2003 Ford Expedition lights problems

Filed Oct 18, 2020 · Lights · 199,000 miles · CA

Loss of headlights when using auto control, since this is an 03' I believe headlight control unit is bad as this same unit was recalled on my 03' crown victoria

Filed Dec 18, 2019 · Electrical, Lights · GA

Sunroof leaks badly it has fuse box shorting out. When it rains my windows go up down alone. All lights shorted out and nothing working any longer

Filed Aug 29, 2014 · Electrical, Engine · 140,000 miles · AR

I was traveling at 70 MPH on the interstate. The car popped, sputtered and died. Has steadily gotten more and more frequent. Engine dies at idle, dies at slow speeds as well as faster speeds. Very dangerous! Have replaced the PCM, wiring harness, and fuel pump. Is not repaired. Power mirrors readjust themselves when the keyless entry is used. Several warning lights stay on, door ajar, check fuel cap, advatrac will not turn on. Rear window will not work. Back up sensor will not work. Interior lights as well as exterior lighting will not power off when car is turned off. You must manually turn them off or the battery drains.cd player will not eject cd's loud popping sound in the front end and grinding sound when stopping. I have had this in the shop since june of 2014 and they cannot find the problem. Have already spent $1000 trying to repair. This vehicle is dangerous and can very likely cause an accident. It is not safe to drive. Ford auto shop wants to charge me $100 an hour to diagnose the problem then they are not sure if they can find the problem, they are telling me it could cost between $500-$1000 just to find the problem. I have checked several web sites and see that there are many, many people with the same problems with the same type of vehicle. This should be looked into before someone is injured or killed in an accident caused from the car stalling!!!

Filed Dec 7, 2013 · Electrical, Lights · TX

Bulbs melting third brake light assembly internally. This happened to original and recently replaced unit. Bulbs were seized to the plastic mounting and melted/deformed both bulb mounts and reflector. Unit is now defective.

Filed Oct 28, 2010 · Lights · 91,000 miles · KY

Tl*the contact owns a 2003 ford expedition. The contact stated that while driving 70 MPH at night, the headlights suddenly turn off and back without warning. The headlight relay made a noise as well. The failure occurred several times. The contact called the manufacturer who stated that there were no related recalls. The failure mileage was approximately 91,000.

Filed Jan 27, 2009 · Brakes, Lights · 200,000 miles · MA

Brakes need to be replaced constantly. Pads wear very fast. Rotors wear easily and need replacement with pads each time. When brought to have rotors turn, was told they are manufactured with very little tolerance and could not be turned even though there was minimal visible wear. Was told they did not "mic" with enough range to tolerate the cut when turning. Rotors should not need replacement with each brake change. Excessive brake dust. Brake dust has eaten away at finish on rims. After last brake repair, front end now has a clicking sound. Brake pedal has always felt spongy. On two occasions with aggressive braking conditions, brakes locked up. Told dealership who said this is normal with the ford braking systems. Additionally, we have had an ongoing problem with the passenger side fog lamp not staying lit and the metal reflector piece in the fog lamps coming loose. We are now having problems with two (front drivers/rear passengers) door electric locks not unlocking or locking the doors.

Filed Jul 25, 2008 · Body, Electrical · 20,000 miles · TX

First, the door ajar light came on and stayed on. I continued to go around the vehicle opening and shutting the doors and the light remained on. Consumer could not start the vehicle since the light came on, and had to get a jump to start it. After a few days of this the battery was finally ruined, and I was forced to buy a new one. I used lubricants to try and clear debris from the door sensors and this worked for 3 months. Now it will not work at all. Talked to dealer and they want to charge 600 dollars per sensors. Nothing wrong with sensor its just dirty. Second, the rear AC is making a clicking noise and will not control temperature. I sent it under warranty to the dealership and replaced the AC mechanism, stated "this was a common defect with the vehicle". 5 months later this part went out again and it was no longer under warranty and the dealership would not replace the problem and wanted to charge me over 300 dollars. They apparently replaced the defective part with the same defective part and would repair it again 5 months later!!!. Third, the side panels on the expedition exterior started fading at about 20,000 miles. The dealership replaced them under warranty. About 20,000 miles later we noticed they had faded again. We took it to the dealership and they would not replace the defective panels this time because it was know longer under warranty. Even though it was another defect replaced with a defective part. Forth, the rear passenger exterior door/window trim is bubbling and peeling off. This looks horrible! Fifth, the front passenger and font driver window switches that roll down the windows are having issues. I had the motor replaced for the passenger window and it fixed the issue for a little bit. Now the passenger can not roll down the window. However the driver can??? Please help! I need help with any or all of these issues. I don't know where else to go!

Filed Dec 28, 2006 · Electrical, Lights · 20,800 miles · OH

Rear view mirrors fail to return to correct position after backing up causing a driving hazard. This has been an on-going problems since purchasing this vehicle - new in 2003. Dealer has looked at it and stated they could not duplicate the problem and no service bulletins existed as of march 2006. Other intermittent electrical problems exist - 1. Passenger side rear door - automatic lock doesn't always operate. 2. Interior lights stay on as if a door has been left open, even when all doors and hatches have been checked to ensure they are completely closed.

Filed Aug 24, 2005 · Lights · 100 miles · CA

2003 ford expedition headlights are too dim to drive safely. Husband has returned vehicle to ford dealer and had them checked, not long after we bought it new. Service dept says headlights are fine. Both my husband and I feel that it is a safety hazard to drive with the dims on, because we can't see far enough in front of us. The brghts are fine, just the dims seem to be faulty. The headlights were like that when the car was brand new, so it isn't something that started deteriorating with age. Husband thought maybe they were out of adjustment, and had them checked, but was told they were fine. We own a ford econoline van and a ford f-150 pickup and both of the other ford vehicles have much better visibility than our 2003 expedition. Due to mountain driving in a rural area in northern california, we have to be able to see far enough in front of us to avoid hitting animals. The headlights are not bright enough to see far enough in front of us to avoid rocks in the road or even deer. Please investigate this because it is a very serious problem when night driving here. I am adding a number in the field (number of failures) that really isn't accurate because the headlights have been this way since the car was purchased.

Filed Jun 8, 2005 · Body, Lights · 17,493 miles · OH · crash

Dt: the drivers side tie rod has broken twice. Both times was without warning. The dealer has fixed it once and now it is back to the dealer for the second time for same problem. The manufacturer took information from the consumer, but she has not heard back from them. *jb passenger side rear window does not go down from master switch. Door ajar light does not go off. Left front ball joint separated, then vehicle hit sign. Lower control arm broken, upper ball joint bad, spindle broken sway bar link broken, cv boot torn and axle pulled out of front differential. Tie rod end on left side broken and vacuum hub cracked on spindle and tire and rim damaged. Also fender liner ripped out. Spindle, upper control arm, lower control arm, cv boot replaced. Clip for axle vacuum hub and wheel and tire, removed front differential to reinstall, axle and clip replaced wheel and tire and performed alignment. Damage to hood when knuckle split. *tt