Ford Edge fire or smoke problems

Filed Nov 5, 2026 · Engine · VA

One October 9, 2026, I took the my 2018 Ford Edge to the dealership (odometer reading 59,414 miles) because the check engine light was on. They performed a service to replace three spark plugs. About one day later, the check engine light came back on. I took the car back to the dealership service (odometer 59,678 mi) for the review on October 27, 2026. I was given a service report stating the engine needs to be replaced per tsb22-2229 coolant leaking into cylinders. At that point, I did some research on the internet and found this is a KNOWN problem for the 2018 Ford Edge with the 2.0L engine due to a flawed engine design. My engine has the potential to catch on fire or stop operating in unsafe conditions. I parked it before either situation could happen because my engine began to overheat.

Filed Nov 3, 2026 · Engine · 150,000 miles · NH

The contact owns a 2016 Ford Edge. The contact stated that the vehicle failed to immediately start on several occasions. After the vehicle was started, the check engine warning light remained illuminated, with white smoke coming from the exhaust pipes. Additionally, while driving, the contact heard a splashing fluid sound coming from behind the dashboard, and the coolant reservoir was constantly low. The engine was revving high while the vehicle was idling. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The contact associated the failure with the federal safety agency Action Number: DP26008 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the investigation. The failure mileage was 150,000.

Filed Oct 23, 2026 · Engine · PA

I am currently dealing with the coolant intrusion into cylinder 2 of the 2.0L EcoBoost engine. In the beginning of XXX at about 134K miles, the check engine light came on. I was at a stop light (.2 miles from my home) and I got a warning message telling me the coolant temp was high and engine power was reduced. When I got home, I saw that the coolant was low, but there has not been any leaks noticed in driveway, refilled and was fine for 2 weeks. During those 2 weeks, I was having a rough idle at start up, and white smoke coming from exhaust. Then on the way to work the engine was overheating. Pulled over and turned off on the side of a highway to let it cool. After 10 minutes, turned the car back on to continue to work (which was a mile away), also turned on the heat to pull from the engine, the air was cold until I started driving then it warmed. I am now having to fill the coolant every few days and having misfires while accelerating causing me to stall and then traffic approaching me having to slow to avoid hitting me. I purchased this vehicle used in XXX from a dealership in [XXX] and the carfax did not state any of these issues at the time of purchase. The only repair given is the TSB 19-2346, and no safety recall has been issued for this defect. This defect poses a safety risk as it can lead to sudden engine stalling, loss of power while driving, and potential engine fires due to overheating. There is a financial burden since this repair is costly and Ford will not help with the cost of this repair. Car warranties are denying claims because Ford as acknowledged this defect. And dealerships are still selling these used cars despite the issues and because it is not a recall, they are not held liable for these repairs or made to disclose the defect. This is a huge safety issue and financial burden. As I am now out of a vehicle THAT FORD NEW WAS A DESIGN DEFECT.

Filed Oct 20, 2026 · Engine · ME

Car started running running roughly with white smoke coming out the exhaust. As since researched, it’s a known issue, the coolant intrusion into the cylinder. Repair shop says it needs a new engine. I called Ford to check to see if they could offer any assistance but they couldn’t, the car is just out of warranty (2019 with 62,000 miles). They opened a case #CXH-09690702 and advised to keep all repair receipts in case Ford should ever do a recall in the future.

Filed Oct 19, 2026 · Electrical, Engine · UT

I have barely had my car now for 2 years and have had nothing but problems with it since the day I bought it it spends more time in the shop then any other vehicle I’ve owned! I’ve had to relaxed the coils 8 times now in the past year 5 of them in the past 5 months! The coolant continues to leak into the fuel system calling it an COOLANT INTRUSION which is causing havoc on my cold my engine my catalic converter to get extremely hot and causing my coils to burn and melt leaving me stranded alone on dark freeways costing me hundreds now thousands from having to have it towed to time in the shop parts and labour not to mention countless hours and days missed off work unable to get there or being late already lost one job and on the verge of losing another! The lady 2 coils that I had to replace weren’t lasting more than a week to a few days! I know there are countless complaints about this issue and major problem! WHY HAS THERE NOT BEEN ANYTHING DONE ABOUT IT YET WHY ISN’T THIS BEEN RECALLED ARE THEY WAITING FOR SOMEONE TO GET KILLED BECAUSE THEIR STATUS ON FIRE AND BLOWS UP?? I’m ready to start Law suit this is not right nor ok! We trust these manufacturers to build safe reliable vehicles and if not then they need to replace or repair them! This is the only vehicle I have and I’m disabled and can’t just go out and buy a new car let alone continue to pay for repairs I shouldn’t ever have to pay for over and over again! Please help?! You want dates? I have several dates!

Filed Oct 13, 2026 · Engine · TN

Hello, I'm on permanent disability and this my only car. it started with noticing white smoke coming out of the exhaust and a sweet smell. also noticed the coolant getting low and had to keep adding more in with no visible leaks. I pulled cylinder one plug and put a bore a scope down it and found a crack in the cylinder wall. I found a web site that said there was a class action law suite miller vs. ford for this issue, it told me to call these two dealer ships Ted Russel Ford and Ray Cunningham Ford to have my car fixed free of charge. The web site told me if they said no, to contact the federal safety agency and file a complaint. I also called the federal safety agency they told me to contact the state attorney office they suggested to also file a complaint to the state, and I did that. I found this information below that looks like the issue. the federal safety agency ID Number: 10214126 Manufacturer Communication Number: TSB 22-2229 Components: ENGINE AND ENGINE COOLING

Filed Oct 9, 2026 · Engine · NC

I am currently dealing with the coolant intrusion into cylinder 2 of the 2.0L EcoBoost engine. In the beginning of XXX at about 125K miles, the check engine light came on. I was at a stop light (.2 miles from my home) and I got a warning message telling me the coolant temp was high and engine power was reduced. When I got home, I saw that the coolant was low, but there has not been any leaks noticed in driveway, refilled and was fine for 2 weeks. During those 2 weeks, I was having a rough idle at start up, and white smoke coming from exhaust. Then on the way to work the engine was overheating. Pulled over and turned off on the side of a highway to let it cool. After 10 minutes, turned the car back on to continue to work (which was a mile away), also turned on the heat to pull from the engine, the air was cold until I started driving then it warmed. I am now having to fill the coolant every few days and having misfires while accelerating causing me to stall and then traffic approaching me having to slow to avoid hitting me. I purchased this vehicle used in XXX from a dealership in [XXX] and the carfax did not state any of these issues at the time of purchase. The only repair given is the TSB 19-2346, and no safety recall has been issued for this defect. This defect poses a safety risk as it can lead to sudden engine stalling, loss of power while driving, and potential engine fires due to overheating. There is a financial burden since this repair is costly and Ford will not help with the cost of this repair. Car warranties are denying claims because Ford as acknowledged this defect. And dealerships are still selling these used cars despite the issues and because it is not a recall, they are not held liable for these repairs or made to disclose the defect. This is a huge safety issue and financial burden. As I am now out of a vehicle that I just purchased a year ago. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 8, 2026 · Engine · 95,655 miles · MD

The contact owns a 2018 Ford Edge. The contact stated that while driving, the check engine warning light illuminated. The contact stated that the vehicle was losing coolant, but there was no leak found. The vehicle was towed to Meineke, where it was informed that the engine needed to be replaced. The vehicle was towed to an unknown dealer, but no issue was found. There was coolant added to the coolant reservoir. The vehicle was placed on a pressure machine for 4 hours, and a small leak was found. The contact was informed that the head gasket needed to be replaced. The thermostat and cap were previously replaced, and the vehicle was repaired. There was smoke coming from the vehicle. The contact stated that the dealer had not thoroughly checked the vehicle. The failure mileage was approximately 95,655.

Filed Sep 26, 2026 · Engine, Suspension · CA

Bought car used 4 months ago from Peoria Ford, Glendale. Vehicle overheated on freeway, added coolant- lost all coolant 10 minutes later and white smoke came from exhaust. Ford diagnosed EGR cooler failure, replacement and noted CV joint boot leaking and needed replaced- resulting g on $3200 fix with zero assistance from Dealership or Ford.This issue didn’t happen suddenly after 4 months & we believe it was existing prior to the purchase. Read reports of cooler, coolant/ engine issue on 2020 ford edge. These models should be recalled for fix as my daughter was stranded on the freeway at night - safety issue.”

Filed Sep 18, 2026 · Engine · IL

My 2018 Ford Edge has coolant intrusion. It reads coolant level too high, has a rough idle, a burning smell sometimes, and white smoke starting to emit from the tailpipe. The oil is a light brown color and the air no longer blows cold. This is a very costly disaster!!!😫😭😭