2011 Ford Edge fuel system problems

Filed Nov 19, 2025 · Fuel system · FL

See attached document for complaint.

Filed Oct 21, 2024 · Fuel system · 70,000 miles · FL

The contact owns a 2011 Ford Edge. The contact stated that while the vehicle was unoccupied and parked inside the residential garage, there was a fuel odor entering the house. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with a roll-over valve failure. The contact was informed that the roll-over valve needed to be replaced along with other unknown repairs. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

Filed Oct 12, 2022 · Fuel system · CA

Cel light and P0456 diagnostic reading indicates an EVAP leak. Large fuel leak discovered emanating from the fuel tank area when tank is at full. Fuel tank was removed and upon inspection it revealed the fuel tank had cracked at the top of the rollover valve just underneath a vent line. There is no recall for this fuel tank as there should be. A new fuel tank is ordered and awaiting delivery as there is no replacement part or means to install a new rollover valve. Cost of tank at discount is $1000. Photo of cracked area is attached.

Filed Feb 8, 2022 · Fuel system · NV

Failed fuel tank. Noticed fuel like smell when starting car for two weeks but saw no indication of anything wrong. Last week fuel splashed out from underneath vehicle after pulling out of driveway leaving large puddle and stream of fuel. Visual assessment indicated fuel leakage from top portion of fuel tank. Contacted mechanic who removed tank to assess source of leakage and found issue to be damage at rollover valve and severe leakage. There were no warning lamps or messages indicating issue. Severe fire hazard putting safety of my family, self, and home at risk.

Filed Jun 4, 2021 · Fuel system · 91,000 miles · WI

The contact owns a 2011 Ford Edge. The contact stated that upon entering and exiting the vehicle, there was an abnormal fuel odor present. The contact took the vehicle to a dealer where they discovered a leak in the fuel tank due to a defective gasket. The contact stated that the same failure had occurred years prior. The same dealer had performed an unknown repair to the vehicle however, the failure recurred. The manufacturer was notified of the failure and they informed the contact that the VIN was not under recall. The vehicle was not repaired. The failure mileage was approximately 91,000.

Filed Apr 8, 2021 · Fuel system · 116,364 miles · MN

Ptu is leaking I know there was a recall for the f-350s

Filed Mar 31, 2021 · Fuel system · 28,000 miles · AZ

The roll-over valve on the top of the fuel tank cracked allowing gas to escape when the tank was over half full. The rollover valve is part of the tank assembly and cannot be replaced by itself. I had to purchase a new tank assembly for $1300 plus labor.

Filed Jan 11, 2021 · Fuel system · ID

Fuel leak. There are recalls for the same parts on the 2012 and 2013 ford edge. Just want to get my edge fixed so it does not catch fire

Filed Dec 3, 2020 · Fuel system · 115,000 miles · TX

Upon fueling of vehicle a strong smell of fuel is present and after parking overnight a significant puddle of fuel is discovered under the vehicle. This is a sever issue which neededs to be recalled to prevent a catastrophic event.

Filed Aug 14, 2020 · Fuel system · 86,000 miles · TX

Tl* the contact owns a 2011 ford edge. The contact stated upon entering his vehicle, he smelled an abnormal odor of gasoline after refueling. The contact stated that he went into his garage and saw a puddle of gasoline on the floor. The contact contacted an independent mechanic who advised him to refill the fuel tank to determine where the leak was coming from. The mechanic performed a diagnostic test and the result was a leaking seal by the rollover valve sensor. The manufacturer was notified, and informed the contact to file a complaint. The vehicle was not repaired. The failure mileage was 86,000.