The contact owns a 2008 Ford Edge. The contact stated that the vehicle was previously repaired under the federal safety agency Campaign Number: 14V682000 (Fuel System, Gasoline) on November 4, 2021. However, the vehicle experienced a fuel leak. The contact stated that the dealer applied a corrosion preventative to the fuel tank instead of replacing the fuel tank as expected. The dealer was not notified of the failure. The manufacturer was made aware of the failure. The failure mileage was 150,000.
Ford Edge fuel leak problems
115 of the 14,147 owner complaints about the Ford Edge describe fuel leak, most of them for the 2007 model year.
- owner complaints
- 115
- worst model year
- 2007
- typical repair cost reported
- $2,018
- typical mileage
- 101,000
Is there a fix? There are 6 recalls for this area of the car. See below
By model year
Often reported together
Fuel smell 44Check engine light 8Fuel pump 4Fuel gauge 4Stalling 2Misfire 2Fire or smoke 2Grinding brakes 2
Trouble codes mentioned
P0456 4
What owners say
check engine light came on took it to service they ran test on it code p0456 came up saying fuel leak
The contact owns a 2012 Ford Edge. The contact stated that while driving on several occasions at various speeds, or while the vehicle was parked, the contact observed an abnormal gasoline odor in the vehicle. Additionally, while driving at an undisclosed speed, the vehicle lost motive power while attempting to accelerate, with the check engine warning light illuminated. Additionally, a "Turbo Boost" message was displayed. The vehicle was taken to an independent mechanic who discovered a fuel leak. The contact was informed that either the fuel tank or fuel lines needed to be replaced. The manufacturer was not notified of the failure. The failure mileage was 98,260.
Brake booster went bad on the vehicle after 8 years. Brake pedal had to be pressed to the floor. The fuel line had a leak so anytime gas was put into the vehicle it would leak down the frame to the ground. Wiring for the back up camera goes in & out. I’m afraid of the brakes not working & a fire being caused by the leaking fuel or faulty electrical lines connecting the rear camera to the display.
My car was having issues and still is having issues starting after refueling. After putting fuel in the vehicle my car stalls out. I restart the car I have to give it gas before hurrying up and putting it in drive just to keep the car on. Due to a potential internal leak in the canister purge valve this can cause excessive vacuum in the fuel tank and can potentially lead to a crack in the tank, which can lead to a fuel leak and or fire. The check engine light came on reading one code. And because I'm unable to afford to have it repaired because of how expensive it is, I now have three codes coming off the check engine light. I smell fuel when I turn my car off or I'm running I'm running low on gas. My VSA light has also been on during all of this as well. I would gladly bring the vehicle to anyone to get it completely diagnosed by any professional of your choice.
Vehicle has the 2.0 EcoBoost Turbo engine. The original engine produced same issues, mechanic found coolant intrusion at around 78,000 mi and replaced it for around $6,000 out of pocket in March of 2023. Logged everything with the local Ford to ensure new engine warranty stayed intact. Now the replaced engine is experiencing the same and also more concerning issues. Starting in Late January early February 2025, engine has 19,000 mi, vehicle has around 97,700 mi. Vehicle issues began with rough idling & white exhaust at cold start. Vehicle began shutting off while driving. It would never show any signs beforehand, would be driving normally, and then suddenly vehicle shut off and losses all power. Happened 5 times to me going speeds averaging from 35-75, including 3 times on a highway. Took vehicle into shop multiple times to rule out issues. Mechanic noticed a leaking gasket (commonly known issue with this engine), knowing the engine had warranty it was towed to the local Ford dealership. Dealership said the engine was experiencing coolant intrusion. However, in order to even request for an engine replacement under warranty they would have to do an engine teardown at around $5,000 in labor out of pocket. This vehicle is unpredictable and has sat undriven since February 2025. Ford is doing everything to get out of fixing their manufacturing issue & to disprove the part warranty that no one will give me a copy of. This issue is also logged on the Service Bulletin 19-2346
The contact owns a 2009 Ford Edge. The contact stated that there was a strong fuel odor coming from the vehicle. Additionally, the contact noticed that fuel was leaking from the vehicle onto the ground. The contact who is as an independent mechanic, diagnosed the vehicle and determined that the fuel tank was leaking at the spot welds located on the upper part of the tank and at the mounting points on the fuel tank. The contact stated that the fuel tank was previously replaced under the federal safety agency Campaign Number: 15V712000 (Fuel System, Gasoline). The dealer and the manufacturer were notified of the failure and informed the contact that the vehicle could not be repaired under the recall a second time, and that the vehicle was not covered under warranty. The vehicle was not repaired. The failure mileage was approximately 157,000.
Had 2008 Ford Edge Limited AWD looked at while servicing for oil etc. Fuel smell noted at rear of vehicle. When looked at noticed wet fuel tank. Fuel tank is still on vehicle. (Ford wants $4400 to replace it) Independent shop JP Automotive in North Haven CT and Bob Thomas Ford in Hamden CT confirm tank is leaking. Bob Thomas Ford says not part of Ford TSB #14S22 (the federal safety agency #10076517) or Ford TSB #14R02 (the federal safety agency #10076296) A fuel leak in the presence of an ignition source may result in a fire. Causing danger to myself, my passengers, and others on the road. No warning lamps etc. Just a fuel smell at the rear of the vehicle that started.
I have been told that 2017 Ford Edge has a leaking gasket and that coolant is seeping into the engine and mixing with oil. Ford is telling me I need to replace the whole engine. Cost is $9200. They are telling me not to drive it. I guess this has been a problem with many similar Ford engines. Not sure why this is not covered by recall. Basically I am going to have to trash 7 year old car with 85,000 miles on it. I am very disappointed that Ford is not stepping up. I am also surprised that the federal safety agency hasnt extended the recall to this model.
The contact owns a 2017 Ford Edge. The contact stated that while the vehicle was parked, there was a strong fuel odor coming from the vehicle. Additionally, there was fuel leaking from the rear of the vehicle. The vehicle was not diagnosed or repaired. The VIN was not included in the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The manufacturer was notified of the failure. The failure mileage was 51,000.
Related recalls
Fuel system, gasoline: storage: tank assembly
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2009-2010 Ford Edge vehicles manufactured September 11, 2008, to July 1, 2010, and Lincoln MKX vehicles manufactured September 23, 2008, to July 1, 2010, originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Due to corrosion from salt water exposure such as from road salt use, the affected vehicles may leak fuel from the fuel tank seam weld under the tank mounting reinforcement brackets.
- Risk
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- Ford will notify owners, and dealers will inspect the vehicles and either clean and treat the fuel tank with a corrosion preventative or replace the tank, free of charge. The recall began on May 10, 2016. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 15S31.
Recall number 15V712000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- Ford Motor Company (Ford) notified the agency on January 8, 2015, that they are recalling certain model year 2014 Ford Escape vehicles manufactured April 15, 2014, to May 8, 2014, and 2015 Lincoln MKC vehicles manufactured April 21, 2014, to May 15, 2014. On April 30, 2015, Ford expanded the recall to cover an additional 45,505 vehicles, including certain model year 2014-2015 Ford Transit Connect vehicles manufactured November 11, 2013, to August 29, 2014, 2014-2015 Ford Fiesta vehicles manufactured April 10, 2014, to June 17, 2014 and 2014 Ford Edge vehicles manufactured April 30, 2014, to May 21, 2014. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.
- Risk
- If the fuel pump fails, the vehicle may stall without warning, increasing the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will replace the fuel pump, free of charge. The recall began on February 27, 2015. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 14S30.
Recall number 15V005000 · Recall details
Fuel system, gasoline: storage: tank assembly
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2007-2008 Lincoln MKX, and Ford Edge vehicles, manufactured June 15, 2006, to September 22, 2008, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Due to corrosion from salt water exposure such as from road salt use, the affected vehicles may leak fuel from the fuel tank seam weld under the tank mounting reinforcement brackets.
- Risk
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- Interim notices were mailed to owners on December 12, 2014. The recall began on October 6, 2015. Dealers will inspect the vehicles and either clean and treat the fuel tank with a corrosion preventative or replace the tank, free of charge. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 14S22.
Recall number 14V682000 · Recall details
Fuel system, gasoline
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2012-2013 Edge vehicles manufactured from September 2, 2010, through April 25, 2013, and equipped with 2.0L engines. The fuel line pulse damper metal housing may crack as a result of an improper manufacturing process. A cracked fuel line pulse damper housing may result in a combination of fuel odor, weepage, or a continuous leak while the fuel system is pressurized.
- Risk
- A fuel leak in the presence of an ignition source may result in a fire.
- Remedy
- Ford will notify owners, and dealers will replace the fuel line with one that does not have a damper, free of charge. The safety recall began on February 25, 2014. Owners may contact Ford at 1‑866‑436‑7332. Ford's number for this recall is 13S13. IMPORTANT: This recall supersedes recall 12V‑438. All vehicles that have been remedied under the previous recall need to have the current remedy applied.
Recall number 14V002000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- Ford is recalling certain 2012 Edge vehicles manufactured from September 2, 2010, through October 31, 2011, equipped with 2.0L engines. The fuel line pulse damper metal housing may crack as a result of an improper manufacturing process. A cracked fuel line pulse damper housing may result in a combination of fuel odor, weepage, or a continuous leak while the fuel system is pressurized.
- Risk
- A fuel leak in the presence of an ignition source may result in a fire.
- Remedy
- Ford will notify owners, and dealers will repair the vehicles free of charge. The safety recall began on September 27, 2012. Owners may contact Ford Motor Company Customer Relationship Center at 1‑866‑436‑7332.
Recall number 12V438000 · Recall details
Fuel system, gasoline: storage: tank assembly
- What is wrong
- Ford is recalling 142 my 2008 edge and lincoln mkk all wheel drive vehicles. The fuel tank weld fixture may have been exposed to a contaminant during production which could cause a dimple in the bottom of the fuel tank at a spot weld.
- Risk
- This dimple could result in a fuel leak or a fuel drip from the tank. Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Dealers will inspect and, if necessary, replace the fuel tank free of charge. The recall began on july 11, 2008. Owners may contact ford at 1‑866‑437‑7332.
Recall number 08V301000 · Recall details
Questions about the Ford Edge fuel leak
Which Ford Edge years have fuel leak problems?
The model years with the most reports are 2007 (45 complaints), 2008 (20 complaints) and 2013 (14 complaints).
How much does it cost to fix fuel leak on the Ford Edge?
Owners who mentioned a price put the repair at about $2,018 (median of 11 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ford Edge?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history