Ford Edge check engine light comes on

Filed Nov 5, 2026 · Engine · VA

One October 9, 2026, I took the my 2018 Ford Edge to the dealership (odometer reading 59,414 miles) because the check engine light was on. They performed a service to replace three spark plugs. About one day later, the check engine light came back on. I took the car back to the dealership service (odometer 59,678 mi) for the review on October 27, 2026. I was given a service report stating the engine needs to be replaced per tsb22-2229 coolant leaking into cylinders. At that point, I did some research on the internet and found this is a KNOWN problem for the 2018 Ford Edge with the 2.0L engine due to a flawed engine design. My engine has the potential to catch on fire or stop operating in unsafe conditions. I parked it before either situation could happen because my engine began to overheat.

Filed Nov 3, 2026 · Engine · 150,000 miles · NH

The contact owns a 2016 Ford Edge. The contact stated that the vehicle failed to immediately start on several occasions. After the vehicle was started, the check engine warning light remained illuminated, with white smoke coming from the exhaust pipes. Additionally, while driving, the contact heard a splashing fluid sound coming from behind the dashboard, and the coolant reservoir was constantly low. The engine was revving high while the vehicle was idling. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The contact associated the failure with the federal safety agency Action Number: DP26008 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the investigation. The failure mileage was 150,000.

Filed Nov 3, 2026 · Engine · IL

Upon doing a drive with 60,000 miles my check engine light came on. Upon taking it in to a dealer in Chicago, I was told that it had a coolant intrusion defect and that I would need to replace the entire engine ~11,000 quote. I then took it to two seperate dealerships, and got a video of it. They both confirmed this. I contacted ford and they have refused to help in an form. The component is the engine block. I am completely scared to take it on the road. I don't know what will happen as it shakes on startup now. The problem was reproduced by both. I have not had it inspected by insurance. Warning lamp was an engine light.

Filed Nov 3, 2026 · Engine · WI

While operating the vehicle, it experienced a sudden, unexpected loss of engine power, rough idling, and white smoke emitting from the exhaust due to internal engine failure. The vehicle’s check engine light illuminated, throwing codes P0301 for cylinder misfires, and P0316. A formal diagnostic inspection confirmed that this vehicle is suffering from the known manufacturing defect outlined in Ford Technical Service Bulletin (TSB) 19-2346, which involves internal coolant intrusion into the engine cylinders. The open-deck engine block design allows engine coolant to breach the cylinder head gasket and flood the combustion chambers. This creates an immediate safety hazard on public roadways. The sudden loss of acceleration and severe engine shuddering occurred without warning while driving, exposing the vehicle and its passengers to a high risk of a rear-end collision in active traffic. Ford Motor Company has denied out-of-warranty or goodwill assistance to resolve this defect. This issue directly aligns with the ongoing the federal safety agency investigation into Ford EcoBoost coolant leaks and structural engine failures. I am filing this to request that the agency upgrade its current inquiry into a mandatory safety recall to protect consumers from catastrophic highway engine failure. Current Vehicle Mileage: 85,000 miles

Filed Nov 3, 2026 · Engine · PA

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine experienced sudden loss of power due to internal coolant leak resulting in engine overheating while driving at approximately 55 MPH. This vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? An unexpected loss of propulsion while traveling at highway speeds or navigating traffic creates an obvious safety hazard for the driver, passengers, and other motorists. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. This vehicle's engine problem has been INSPECTED and CONFIRMED by a Ford dealership dealer as well as an independent service center. The Ford dealership confirmed that this issue is related to TSB-22-2229. Additionally, this is A DOCUMENTED AND PREVIOUSLY IDENTIFIED ENGINE PROBLEM by Ford dating back to 12 June 2019. Ford has issued multiple Technical Service Bulletins addressing coolant intrusion into the cylinders of certain 2.0-liter EcoBoost engines. Of particular relevance are: •TSB 19-2172, dated June 12, 2019. •TSB 19-2208, dated June 26, 2019. •TSB 22-2229, dated June 9, 2022. TSB 22-2229 specifically identifies coolant intrusion into the cylinders as a known condition affecting certain 2015–2018 Ford Edge vehicles equipped with the 2.0-liter EcoBoost engine. The bulletin identifies symptoms including low coolant levels, white exhaust smoke, rough engine operation, and associated diagnostic trouble codes. More importantly, Ford's prescribed corrective action for vehicles meeting the specified criteria is replacement of the engine long block assembly. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. There was also a MIL (Malfunction Indicator Lamp) activated at the time of the incident, approximately 7:50 AM on 13 October 2026.

Filed Nov 2, 2026 · Engine · 100,000 miles · TX

The contact owns a 2018 Ford Edge. The contact stated that while driving 45 MPH, there was an abnormal grinding sound coming from the engine and the vehicle lost automotive power. The check engine warning light was illuminated. The vehicle was towed to the residence. An independent mechanic arrived at the residence and diagnosed the vehicle. The vehicle was diagnosed with engine failure, and the contact was informed that the engine needed to be replaced. The failure mileage was 100,000.

Filed Oct 30, 2026 · Engine · MI

Engine is leaking coolant into combustion chambers, causing misfire and check engine light to come on. This issue is a known issue by Ford, with multiple TSBs (I have found 19-2346 and 22-2229 so far) Error code on diagnostic was P-0302. This issue was found at North Brothers Ford in Westland MI. We were quoted over $8,000 to have this replaced. We were told that our family car cannot be driven safely because of this issue, as it can cause the engine to just die where it sits, which could be catastrophic.

Filed Oct 29, 2026 · Engine, Transmission · CA

horn stopped working for unknown reasons fuses were checked, all good fuses same with relays and clock springs, horn appears too no longer work on my vehicle the vehicle only has 121k miles, check engine light popped on and all it says is spark plugs got the coils and plugs done same issue. got a dignosis done piston rings have failed at 121k miles. cv axle issue has became disconnected from joint. expensive repair.

Filed Oct 23, 2026 · Engine · PA

I am currently dealing with the coolant intrusion into cylinder 2 of the 2.0L EcoBoost engine. In the beginning of XXX at about 134K miles, the check engine light came on. I was at a stop light (.2 miles from my home) and I got a warning message telling me the coolant temp was high and engine power was reduced. When I got home, I saw that the coolant was low, but there has not been any leaks noticed in driveway, refilled and was fine for 2 weeks. During those 2 weeks, I was having a rough idle at start up, and white smoke coming from exhaust. Then on the way to work the engine was overheating. Pulled over and turned off on the side of a highway to let it cool. After 10 minutes, turned the car back on to continue to work (which was a mile away), also turned on the heat to pull from the engine, the air was cold until I started driving then it warmed. I am now having to fill the coolant every few days and having misfires while accelerating causing me to stall and then traffic approaching me having to slow to avoid hitting me. I purchased this vehicle used in XXX from a dealership in [XXX] and the carfax did not state any of these issues at the time of purchase. The only repair given is the TSB 19-2346, and no safety recall has been issued for this defect. This defect poses a safety risk as it can lead to sudden engine stalling, loss of power while driving, and potential engine fires due to overheating. There is a financial burden since this repair is costly and Ford will not help with the cost of this repair. Car warranties are denying claims because Ford as acknowledged this defect. And dealerships are still selling these used cars despite the issues and because it is not a recall, they are not held liable for these repairs or made to disclose the defect. This is a huge safety issue and financial burden. As I am now out of a vehicle THAT FORD NEW WAS A DESIGN DEFECT.

Filed Oct 23, 2026 · Engine, Fuel system · NY

I have a 2018 Ford Edge with the 2.0L EcoBoost engine. Currently the head gasket is cracked and coolant is constantly dripping out under hood. Im constantly running out of coolant and my engine light is on.