The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to AutoZone, and it was diagnosed with a failed O2 sensor. The vehicle was taken the dealer where it was diagnosed that coolant had leaked onto the O2 sensor and that the water pumped needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 89,600.
2017 Ford Explorer engine complaints
Page 5 of 11: complaints 101 to 130 of 305, newest first, as owners wrote them.
I was driving on the highway at around 60 mph, I accelerated to pass a car and then the "power" just cut off. The check engine light came on and having my foot on the gas did nothing and the car began to decelerate. Then it started to cycle between kicking in and cutting off for a few seconds, as if it was "catching". Then as I moved over towards the shoulder for safety it resumed normal operation.
My transmission went out at 70k miles. Ford told me it was the engine causing the transmission to seize but since they didn’t have an official recall on it, they wouldn’t fix it. It cost me 5k to fix and they had to get 3 different transmissions from ford because the first two were defective. I was out of a car for 8 months
- Transmission/torque convertor has and is failing. Results in lack of acceleration during launch, sluggish vehicle operation and shudder - Known issue with this make/model/year of vehicle. Failure of the above began at 40,000 some miles and is presently not driveable at only 67,000 miles without an $8-$10,000 repair for a new transmission. - Confirmed with dealer the above issue and is in writing and submitted Case #CAS-47518676-K5Y6Y7 with Ford directly. Located letter sent to dealerships regarding this very issue dated 10/2020. - Vehicle has not been in any accidents, but am receiving a "warning" light indicating failure.
The contact owns a 2017 Ford Explorer. The contact stated that the check engine warning light was illuminated on the instrument panel. The vehicle was initially taken to an independent mechanic to be diagnosed. The contact was informed that the coils and spark plugs were damaged and needed to be replaced. The vehicle was then taken to a dealer where a diagnostic was performed; the diagnostic test showed that coolant had leaked into cylinder #3. The manufacturer was notified of the failure but offered no assistance; the contact was referred to the federal safety agency Hotline to file a complaint. The vehicle was not repaired. The failure mileage was 54,186.
On Friday March 1, 2024 approximately 10:30pm. My SUV caught on fire while parked and off.
The contact owns a 2017 Ford Explorer. The contact stated that the exterior trims on the front passenger's side and the front driver's side windows were detaching. Additionally, the contact stated that while his wife was driving 75 MPH, the vehicle started shuddering and lost motive power. The contact's wife veered to the side of the road. The check engine warning light was illuminated. The contact stated that his wife was able to restart the vehicle and drove to the nearby residence. The vehicle was taken to the dealer, where it was diagnosed that the water pump had failed, and the front engine mount had collapsed. The dealer determined that the water pump needed to be replaced and the front engine mount needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 77,000.
Head gasket failure allowing coolant to leak into cylinder 1. Starts rough, but could result in lost of power or engine failure while driving. Ford dealer has confirmed the issue and said this shouldn't happen to a car with only 77,500 miles on it (2017 Ford Explorer XLT 4WD 2.3L Ecoboost 4 cyl. engine). Have to repair or replace engine depending upon the extend of damage.
Since owning vehicle with around 60k, 2 serpentine belts have been replaced, high pressure hose replaced, water pump is now failing. Looking online, this vehicle has been plagued with issues and no recalls? A failing water pump from 2011 models on? Not sure how a car can have over $10k in problems and no recalls.
The contact owns a 2017 Ford Explorer. The contact stated that the odor of burning oil was present coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the "Power Take Off Unit" was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 76,115.
The water pump is in the engine on this vehicle. You have no clue if it is leaking and it can cause your vehicle's engine to blow. It is also a very very costly repair for a water pump.
Issue with CAM Phasers when looking into the problem I noticed there was a recall for other 3.5 EcoBoost engines on other models but not on a Ford Explorer with the same engine.
Exhaust fumes entering inside vehicle when idling and driving on the road. Must drive with windows open and still cannot drive for over a few miles. Get a headache and effects lungs. Vehicle is now parked and cannot use. Exhaust is leaking near engine. Looks like a cracked manifold. Unsafe to use. Date this occurred is an estimate because I do not know how long this has been a problem. There are other 2017 models with the same issue.
The contact owns a 2017 Ford Explorer. The contact stated while driving 50 MPH, the engine temperature warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the internal water pump needed to be replaced. The vehicle was not repaired. The dealer was contacted, and it was stated that the vehicle was no longer under warranty. The manufacturer was notified of the failure and a case was opened. The failure mileage was 59,800.
Car wouldn't start. All the water had run out due to coolent leak near water pump and in finding it they found leak near front engine mount. These are problems that other 2017 explorer owners have also complained about online. In addition, Kirkland Ford stated they are backed up on repairing the toe link and roof repair due to lack of certified mechanics. The 2017 whole vehicle should have been recalled due to the cheap parts used which has caused me to continually go in to have recalls fixed. While there they end up causing more issues causing me thousands in repair bills. I have scheduled with independent car repair shop for them to give me estimate of repairing the above items for January 10 the first date they had available.
Car dies repeatedly while on the road driving and also while parked. Car has errors on dashboard when attempting to turn on, which I have a video of. First mechanic was able to replicate issue once and got some scan tool codes but he said after that, they all cleared out and he wasn't able to replicate. Car was given back to us, drove to store died and it wouldn't start in parking lot. Mechanic sent tow truck, car started when tow truck arrived. Took car to Ford, tech unable to replicate, car returned to us. Car died once again, which is when I took the error video and took the car back to Ford and showed service rep the video. Ford still unable to figure out the issue. We told Ford to keep the car because it isn't safe to drive until we find and fix the issue. Car has been in mechanic and Ford for about 4 months total.
I experienced the expulsion of coolant underneath the hood of my vehicle in the parking lot / driveways the past month or so. I took this into my mechanic and they diagnosed with water pump failure, need of timing chain assessment and 12 hours of expected labor. This issue has been recalled in Canada, but not here in the U.S. This is a significant amount of money to fix this and a safety issue as this vehicle is often driven in rural areas late at night. If inspection upon request is needed I can make it available.
The car started overheating while on my way home from a trip. I had to get a wrecker to haul it in. Ford offered no help. It was the water pump. Milage at the time was 103,000, Cost to fix $3000. So no Thanksgiving for me this year.
The contact owns a 2017 Ford Explorer. The contact stated while driving 65 MPH, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle was able to restart. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to diagnose the failure. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 144,000.
My 2017 Ford Explorer XLT - eco boost (72,524 miles) vehicle was misfiring (running really rough) at startup the last week or so and the engine light came on and stayed on. The vehicle was serviced in July of this year and there was no mention of the problem. Upon paid inspection today (11/10/23) and diagnosis at my local AAA Car repair service they reported the following: Engine code P0303 - no 3 misfire. The no 3 plug is very clean, which is not good (as it likely means a leak of coolant from head gasket). Upon pulling the number 3 plug, it was confirmed that there was a coolant leak from the Head Gasket. AAA car repair indicated that this was not normal for a car with this low of mileage and shouldn't happen this soon. They said they did not do this type of work and advised I check with Ford corporate to see if there was a recall or extended warranty. I called Ford Corporate, and they did not see any recalls or information that could help with the repair, and they advised I reach out to the federal safety agency to see if there might be other reports or investigations underway and if not, to open one. The vehicle has only been inspected by the AAA Service garage and is now back home in my garage and available for inspection upon request. NOTE: in researching this issue on line, I did find several articles and links of videos with this problem. There are safety issues, especially when pulling out in traffic or accelerating, as the vehicle sputters and does not run smoothly or go as fast as expected and could cause an accident.Â
The contact owns a 2017 Ford Explorer. The contact stated that upon inspection of the vehicle, there was an unknown fluid was underneath the vehicle. The vehicle was examined by an independent mechanic who determined that the water pump was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 95,000.
The contact owns a 2017 Ford Explorer. The contact stated that after moving the vehicle in the driveway, she became aware of a puddle of coolant had formed under the engine compartment. The contact refilled the coolant reservoir and noticed that a puddle had formed. The contact stated later while driving at approximately 35 MPH, the temperature warning light illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed and had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 95,000.
Mechanic confirmed water pump failure. Explorer was brought to mechanic for issue with heater. Upon inspection by mechanic, the coolant was low. Mechanic filled the coolant and left the vehicle idling. Water was seen leaking from undercarriage. Vehicle cannot be safely driven until water pump is replaced. Minimum cost of $2000 to complete repair.
The vehicle loses power at times. When going to another lane or pulling out in traffic, it will surge loosing power. I noticed it shorlty after purchasing it. Ignored it for a long time but have had to drive it more lately and feel unsafe doing so. The vehicle has not been inspected by anyone. It has less than 25,000 miles on itand the problem seems to be getting worse
While driving cross country, driver began to experience lag in acceleration and delayed shifting. In some cases, noted transmission was not down shifting. At destination, the check engine light came on and we took the vehicle into a Ford dealership for repair. It should be noted that there was a low coolant light just prior to the trip and we filled up approximately a quart to bring it back to serviceable limits. The dealer called after several hours to explain the car would need a new 2.3L EcoBoost engine and new Automatic transmission. The engine had evidence of coolant in the engine/oil. The transmission was diagnosed to have a failure of an internal component. The vehicle was been regularly serviced for the 79000 miles with no previous warning lights. We currently have the vehicle in our garage trying to decide if it's worth fixing for $25000 quoted by the dealer.
mechanic noticed water pump leaking at only 61,000 miles and ford refused to help because it was "out of warranty". water pump needed to be replaced which was a 3 day $2300 job. With the amount of people that have had this exact same issue you would think Ford would take action on their equipment. Really starting to regret buying so many Fords.
continuous highway cruise speed shudder in 6th gear between 50 and 60 MPH
The contact owns a 2017 Ford Explorer. The contact stated while driving 20 MPH, the message "Coolant Overheating" was displayed, and the vehicle started to overheat. The contact drove to an independent mechanic, where she was informed that there was no coolant in the vehicle, and that coolant had leaked due to the water pump failure. The mechanic added coolant to the vehicle and referred the contact to the dealer for the repair. The contact drove back to the residence. The vehicle was then taken to the dealer, where the same assessment was made. The dealer informed the contact that the water pump needed to be replaced, and that the failure was a known failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist due to the mileage of the vehicle. The failure mileage was approximately 100,000.
The contact owns a 2017 Ford Explorer. The contact stated that while driving at various speeds, the vehicle was jerking, vibrating, and transmission was slipping. The vehicle was taken to an independent mechanic who diagnosed that the torque arm, engine mount, axle shaft, and catalytic converter were all damaged due to the jerking and vibrations from the vehicle. The vehicle was repaired. The vehicle was later taken to the local dealer who performed service repairs under an unknown Customer Satisfaction Campaign however, the failure persisted. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 46,000.
The contact owns a 2017 Ford Explorer. The contact stated that while parked with the engine idling the message "Engine Too Hot to Operate" was displayed and the engine temperature gauge indicated that the engine had overheated. The vehicle was towed to the local mechanic who diagnosed that the water pump and timing chain were faulty and needed to be replaced. The water pump and timing chain were replaced, and the vehicle was repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 132,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history