road poses great risk when the vehicle may cease functioning.

Filed Aug 13, 2026 · Brakes, Electrical · GA

While driving, I experienced the brakes beginning to fail, followed shortly by a complete loss of engine power. My 2021 Ford Bronco is subject to recall 25S75 (the federal safety agency 25V455) for a low pressure fuel pump defect that can cause loss of fuel pressure or flow and engine stall. I was stranded on the side of the interstate in 100 degree heat with my newborn in the vehicle. This was a dangerous situation, not a minor inconvenience. I had the vehicle towed to an AAA Car Care Center in Charlotte, NC, where the fuel pump failure was diagnosed. AAA could not perform a repair because the issue falls under an open safety recall. I contacted the Ford Recall Assistance Center and was told no remedy is currently available for recall 25S75. I also visited Capital Ford Charlotte, who confirmed the same, that no remedy exists yet. With the vehicle inoperable and no repair available anywhere, I paid out of pocket for private transport to move the vehicle to my home in Newnan, GA, since Ford could not confirm coverage for towing to my home dealership. As of August 12, 2026, the federal safety agency materials still list the remedy for 25S75 as under development. My vehicle remains inoperable with no path to repair. This is now also preventing me from selling or trading the vehicle. A dealership (Buford Toyota) declined to even appraise it because it will not run. I am filing this complaint to document that an open, unremedied safety recall directly caused a vehicle failure that endangered myself and my infant child, and continues to leave the vehicle unusable and unsellable months later.

Filed Jul 28, 2026 · Engine · GA

The vehicle experienced a sudden, severe mechanical engine condition resulting in a violent rough idle, loss of motive power, and a flashing Check Engine light with hard misfire codes on Cylinders 4, 5, and 6 (the entire driver-side engine bank). Additionally, the vehicle has been losing engine coolant internally with no external leaks or puddles on the ground, indicating fluid is entering the combustion chambers. These symptoms exactly mirror the mechanical pattern documented in Ford Safety Recall 24S55 (the federal safety agency Campaign Number 24V635) involving brittle engine intake valves fracturing. This vehicle has an August 2022 manufacture date and sits just outside the manufacturer's current restricted recall window, indicating that the defective component batch extends significantly past the reported dates. Component Availability: The engine is intact and available for federal inspection. Safety Risk: The sudden loss of engine power, hard stalling, and severe misfires while operating the vehicle creates an immediate risk of being rear-ended by traffic or stranded on a high-speed roadway without motive power. Dealer Confirmation/Inspection: These symptoms occurred recently at roughly 58,300 miles. The vehicle is currently being towed to an authorized dealership for diagnostic confirmation, relative compression testing, and cooling system pressure testing to officially verify the root cause. It has not been inspected by police or insurance representatives. Warning Symptoms: Prior to the sudden rough idle, the vehicle exhibited a low coolant level in the reservoir. There were no dashboard warning lamps or performance symptoms prior to the sudden flashing Check Engine light and immediate hard misfires.

Filed Jun 16, 2026 · Engine, Transmission · ID

While operating the vehicle under load, the vehicle suffered a sudden and severe loss of engine performance, followed immediately by loud metallic banging from the engine bay. The vehicle lost all power and was immediately disabled (LIMP MODE), presenting an imminent highway safety hazard.The Physical Damage: Subsequent mechanical teardown revealed deep vertical cylinder wall scoring, heavy raw fuel residue in the engine oil pan, and a blown head gasket. Relationship to Active Safety Defect: This catastrophic block failure perfectly mirrors the progressive failure profile of the federal safety agency Campaign 25V455 / Ford Safety Recall 25S75 (Low-Pressure Fuel Pump Failure). Internal component degradation in the fuel tank delivery module dropped fuel pressure to the engine. Under turbo boost, this starvation induced an extreme, instantaneous lean-out condition. The resulting low-speed pre-ignition (LSPI) exploded and shattered the internal piston rings (the metallic banging), leading to mechanical wall gouging, unburnt fuel wash into the lower crankcase, and a secondary blown head gasket. Request for Action: Ford's current VIN parameters for Recall 25S75 have not yet captured my specific vehicle despite it matching the exact production window, component setup, and catastrophic failure sequence. I am requesting that the federal safety agency log this case as clear evidence of consequential engine destruction originating from the 25V455 pump defect, and evaluate whether Ford's recall scope must be expanded to protect other consumers from highway engine failures.

Filed Jun 16, 2026 · Engine, Transmission · ID

The Incident: While operating the vehicle under high load, the driver received an explicit "Service Engine Soon" powertrain malfunction alert stating: "The powertrain control module lost communication with the vehicle active grill shutter module for a period of time." Immediately following this warning, the engine experienced a severe loss of power, followed by loud metallic banging from the engine bay. The vehicle stalled completely and lost all motive power, creating an imminent highway safety hazard.The Physical Damage: Subsequent mechanical teardown by the dealership revealed terminal block destruction, including deep vertical cylinder wall scoring, heavy unburnt liquid gasoline residue in the engine oil pan, and a blown head gasket.Relationship to Active Safety Defect: This catastrophic engine failure mirrors the progressive failure profile of the federal safety agency Campaign 25V455 / Ford Safety Recall 25S75 (Low-Pressure Fuel Pump Failure). In this EcoBoost architecture, the Active Grill Shutter (AGS) module shares critical voltage paths, grounding blocks, and wiring looms with the engine management and fuel delivery systems. The sudden network communication loss is diagnostic proof of a severe voltage drop or electrical short caused by the high-friction fuel pump degradation detailed in Recall 25S75. This circuit failure instantly starved the engine of fuel under turbo boost, inducing an extreme lean-out condition. The resulting pre-ignition forces violently shattered the internal piston rings (the loud banging), which then gouged the cylinder walls, wiped out compression, fouled the crankcase with fuel residue, and blew the head gasket.Request for Action: Ford's current VIN parameters for Recall 25S75 have not yet captured my specific vehicle despite it matching the exact production window, component setup, and catastrophic failure sequence. I am requesting that the federal safety agency log this case as definitive evidence of consequential engine destruction originating from the 25V455 fue

Filed Mar 19, 2026 · Electrical · SC

My vehicle is experiencing potential electrical issues which appear to be similar to the same 12-volt battery management failures that are currently recalled in the Bronco Sport models. The "Charging System Service Now" alarm continues to pop up, sometimes every 30 seconds. I am also not able to use my communication and navigation system, and I am not sure if this is related to the same electrical system malfunctions. Furthermore, on three recent occasions, my vehicle stalled while I was pulling out of a street which was on a slight incline, another while I was on a hill in a parking lot, and another while I was reversing and putting my car into 1st gear to drive. During all of these occasions, my vehicle stalled and did not automatically re-start which had me blocking traffic while I turned my vehicle back on. All of these issues have affected the safety of myself and my passengers due to the unexpected stalling as well as electrical power loss, including loss of navigation/communications. It has also resulted in me getting pulled over by law enforcement twice due to swerving while I was looking at the screen when it went black and the other because I was speeding because my Charging System Service alarm went off and I was also unable to determine the speed limit of that road without having my navigation screen working. I believe I have contacted the Ford Dealership regarding the specific loss of the communication and navigation issue and was told they did not have the parts/software available at this time. I have taken my vehicle to an Advance Auto Parts store when the "Charging System Service Now" first appeared and was told it was potentially the alternator. I will have to locate the documentation at a later time.