The contact owns a 2016 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front driver's side trim fractured and was flapping loosely. The contact used double-sided tape to attempt to hold the windshield trim in place. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000. VIN tool confirms parts not available.
2016 Ford Explorer body complaints
Page 15 of 21: complaints 401 to 430 of 594, newest first, as owners wrote them.
The contact owns a 2016 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts are not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact stated that while operating the vehicle a rattling noise was present coming from the top of the vehicle. Upon inspection it was discovered that the passenger’s side roof rack assembly had become unsecured. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 21V316000 (Structure). The contact stated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 140,000.
On 3/19/24, my left side exterior A-pillar trim part flew off my car on the highway. I have had a constant wind noise in my windshield for a very long time. I didn't think this was going to happen. Thank God there was no cars directly behind me because it came off and was hanging and then blew off before I actually knew what was going on and could pull over. I called the Dealer regarding repair and was informed that there is no fix but they could replace with the part that they have existing in stock which would cost me $366 for the part. Since this is a recall I was asking if I will be reimbursed and the Dealer told me I would need to call Ford. I did and they told me I would need to wait for a parts letter to be sent to me. I explained that I do not want to drive my car around with this piece missing. But they were unable to provide me guidance for reimbursement. I am wondering if you have any information or guidance re: reimbursement for the current parts fix until Ford provides a permanent solution to this recall?
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 40 MPH, there was an abnormal rattling sound coming from the passenger side of the vehicle. The contact stated the front passenger side door handle trim was then separated from the vehicle. The door handle trim was replaced by the owner. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 120,000.
The contact owns a 2016 Ford Explorer. The contact stated that rainwater had leaked into the driver's side B-pillar trim panel causing electrical failures to occur which included the battery failure and the keyless entry failure. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was offered. The failure mileage was 125,000.
The contact owns a 2016 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the rain was entering into the interior of the vehicle. The contact stated that the rain was entering from the left and right sides of the front windshield. The vehicle was taken to the dealer and diagnosed with a fractured windshield trim and the windshield trim needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but confirmed that parts were not yet available. The manufacturer was made aware of the failure. The failure mileage was unknown. VIN tool confirm parts not available.
The contact owns a 2016 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front windshield trim detached and flew off the vehicle. The contact stated that it was the third time that the failure had occurred. The contact stated that the first two times the failure occurred, the repair was paid for out of pocket. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 55,000. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the keypad to unlock the driver-side front door with the passcode detached from the vehicle. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was 58,630. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 65 MPH, the passenger’s side exterior A-pillar trim dislodged from the vehicle and struck another vehicle. The contact stated that the driver's side A-pillar trim was also unsecured and loosened. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet notified. The approximate failure mileage was 91,000.
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 80 MPH, the passenger’s side exterior middle trim panel had dislodged from the vehicle. The cause of the failure was not yet determined. The local dealer was notified of the failure and explained that the failed part was not listed in the federal safety agency Campaign Number: 24V031000 (Structure). The vehicle was not repaired. The manufacturer was not yet contacted. The failure mileage was 30,000.
The roof rack on the left side of the vehicle became unattached in transit, and flew off into traffic.
The contact owns a 2016 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the trim detached and flew off the vehicle. The rear driver's side door applique trim was impacted by the detached trim. The rear driver's side door applique trim was damaged. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 205,040.
The contact owns a 2016 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 65 - 70 MPH, the vehicle emitted a loud bang that came from the passenger’s side of the front windshield. Once the contact was able to park the vehicle, the vehicle was inspected, and the contact became aware that the trim on the passenger’s side of the front windshield had detached. The same failure occurred on the driver’s side of the windshield about a week later while driving at approximately 55 MPH. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact stated while driving 70 MPH, the driver’s side front door panel became loosened due to failed adhesive exposing wiring in the door. The front door lights remained illuminated while the door was closed. The contact stated that the rear door failed to open however, the door ajar light was illuminated. The vehicle was taken to the dealer, and tape was placed on the vehicle however, the failure persisted. The vehicle was taken back to the dealer and the contact was informed that the Keyless entry door panel and actuary for the rear door needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure. The approximate failure mileage was 195,000.
The contact owns a 2016 Ford Explorer. The contact stated that the air bag warning light was illuminated. The contact stated that there was windy sound coming from the front passenger's side door while driving. Additionally, the contact stated that there was water accumulated between the front driver's side door and the body of the vehicle, which caused water to pour inside the vehicle while opening the door. The contact also noticed that water was leaking from the driver's side of the windshield during inclement weather. The contact stated that the vehicle made an abnormal popping sound while making a left turn. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 104,000.
The contact owns a 2016 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the front driver’s and passenger’s side window trims had detached from the vehicle. The vehicle was taken to a local body shop where the trims were replaced. The dealer was contacted. The manufacturer was made aware of the issue. The failure mileage was 70,000. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed MPH, the roof rack rails detached from the vehicle. No warning lights illuminated. The vehicle was taken to the dealer and it was confirmed the entire roof rack rails had detached from the vehicle. The vehicle was previously repaired under the Customer Satisfaction Program recall 21S22. The contact stated the failure persisted. The vehicle was not repaired due to cost. The contact stated the dealer informed him he must pay for the repairs because the vehicle had been previously repaired under the recall program. The manufacturer was made aware of the failure and referred the contact back to the dealer. The failure mileage was approximately 160,000.
Trim piece on passenger side broke in half while driving and hit another car. No damage reported but it almost caused accident. Confirmed this is the recalled piece.
On 1/28/24 We were traveling 50-60 mph when all of a sudden we heard a popping noise and noticed the trim on drivers side was loosening. We were able to slow down and pull over which was when the trim then blew off. My husband retrieved the trim (which we now know is referenced as the a-pillar) off the side of the road. obviously this could have been worse if it had struck another vehicle /caused someone to swerve. I then contacted the ford dealership as we learned this was part of a recall. They came out and ended up fixing the roof rack of which that was not my complaint. Clearly there was a miscommunication on what my problem was when called in. I then took it into dealership for them to observe. He printed out a quote to fix pillar at 400-500$ but could not guarantee reimbursement by Ford. I called Ford motor company who gave me a case number and corresponded with local dealership. Essentially I have been told bc this is an advanced notice recall there is nothing that can be done to fix current situation. I will now be driving my vehicle without the trim and also concerned how long til the passenger side blows off as there was no loosening or sign of defect prior to this event. How will weather affect the exposed trim and windshield/aerodynamics. I just hope Ford will expedite the process of repair for safety first but also the look of the vehicle as this is a reflection of their company . My case number is CA547669778 approx mileage 123,000
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 70 MPH, there was a loud popping sound coming from the driver's side window trim panel detaching from the vehicle. The cause of the failure was not yet determined. The vehicle was not yet repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 112,000.
I reported a problem 1/23/24 concerning the trim blowing off by the front windshield, I saw on the news that this is a recall issue but I also think that the cowling where the wipers are attached should be looked into, this piece is falling apart and when driving the wind gets under the trim pieces causing it to blow off.
I was driving down the interstate and heard a tapping/clicking sound from the right side of my windshield that got progressively worse. Before I could stop at the next exit to examine the cause, I noticed an object falling to the ground in my rearview mirror just as the noise stopped. After exiting and looking at the area where the noise was coming from, I noticed a trim piece missing. I later identified the missing trim piece as the passenger side Windshield Outer A-Pillar Trim Molding. Our 2016 Explorer was purchased new in 2015 and has never been in an accident or suffered any damage that could have caused the trim piece to detach. Since replacing the trim piece, I can hear faint fluttering from the same area. The trim piece appears slightly loose, although I've been told it's as secure as it can get. This happened around a year ago. I didn't think to report it until I read an article earlier about a recall for a loose trim piece on Ford Explorers. My first thought was that it was going to be about the same issue I experienced, but it was for a trim piece on the roof rails. I decided to submit this report in case this has happened to others with similar generations of our Explorer.
We were driving down [XXX] between Houston and San Antonio on [XXX], when we heard a loud noise but felt nothing. When we were ready to leave our destination, the front-driver's side windshield panel was gone. It had blown off going down the road. There was no warning that the panel was loose nor any warning that it was gone. We could have been seriously hurt or killed if the part had come through the windshield. We are thankful that it did not hit and or kill a motorcyclist or cause a wreck where someone else could have been hurt or killed. There is no way to know if a later travelling car received damage due to the part being in the freeway or if it caused a wreck. I am also concerned that the windshield will leak since there is nothing covering the edge of the windshield. My car is available for inspection, but I do not have the panel. I spoke with Mia at Ford Customer Service (800‑392‑3673) on January 22, 2024. There is nothing that Ford is doing at the time to help car owners. Mia said to keep all paper work incase Ford decides to do some repairs in the future. I will get my car fixed but not at Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The cowling where the windshield wipers are attached is falling apart this caused the pillar molding bracket to blow off on I-95 may have struck another vehicle. The ford dealer estimated it would cost $1223.72 to repair.
The windshield Trim panel flew off at highway speed.
The windshield trim on the drivers side and passenger side has come off while driving 70+ mph on the interstate. The drivers side flew off and hit my windshield. A few weeks later the passenger flew off and the car behind me had to swerve to avoid being hit by it. This is dangerous for me as the driver of the vehicle because it could have cracked my windshield while I was driving and it puts the other drivers in danger from flying objects.
Passenger-side A-Pillar Molding Windshield Outer Trim flew off while driving on the highway.
The contact owns a 2016 Ford Explorer. The contact stated that water was accumulating in the rear driver’s side cupholder. In addition, the contact also stated that water was leaking through the rear speakers as well. The vehicle was taken to a dealer where the vehicle was diagnosed with a crack in the driver-side roof rack panel which was repaired out of pocket. The contact was assured by the dealer that water pressure tests were performed on the vehicle which showed that there were no present leaks on the vehicle. Upon return of the vehicle, the contact stated that the passenger’s side of the vehicle had experienced the same failure. The failure was later linked to the federal safety agency Campaign Number: 21V316000 (Structure) however, the VIN was not included in the recall. The manufacturer was notified of the failure and the contact was provided a case number. The contact was also referred to the federal safety agency Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 50,000.
I was driving on the highway and heard a loud noise didn’t know what it was until I got home and realized my windshield trim on passenger side was not on there anymore. It had flown off while driving down the highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history