A module is causing communication issues in the car between its and the key fob causing the car not to be able to start at all. It has been at the Ford dealer [XXX] for over a month now and they are unable to remedy the situation. They claim they can’t update the software or can’t find out what’s wrong with the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2020 Ford Escape electrical complaints
Page 3 of 6: complaints 41 to 70 of 160, newest first, as owners wrote them.
My 2020 Ford Escape Hybrid experiences complete electrical failure - battery saving mode followed by total power loss. Ford has published Technical Service Bulletins SSM 49990 (the federal safety agency ID: MC-10199655-0001) and SSM 49574 (the federal safety agency ID: MC-10187983-0001) addressing this exact issue through ABS module programming. However, both my local Ford dealership and Ford Customer Service claim these documented TSBs do not exist in their systems. This appears to be systematic denial of safety-related warranty repairs for a known defect. According to my research, some of Ford owners could receive a 8 year Hybrid component warranty through these TSBs. It seems to be a typical pattern for Ford to avoid warranty procedures by denying TSBs. I have records of the calls. I cannnot upload it from this page
obd communication with emissions and state safety inspection. Ford knows -- will not fix under recall
All kinds of warning lights come in and stay on, which a lot of people are having the same issue which is due to a faulty sensor module.. I almost hit a truck who pulled out of a parking lot once I was on top of him ( was trucks fault) and no warning lights were functioning properly. There's also a recall for a fuel injector issue that ford is taking their sweet time to remedy, but technically I'm driving a time bomb that st any moment this fuel injection issue could crack and leak and cause a fire. And I'm not about to lose my life because of it. I've contacted ford for a lemon law buyback and they are taking their sweet time in that. No warning lights are functioning properly causing a danger for me to drive it. But I have to have a reliable care to get to dr appts and to shop for groceries. Something has got to be done about this. And further more when I purchased this car used I questioned the salesperson at the used car lot about this recall paper that was in the glove compartment about the recall on the fuel injection. He told me it was nothing. Bull!!! Why have that paper in the car if there wasn't a recall for the fuel injection when I bought it back in July 2023. No dealership should have the right to sell any car with a recall already in place. I want to sue the used car dealership for selling me this lemon. The car dealership was key auto of Somersworth nh but now they have a new place in Rochester nh...they should be held accountable for selling me the vehicle with a recall already in place. Ford said recall didn't go into effect till 2025, but why have a document in the car about it when I purchased car in 2023. Makes no sense.
I have a recall been having this problem for months told them what was going on they said nothing was wrong. Months later recall got called for the fuel injector and replacement of high fuel injectors im a single mother. Check engine came on when I gas it..it won't go or goes slowly then takes off into gear
Warning lights coming on and staying on unless I press ok on steering wheel. Warning lights are: pre-collision assist not available, and fault service required, and off, and traction light comes on and stays on.
I am the owner of a 2020 Ford escape. My vehicle falls under the recall dealing with defective fuel injectors. The dealership preformed the suggested service or installing the drain tube and updating the software. I’ve been noticing that my vehicle has a slight hesitation while accelerating in speed and I would periodically smell the strong scent of gasoline, but no check engine or warning lights ever come on. Here recently while driving, my car started slowing down unexpectedly by itself and started idling extremely rough, almost like a tractor and the check engine light came on. I pulled over in the nearest parking lot, turned the car off and looked under the hood but didn’t see anything out of the norm except a small wet spot on the engine cover and there was the slight smell of gasoline. I didn’t think anything of it because I had recently had my oil changed and thought it was probably just a slight spill from there they and refilled the engine oil. I was able to restart my car and everything seemed to have went back to normal. I was able to drive my car to the nearest auto part store where they were able to run a diagnostic scan to see why my check engine light was on. The scan pulled two error codes: the first one being P0302 which is a cylinder 2 misfire, and the second one being P3402 which is a Cylinder 1 Deactivation/Intake Valve Control Circuit Performance. I called ford to see what could be done and they informed me that there was currently no fix for my vehicle. And when asked what i should do the person on the phone told me to “drive the car until it was inoperable”. Which is absolutely crazy to me!
My vehicle had been driving great up till about three or four months ago. It started losing speed, stalling and would not accelerate unless i pressed the pedal to the floor which I had to do in order to avoid an accident. All while this was happening the service light with the 🔧 would comes on, but once I cut the car off and started it up again the next day or after running multiple errands the service light would be gone and my car would drive normal so I thought it was just a fluke and I didn’t worry about it again. Until now!!! Just today my car would not start and at the same time I would also get a warning saying, start the car or cut the engine off as I was trying to start the car so that was crazy. And in order to get it started I had to get the battery jumped, after that it would start right up. But later if I tried starting the car up again it would barley start up without multiple attempts of me pressing the push start, and pressing down hard on the brake pedal and to top it all off my car is losing speed and stalling again.. So because of this I had the battery, terminals, starter, and alternator tested and they said everything is fine so none of that is causing my car not to start up. While trying to find a solution and get a estimate on repairs, I found out my car model has three recalls on it but from what I can see non of these recalls should cause any of these issues. Still I made a appointment to drop it off tomorrow so they can fix the recalls and hopefully figure out what the problem is and fix these other issues. Any who, I thought I should share this just in case others are having these problems and maybe Ford will correct these hazards. Thank you.
Underneath the transmission is a part that once damaged could emit steel into the transmission which causes damage to the transmission. Small pieces of steel. My technician said it happens to all the Ford vehicles mainly the Ford Escape and Ford has not provided a recall for this and it cost $3,500.00 to be replaced. I am disgusted that this damaged part that puts pieces of steel into the transmission could not be noted by Ford as a legitimate recall. Please see what you can do. It's been reported constantly. Thank you
Subject: Safety Complaint – TPMS & Trunk System Failure on 2020 Ford Escape Hybrid I’m reporting two ongoing issues with my 2020 Ford Escape Hybrid that I believe are connected to a recall I’ve seen issued for other vehicles of the same make and model year. 1. Tire Pressure Monitoring System (TPMS): My dashboard only displays pressure readings for two of the four tires. The other two do not register at all, which makes it difficult to monitor tire safety. 2. Trunk Release Button Failure: The button to electronically open my trunk no longer works. I have to manually open the liftgate each time, which is not how the vehicle was designed to function. The last time I took my vehicle in for a recall-related service, I was told I would need to return to complete additional recall work. I never received follow-up communication, and my VIN currently does not show any active recalls, despite these ongoing issues and my earlier service visit. I have since discovered that other 2020 Ford Escape models have been recalled for failures related to the Body Control Module or related systems—which seem directly tied to my problems. I’m requesting a review of my case, as these failures could compromise vehicle safety. I’d also appreciate consideration for repair assistance or further investigation into whether my VIN should be included in the relevant recalls. Thank you for your time and attention.
When it's hot outside, the car will not shift out of park.
When I push the driver window down and when I want to roll it up. The driver window don't go up i have to play with button by pushing it up and down for about 5 to 10 minutes. I have to keep pushing the button up-and-down or turn my car off, open my door it takes a minute for it to go back up. The passenger window goes up and on its on like for example i want to let the window up it comes down by itself. Ford has fixed the driver door panel for the window, but it's doing the same thing. My tire system, it doesn't give me the tire pressure. And when I put gas in my suv, my engine is revving up-and-down, and it cuts off. And when I'm driving, he doesn't want to go I have to push on the gas to make it go. But as far as the window, I have issues with that every single day ever since Ford fixed my suv. And the gas, every time I put gas in My suv make like it wanna shut off, and it do shut off. Sometimes when I put my foot on the gas after pumping gas. This is a ongoing procedure for me. This happens every single day, and every time that I put gas in my suv. This has been going on for about six months or more.
The contact owns a 2020 Ford Escape. The contact stated that the message "Tire Pressure Sensor Fault" was displayed for the rear passenger's side tire; however, the tire air pressure appeared to be normal upon inspection. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 20V635000 (Electrical System, Tires). The failure mileage was 78,000.
4WD module was failing. It affected hill braking, AWD and collision alert and other components. These messages popped up on my driver screen repeatedly. Safety was compromised in winter driving in snow with no AWD. Also, safety impaired with no collision assist available and all the other safety features related to the module . I took it in for repair eventually and dealer confirmed error(s) and replaced the AWD module. I got error messages for at least 2 months before I took it in. The car had less than 30000 miles and was only 4 years old when this started. It was repaired in December 2024.
The contact owns a 2020 Ford Escape. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that several unknown warning lights were illuminated. In addition, the vehicle failed to accelerate above 30 MPH. The vehicle was taken to the dealer where it was diagnosed with a failed high-voltage battery. The contact was informed that the high-voltage battery needed to be replaced. The vehicle was not repaired. The contact stated that the battery was the original high-voltage battery. The manufacturer was made aware of the failure. The contact was advised to contact the federal safety agency Hotline to report the failure. The contact was informed that the repair was not covered under warranty or recall. The failure mileage was approximately 105,000.
1) AWD module failed, 2) The failure of this module resulted in the deactivation of the Advance Track, Hill Start, and pre collison detection systems. 3)Dealer inspected and ran a diagnostics which into the problems listed above. 4)Manufacturer has inspected it. 5)The warnings and systems failure happen when the module failed.
The contact owns a 2020 Ford Escape. The contact stated while driving at approximately 40 MPH, the message "Low Tire Pressure Fault" was displayed. The vehicle was taken to a local dealer, where it was diagnosed that the TPMS sensor needed to be replaced. The contact related the failure to the federal safety agency Campaign Number: 20V635000(Electrical System, Tires); however, the dealer informed the contact that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure and provided the same information. The manufacturer referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 41,000.
May 2025 The following fault codes illuminated on vehicle start up. * AWD FAULT SERVICE REQUIRED * Hill Start Assist Not Available * Service Advance Trac * Pre-collision Assist Not Available. Wrench light illuminated on dash board. AWD and safety features disabled intermittently. OBD Codes: - C0090:18-6C Power Transfer Unit Actuator - Circuit Current Below Threshold - C0095:18-64 Rear Diff Unit Actuator ‘A’ - Circuit Current Below Threshold - C00A2:01-6C Drive-in Control Module Power Transfer Unit Control Circuit Driver. - C00A3:01-6C Driveline Control Module Rear Diff Unit ‘A’ Control Circuit Driver - P0562:00-AF - System Voltage Low on AWD Module. Appears to be AWD module failure.
The contact owns a 2020 Ford Escape. The contact stated that while driving at various speeds, the "All Wheel Drive fault - Service Required", "Hill start not available", and "Pre-Collision assist not available" messages were displayed. The vehicle was taken to a local dealer, where it was diagnosed and determined that an undisclosed module needed to be updated and the battery replaced. The vehicle was repaired out-of-pocket; however, the "All Wheel Drive fault - Service Required" message was displayed again. Upon further investigation, the contact related the failure to an unidentified recall; however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 72,000.
AWD module failed at 20,000 miles
The vehicle has two indicator lamp warnings. One warning for a rear seatbelt monitor fault and one warning for the driver's seatbelt monitor fault. When these seatbelt monitor faults occur the airbags throughout the vehicle are no longer operational. The safety risk of not having operational airbags is extremely high and puts all passengers at risk of serious harm or death. The vehicle is currently at a local Ford dealership undergoing diagnostic testing.
When I go to start up my vehicle it stalls before it turns on. And everytime I put gas in my car it shakes as if it wants to cut off.
The contact owns a 2020 Ford Escape. The contact stated that the engine continued running after turning off the vehicle. The contact stated that upon opening the hood, the engine turned off as needed. The contact stated that the message "Hood ajar - Stop Safely, Close Hood" while the hood was securely closed, and the message “Charging System - Service Now" was displayed. The contact related to the failure to the federal safety agency Campaign Number: 24V954000 (Electrical System). The vehicle was taken to the dealer, where the contact was informed that the VIN was not included in the recall. The dealer diagnosed the vehicle and determined that the failure was related to wires underneath the bumpers. The dealer was in the process of taking the bumpers apart for further diagnostic testing. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included under recall because of the manufacturing plant the vehicle was built. The failure mileage was 74,880.
The contact owns a 2020 Ford Escape. The contact stated that while entering the vehicle, the driver's side door squeaked with an abnormal popping and metallic sound while opening and closing the door. The contact stated that while the vehicle was idling or stopped, the engine made abnormal sounds while the vehicle surged forward, and the vehicle turned off before the contact continued driving. The window failed to lower and raised upwards intermittently. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed that the door had a hairline-sized fracture and needed to be replaced. The door was replaced 3 times under warranty; however, the failure persisted. The manufacturer was informed of the failure and a case was opened. The failure mileage was 26,342.
The contact owns a 2020 Ford Escape. The contact stated the vehicle failed to start as intended. The contact waited for a while to restart the vehicle. The check engine warning light was illuminated. The vehicle was driven to O'Reilly's to be diagnosed. The vehicle was diagnosed with an undisclosed emission code. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 106,000.
First Ford had issues a Customer Satisfaction Program 21B19 was issued to all Ford dealers on April 9, 2021. Then they put out a TSB 23-2061 which my vehicle is part of but says it is not covered under warranty. There are MANY 2020 FORD ESCAPES with this issue. Seems to be just gas vehicles 1.5 and 2.0l engines. My vehicle was not covered along with many other vehicles. Then they even put out a The contact stated while operating the vehicle, the messages "Hill Start Assist Not Available", "Pre-Collision Assist Not Available", "Service Advance-trac" and "Service All Wheel Drive" remained displayed. The vehicle was taken to the local dealer who diagnosed that the All-Wheel Drive module was faulty and needed to be replaced. The vehicle was not yet repaired.
When riding down the road once the car heats up it jerks like it's going to cut off going down the road and you can smell has it has just recently started doing this.
Awd fault. Module needed replaced
The contact owns a 2020 Ford Escape. The contact stated while the vehicle was parked, the contact was locked outside of the vehicle; however, the key fob was within range. On another occasion, the contact attempted to start the vehicle using the key fob and the manufacturer app however, the vehicle stalled. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the battery was dead and needed to be replaced. The VIN was not included in the federal safety agency Campaign Number: 24V954000 (Electrical System). The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 60,470.
Driving down road and came to stop sign and vehicle engine turned off due to start/stop feature and would not turn back on. Received alert battery was going into deep sleep mode. While stuck at stop sign. Had to put in park, turn vehicle off and back on to proceed to move. This is 3rd time see pic of happened Also separate issue the computers sync 3 software will not take and now the screen doesn't work, remote start won't work, gps doesn't work had you drive around in circles.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history