Ford Edge won't start problems

Filed Oct 20, 2026 · Engine · IN

"I am reporting a severe, known manufacturing defect involving internal coolant intrusion on my 2018 Ford Edge 2.0L EcoBoost, which has caused total engine failure and rendered the vehicle entirely unsafe and completely inoperable. The vehicle began throwing codes P0300 (Random Misfire), P0302 (Cylinder 2 Misfire), and P0303 (Cylinder 3 Misfire) due to liquid coolant flooding the combustion chambers. The engine is now completely locked and will not start, stranding me at home with no transportation. This is a critical safety issue. Liquid coolant leaking into active engine cylinders poses an immediate risk of sudden engine stalling while driving, loss of motive power in traffic, and potential engine fire hazards. This failure matches Ford's own Technical Service Bulletin (TSB 22-2229), proving Ford has long-standing knowledge of this hazardous design defect. When I contacted Ford Motor Company corporate customer service for emergency assistance and towing to a dealership, Ford explicitly refused to assist me and instructed me to contact class-action plaintiff's attorneys instead. Ford is actively refusing to remedy a severe, known safety hazard for a stranded consumer. I request that the federal safety agency escalate its investigation into Ford EcoBoost coolant intrusion to force a mandatory safety recall before this defect causes a serious highway accident."

Filed Sep 12, 2026 · Engine · MO

Recently purchased the vehicle, the following morning after purchased, the check engine light came on and I had it hooked to a computer scanner for it showed a cylinder 3 misfire. We also visually notice that the coolant level in the reservoir was somewhat low after sitting for several hours, so we filled the coolant reservoir to the appropriate line shown on the tank, but just between the afternoon when it was purchased , and that next morning there was no coolant that had leaked underneath the vehicle . The dealer that I purchased it from had the spark plugs, the spark plug wires and the ignition coils replaced. When I picked up the vehicle after those were replaced, I drove it for about a total of 40 miles before the check engine light came back on and upon starting, the vehicle started kind of rough like it wasn't igniting completely. Over the next day and a half upon each start whether it be a cold start or not, the vehicle started in the same way where it felt as though it was not getting a good ignition or fire but it would still start up. I took the vehicle to a Ford dealership where the technicians connected their diagnostic scanner and also did a pressure test where it reported to have coolant intrusion and would require a new motor . As I could not afford to replace it, since I just purchased the vehicle, I took it home and did not try to drive it but by the next morning, less than 24 hours, upon trying to start it, the vehicle would not start at all. The warranty that the vehicle had from the used dealership I purchased from unfortunately has a $500 max payout for repairs. It never overheated the few times I drove it, it only showed a small amount of white smoke out of the exhaust upon starting, but the coolant level has not really going down since putting the coolant in it the morning after I purchased. It currently has a little over 104,000 miles, I've had less than a week, driven it maybe a total of 100 miles, I don't have over $9,000 for a motor

Filed Jul 21, 2026 · Engine · TX

Component Failure: Engine - I am reporting a dangerous engine defect in my 2017 Ford Edge which involves the 2.0L EcoBoost I4 F DOHC 14v engine. My vehicle has experienced total engine failure due to coolant leaking into the engine cylinders. This is a known design flaw documented by Ford in TSB 19-2346, yet no safety recall has been issued for the Edge model. This defect poses a significant safety risk as it can lead to sudden engine stalling, loss of power while driving, and potential engine fires due to overheating. My vehicle started having issues with coolant levels in December 2025, which led to believe that it was the water pump. This was the first indicator that coolant was leaking somewhere. The repair shop replaced the water pump along with the thermostat and heater hose. Later that week the vehicle started stalling and left my daughter stranded. It was able to be jumped and driven to a shop where the battery was replaced thinking that maybe that was the issue. Within 24 hours the engine started backfiring which left my daughter stranded again. The vehicle was towed to the shop and water pump was replaced again under the warranty but the vehicle just kept backfiring and wouldn't start. It was towed to a Ford dealership where they said that it may need a new engine. Ford knew of the coolant engine intrusion issue and pretended that they didn't know what caused the engine failure and the only solution is an $8k new engine. This has caused an impact and financial burden. My vehicle is currently inoperable. I am facing a repair estimate of $8,000 – $10,000 in addition to all the prior repairs leading up to this catastrophic engine failure . My daughter was left stranded twice and other owners are being left stranded as well with dangerous, failing vehicles because Ford has not transitioned this TSB into a formal recall or Customer Satisfaction Program (CSP), despite the clear risk of engine failure at highway speeds. My Ford Case # CXH06505814-Q0P6Z4

Filed Apr 26, 2026 · Fuel system, Transmission · KY

While I was driving my car stopped accelerating on busy [XXX] . It was myself my son his girlfriend who is pregnant and her [XXX] son no indication there was a problem just heard a some kind of noise and it loses speed when try to accelerate it wouldn’t we where able to turn in to a gas station. I then cut the car off and when I tried to restart it the car wouldn’t start a week prior to this a wench did pop up on my dashboard when I looked in the manual it said that I need to take car to get looked at, at earliest convenience but a week. I have only had these vehicle seen December 2023 I paid cash for the vehicle and had warranty that was up to late last year the noise I heard sound like the same noise that when I purchased the vehicle maybe about 3 weeks later they had to fix something with the transmission maybe whatever wrong with it had something to do with that I know if we where on the highway we could have died I have had many cars that had mechanical problems but not none of them ever lost acceleration while driving my car will not start after I cut it off. Unknown what is going on with it just gave the details that happened on [XXX]. Before the malfunction the car started and drove fine until that noise and the car lost acceleration no messages appeared on the dashboard that day. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 26, 2026 · Engine · IN

When I had accelerated to pass a vehicle, the car acted as though it had been flooded with fuel, but then wasn’t getting enough fuel. It was shuttering/shaking and then eventually it completely shut down in the middle of traffic. I was in the left lane. The car would not start. I could not get it out of park to be able to get it off the road, causing a traffic delay and safety hazard to me and other cars on the road. This was during 5 o’clock traffic on a very busy road.

Filed Feb 3, 2026 · Engine · CA

2.0L EcoBoost engine and coolant intrusion. Coolant leaked into two of the cylinder heads, resulting in engine failure and the need for a full engine replacement.Initially, the vehicle would not start. A tow company technician was able to get the vehicle started, after which I was advised to drive directly to my mechanic. I was informed that the exhaust smelled like diesel fuel and that if the engine were shut off, it was highly unlikely to restart. At that point, the check engine light illuminated. The dealership confirmed the coolant instrusion and the need for a new engine.

Filed Jan 15, 2026 · Fuel system · OH

Every time I fill my gas tank up the car acts like it will not turn over and gives me a battery error. I have a brand new battery in my car and key just replaced both December 2025. After turning the car off and waiting then hitting the start button the car will start up then shutter. After going down the road it's fine and doesn't have the issue of not starting.

Filed Nov 6, 2025 · Engine · WI

I have had the high-pressure fuel pump fail on me three times in less than 10,000 miles. This causes the motor to shut down, crank no start and I’ve also had it blow the fuel pump off the top of the motor and dump the oil on the highway on the windshield all over the car, creating a severe crash hazard on these events

Filed Sep 10, 2025 · Engine · KY

Check engine light came on. A friend of mine said she saw smoke from my rear exhaust. Ran codes came back as a misfire. Spark plugs; the cold idle had become a little rough. I was driving home from work 2 1/2 weeks ago and had to stop because a warning came across my screen about hot coolant or engine in red with exclamation marks.My daughters boyfriend came out where I stopped and changed my thermostat because one of the hoses was hot and one not showing it was stuck closed. I asked him to do my spark plugs at a later date. I took the car to Byerly Ford for a coolant flush because I realized I should have used the same coolant. I asked for spark plugs. They couldn't fit it in that day because I scheduled online. He asked if I could leave it overnight. I couldn't. I was then told it may be this bigger known problem if residue under spark plugs come back. He also asked if I had been topping fluid. I told him no. Last Friday night the bf changed my plugs. Residue under # 3. He asked why my coolant looked brown. He opened the cap and saw the coolant was low but good color and the container was stained. I bought the correct coolant. I called Monday morning to see if I could get it in that day. I was sent to voicemail of who is in charge of Engine work.I left a brief message as was requested. I haven't received a call back. Tuesday night (last night) after opening the cap to checking my coolant level and the level rose a bit; my car wouldn't start. I came across TSB#22-2229 which states safety concerns. This includes my cars year, make, model and engine type. I read of a class action lawsuit and recall, but when I look up my vehicles recalls this problem is not listed. I will be calling Byerly shortly to discuss me having my car towed up there for definitive diagnosis. My 2016 Edge has 90016.5 miles. I got new brake pads very recently as well as my the works oil change (no issues)and tires are newish.I have cared for this car with the expectation of twice the milage.

Filed Aug 19, 2025 · Engine · MI

The engine just stopped and the car wouldn't start before this incident it needed a spark plug a sparkplug box two weeks after this being repaired engine light came on and the Ford edge just stopped and had no pressure according to the dealer I purchased the Ford edge from . I payed to have it towed to him and he did not fix it. he said 3,900 for a engine with I only had this edge for 3 months it had 148.700 miles and it's 150. 234miles.and and it's the dealer selling defaced cars there are three complaints on his dealership as far as these cars not being in condition to sell because there are major problems they patch up and major recalls on his . Company selling the vehicle has issues a he bandage the issue and I have a car note and the dealer is not willing to come down on the price to have this repaired I believe it's a defect in the engine and he sold the Ford edge anyway please help me. I'm not able to afford another car I'm [XXX] and a [XXX] I need help plz. And thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)