2005 Ford Explorer brakes problems

Filed Aug 14, 2018 · Acceleration, Brakes · 130,100 miles · VA

1) ABS, brake, and wrench failure lights flashed on for about 3 seconds and turned off when decelerating with cruise control from 55 MPH to 45 MPH zones at courland, va. Vehicle manual provides no guidance on this failure mode; only 'warning lights turn on and continue flashing, reduce speed and take vehicle to nearest service provider' and 'warning lights turn on and stay on, stop driving immediately and have vehicle towed to nearest service provider.' 2) approximately ten minutes later, driver began applying brakes to disengage cruise control and slow from 60 MPH to 35 MPH school zone speed about 50 to 60 m before school zone warning sign at capron elementary, va, on state highway 58. 3) driver checked speed upon entering school zone and found cruise control light still on and vehicle still traveling at 60 MPH. Depressed brake approximately 1/3 total braking range (4 cm), which should have locked the brakes and brought the vehicle to a full stop. No effect. Cruise control light remained on and vehicle continued at 60 MPH. 4) at this point, driver realized that he had no control of the vehicle, panicked, and decided he had to stop or crash the vehicle. Driver jammed the brake petal as hard as he could and held. It took probably 3 seconds for the rear brakes to finally go up a logistic growth resistance curve, grab, and stop the vehicle. No braking by front wheels. Abs did not work. Contributing physical defects: worn-out front brakes, even though vehicle was kept under rigorous maintenance and had valid virginia state inspection sticker. Warped front brake rotors most likely induced intermittent false signals to computer control center causing cruise control to fail to disengage.

Filed Jul 23, 2018 · Brakes, Engine · NC

Something wrong with the tire pressure the light stays on in the message board and a message with the brake system also stays on and it stalls while im in motion on the hwy and streets and takes awhile to move foward again. I

Filed Apr 26, 2018 · Brakes, Electrical · IL

Abs light and advance tracking light and 4x4 light and car with tracking light all comes on and the braking jerk when stopping. Also low oil pressure light comes on even after oil change

Filed Nov 2, 2016 · Brakes, Engine · 110,000 miles · TX

Vehicle engine while traveling, generally at high rates of speed greater than 40mph, will randomly turn off. There are no warning lights, no indication on the instrument panel. The engine just turns off. The only way of knowing is once the gas pedal is depressed to increase speed and then realized the car had turned off. This is happening more frequently. I had to by a new car. Explorer just sits in the driveway. This happen randomly with no notice and generally while traveling at speeds above 40 MPH

Filed Aug 31, 2016 · Brakes · 116,000 miles · TX

Tl* the contact owns a 2005 ford explorer. The contact stated that while driving, a grinding noise emitted from the front passenger side wheel. The vehicle was taken to an independent mechanic where it was diagnosed that the front passenger side brake caliper failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 116,000.

Filed Feb 24, 2015 · Brakes · MI · crash · 1 injury

I was driving the vehicle at 60 MPH when the car in front of me slammed on their brakes and when I attempted to stop nothing happened and I hit the car in front of me wrecking my truck and bruising myself badly.

Filed May 12, 2014 · Brakes · 76,884 miles · NC

Tl* the contact owns a 2005 ford explorer. The contact stated that while driving 30-55 MPH, the brakes engaged independently. Additionally, the 4x4 high light and the ABS warning light were illuminated after the failure. The vehicle was not taken to a dealer or an independent mechanic. The manufacturer was not made aware of the failure. The failure mileage was 76,884 and the current mileage was 77,459.

Filed Mar 31, 2014 · Brakes, Electrical · 80,000 miles · CA

Because of the recent gm recall ignition issue, I thought I should let someone know about the serious similar issue I had 3 times before I traded my car in. The car would just shut off while driving. And all 3 times, I pulled to the side of the road and restarted the car and continued on my way. I was lucky to have a place to pull over safely. I took it to my mechanic twice, found nothing wrong. Took it to ford and they found nothing wrong. I traded the 2005 for a 2011. I also told the dealer that I traded it into about the engine just shutting off for no reason and to check out the problem before they sold it again.

Filed Jan 13, 2012 · Acceleration, Brakes · 70,000 miles · TX

The gears in the powered brake/gas pedal assembly seem to strip. Then the brake/gas pedal won't change position. That creates a dangerous situation for the driver because the pedals get stuck too far away for some drivers and too close for others. This is a fleet wide issue for all fords with adjustable pedals.

Filed Sep 21, 2011 · Brakes · 52,367 miles · MD

Parking brake shoes broken. Advised during regular service that shoes were broken during earlier service and was advised to wait until rear brakes required service since parking brake is rarely used. During service on 9/21/2011 request repair of parking brake in which the shoes were replaced at cost of $424.19. Inquired as to cause since parking brake is rarely used and was told that could be the reason. Overheard another service rep state that, quote, "explorer's are notorious for that". Currently contacting ford national customer relations to inquire about possible partial reimbursement since problem appears to be wide spread.