Ford Edge overheating problems

Filed Nov 5, 2026 · Engine, Fuel system · FL

Vehicle Safety Complaint – 2017 Ford Edge 2.0L EcoBoost VIN: [XXX] the federal safety agency Service Request: XXX I am submitting a formal vehicle safety complaint regarding a 2017 Ford Edge equipped with the 2.0L EcoBoost engine. The vehicle has experienced recurring overheating problems, including at highway speeds. Multiple diagnostic and repair efforts have been undertaken, including replacement of cooling-system components and evaluation by an authorized Ford dealership. The case involves suspected coolant intrusion into the engine, a condition addressed in Ford Technical Service Bulletin 22-2229. I have sought assistance from Ford Motor Company and requested a technical review and goodwill consideration. I am concerned that this condition could cause unexpected engine overheating, loss of engine power, or engine failure while driving, creating a potential safety hazard. I respectfully request that the federal safety agency review this complaint, consider the available Ford diagnostic documentation, and evaluate its relevance to investigation DP26-008. Please assign an ODI Complaint Number and advise whether additional documentation is required. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 5, 2026 · Engine · VA

One October 9, 2026, I took the my 2018 Ford Edge to the dealership (odometer reading 59,414 miles) because the check engine light was on. They performed a service to replace three spark plugs. About one day later, the check engine light came back on. I took the car back to the dealership service (odometer 59,678 mi) for the review on October 27, 2026. I was given a service report stating the engine needs to be replaced per tsb22-2229 coolant leaking into cylinders. At that point, I did some research on the internet and found this is a KNOWN problem for the 2018 Ford Edge with the 2.0L engine due to a flawed engine design. My engine has the potential to catch on fire or stop operating in unsafe conditions. I parked it before either situation could happen because my engine began to overheat.

Filed Nov 4, 2026 · FL

I have had several warnings that my engine coolant is over temperature. Had shut down several time. I have the radiator fluid changed, and have white exhaust smoke, severe engine misfires, and persistent overheating. I am not even driving it right now. My car is definetely a part of the issues that is involved in this : Miller, et al. v. Ford Motor Company is a major consolidated class-action lawsuit centered on a catastrophic engine design defect in Ford’s four-cylinder EcoBoost engines. Absolutely rediculous. Register my car for updates on this lawsuit and engine replacement.

Filed Nov 4, 2026 · Engine · MN

Vehicle was using coolant, engine overheating warning, whole vehicle violently shaking, could not accelerate/loss of power, got diagnosed with coolant intrusion on cylinder 1

Filed Nov 3, 2026 · Engine · WI

While operating the vehicle, it experienced a sudden, unexpected loss of engine power, rough idling, and white smoke emitting from the exhaust due to internal engine failure. The vehicle’s check engine light illuminated, throwing codes P0301 for cylinder misfires, and P0316. A formal diagnostic inspection confirmed that this vehicle is suffering from the known manufacturing defect outlined in Ford Technical Service Bulletin (TSB) 19-2346, which involves internal coolant intrusion into the engine cylinders. The open-deck engine block design allows engine coolant to breach the cylinder head gasket and flood the combustion chambers. This creates an immediate safety hazard on public roadways. The sudden loss of acceleration and severe engine shuddering occurred without warning while driving, exposing the vehicle and its passengers to a high risk of a rear-end collision in active traffic. Ford Motor Company has denied out-of-warranty or goodwill assistance to resolve this defect. This issue directly aligns with the ongoing the federal safety agency investigation into Ford EcoBoost coolant leaks and structural engine failures. I am filing this to request that the agency upgrade its current inquiry into a mandatory safety recall to protect consumers from catastrophic highway engine failure. Current Vehicle Mileage: 85,000 miles

Filed Nov 3, 2026 · Engine · PA

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine experienced sudden loss of power due to internal coolant leak resulting in engine overheating while driving at approximately 55 MPH. This vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? An unexpected loss of propulsion while traveling at highway speeds or navigating traffic creates an obvious safety hazard for the driver, passengers, and other motorists. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. This vehicle's engine problem has been INSPECTED and CONFIRMED by a Ford dealership dealer as well as an independent service center. The Ford dealership confirmed that this issue is related to TSB-22-2229. Additionally, this is A DOCUMENTED AND PREVIOUSLY IDENTIFIED ENGINE PROBLEM by Ford dating back to 12 June 2019. Ford has issued multiple Technical Service Bulletins addressing coolant intrusion into the cylinders of certain 2.0-liter EcoBoost engines. Of particular relevance are: •TSB 19-2172, dated June 12, 2019. •TSB 19-2208, dated June 26, 2019. •TSB 22-2229, dated June 9, 2022. TSB 22-2229 specifically identifies coolant intrusion into the cylinders as a known condition affecting certain 2015–2018 Ford Edge vehicles equipped with the 2.0-liter EcoBoost engine. The bulletin identifies symptoms including low coolant levels, white exhaust smoke, rough engine operation, and associated diagnostic trouble codes. More importantly, Ford's prescribed corrective action for vehicles meeting the specified criteria is replacement of the engine long block assembly. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. There was also a MIL (Malfunction Indicator Lamp) activated at the time of the incident, approximately 7:50 AM on 13 October 2026.

Filed Nov 2, 2026 · Engine, Transmission · MO

Coolant Intrusion and or cracked long engine block When I’m driving my car wants to lose power for example turning in traffic my car acts like it wants to turn off mid turn sometimes do coolant leaking in my engine which I have no control over due to the way my engine was made I have cyclinder 3 misfire. If my car is doing it I’m sure I’m not the only one having this issue on FORD EDGE 2017 make of suv I took it to the shop and ofc they say I need a new engine for something they made why make the engine this way if at some point they will be cracked long block or coolant intrusion, my car losing power could cause an accident

Filed Oct 30, 2026 · Engine · TX

Engine overheating. Coolant leak into the engine.

Filed Oct 29, 2026 · Electrical, Engine · ID

Coolant leak into the cylinders which has caused misfires & overheating. Vehicle no longer starts and has a complete engine failure. not even 75,000 miles have been put on the car.

Filed Oct 23, 2026 · Engine · PA

I am currently dealing with the coolant intrusion into cylinder 2 of the 2.0L EcoBoost engine. In the beginning of XXX at about 134K miles, the check engine light came on. I was at a stop light (.2 miles from my home) and I got a warning message telling me the coolant temp was high and engine power was reduced. When I got home, I saw that the coolant was low, but there has not been any leaks noticed in driveway, refilled and was fine for 2 weeks. During those 2 weeks, I was having a rough idle at start up, and white smoke coming from exhaust. Then on the way to work the engine was overheating. Pulled over and turned off on the side of a highway to let it cool. After 10 minutes, turned the car back on to continue to work (which was a mile away), also turned on the heat to pull from the engine, the air was cold until I started driving then it warmed. I am now having to fill the coolant every few days and having misfires while accelerating causing me to stall and then traffic approaching me having to slow to avoid hitting me. I purchased this vehicle used in XXX from a dealership in [XXX] and the carfax did not state any of these issues at the time of purchase. The only repair given is the TSB 19-2346, and no safety recall has been issued for this defect. This defect poses a safety risk as it can lead to sudden engine stalling, loss of power while driving, and potential engine fires due to overheating. There is a financial burden since this repair is costly and Ford will not help with the cost of this repair. Car warranties are denying claims because Ford as acknowledged this defect. And dealerships are still selling these used cars despite the issues and because it is not a recall, they are not held liable for these repairs or made to disclose the defect. This is a huge safety issue and financial burden. As I am now out of a vehicle THAT FORD NEW WAS A DESIGN DEFECT.