Coolant intrusion into the motor causing the motor to overheat Ford recommend new motor but will not take responsibility of the cost. There was a recall on the 2.0 motor but not on the 2.3 and it is the same design of motor. The problem is the way Ford design the motor the new ones after 2017 are designed differently.
2017 Ford Explorer engine complaints
Page 7 of 11: complaints 161 to 190 of 305, newest first, as owners wrote them.
The transmission would slip and/or lag. This started around 65k miles. It was reported to the dealer, they couldn’t reproduce it. Then at 101k miles the engine started vibrating when in gear and idling. Motor mounts were replaced, but the problem persisted. Eventually got the entire transmission replaced.
Water pump leaking
The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, she noticed a bluish-gray cloud of smoke coming from the rear of the vehicle. No warning light was illuminated. The contact was able to maneuver the vehicle off the road. The vehicle was towed to an independent mechanic where it was diagnosed that the turbocharger leaked on the engine and the turbocharger tubes needed to be replaced. The dealer was not notified of the failure. The vehicle was not repaired. The contact referenced the federal safety agency Campaign Number: 16V925000 (Engine and Engine Cooling). The manufacturer was notified of the failure and the contact was advised to call the federal safety agency Hotline for assistance. The failure mileage was approximately 94,000.
Driving on busy interstate at approximately 55mph there was a sudden loss of acceleration ability and check engine light came on, white smoke coming from exhaust. Car was taken to dealership and diagnosed with bank 1 broken turbocharger turbine wheel, and bank 2 turbocharger turbine wheel damaged requiring replacement of both turbocharger turbine wheels, both catalytic converter assemblies, o2 sensors, tailpipe, flex pipe, gaskets. Estimated repair cost greater than $9000. Mechanic at dealership reports this is a very common problem with this vehicle. Vehicle at 88k miles with routine maintenance and no collisions, similar recall for other years of same make and model
The contact owns a 2017 Ford Explorer. The contact stated that on numerous occasions while driving at an undisclosed speed, the check engine warning light intermittently illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant was leaking into cylinder #3, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 96,000.
I own a 2017 Ford Explorer XLT with 2.3L Eco Boost. It was recently diagnosed with coolant leaking into the cylinder. I was told there is nothing that can be done about it other than buying a new engine. Since August 2022, this car has had the "check engine" light on and has been to several different mechanics and 2 different Ford dealers before finally being diagnosed. After researching this issuer, I have learned that Ford has known about this issue since 2010 and chosen to do nothing about it. I have been driving this vehicle around, not knowing that this problem could cause the engine to catch on fire, endangering all the lives of my family! Ford should take responsibility for this issue and replace the engine!
The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was parked, he noticed fluid leaking underneath the vehicle. There was no warning light illuminated. The contact, who is an independent mechanic, diagnosed the vehicle and determined that the water pump needed to be replaced. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 56,000.
The contact owns a 2017 Ford Explorer. The contact stated that carbon monoxide was entering the cabin of the vehicle. The contact stated that there was an abnormally strong exhaust odor inside the vehicle after driving short distances. The contact stated that he felt lightheaded while driving the vehicle. No medical attention was sought. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 180,000.
After purchasing a 2017 Ford Explorer Eco Boost (65K miles) it was only 6 -7 months (yes months) later that I would find myself in a devastating car situation. At exactly 72,000 miles, I discovered my engine would need to be completely replaced. I discovered this after having my vehicle diagnosed at the Ford dealership. Coolant in the #2 and #3 cylinders. The dealership said it would cost $9500 for a new motor. I just bought the car! After searching the internet, I am finding more and more people are having the same problems, and some are prone to engine fire! I have children! There is already law suite against the Ford Company, But I try to do the right thing, I called Ford Motor Company to report my problem. Case No. CAS-39543003-F9S9T0 CRM:040000805. They said they would look into it. My hopes were up. I received a call, They know it is a default in the motor but it has not been recalled yet! Really! So I’m supposed to wait until there is a recall! I was so upset! She did say that they would pay for $4500, but I only have 30 days to let them know if I will take their offer. I told her I don’t have $5 - $6000 sitting around. Ford motors is aware of this issue and has refused to offer assistance in the whole cost. It should be a recall...
The contact owns a 2017 Ford Explorer. The contact stated that after starting the vehicle, the message to "See Owner’s Manual" and the coolant level overheating warning light were illuminated. The vehicle was taken to an independent mechanic, where the contact was made aware that there was a coolant leak and was advised to take the vehicle to a local dealer for further diagnostic testing. The vehicle was not yet taken to a dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the federal safety agency Campaign Number: 16V925000 (Engine and Engine Cooling); and advised the contact to file a complaint with the federal safety agency Hotline. The approximate failure mileage was 100,000.
The contact owns a 2017 Ford Explorer. The contact stated while driving 30 MPH, the vehicle stalled. The contact stated that an unknown warning light was illuminated. The contact inspected under the hood and noticed that the spark plugs were crossed in the engine. The contact took the vehicle to the local dealer, where it was diagnosed with needing the spark plugs to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 101,000.
The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the temperature gauge failed to increase. The contact stated that a message appeared on the instrument panel indicating that the engine power had been reduced to prevent engine failure. The contact stated that after the vehicle was parked, he noticed that coolant was leaking on the ground. The dealer was notified of the failure and informed the contact that the potential cause was due to a faulty water pump. The contact was informed that the water pump needed to be replaced. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was advised to take the vehicle in for diagnostic testing. The failure mileage was approximately 133,000.
The contact owns a 2017 Ford Escape. The contact stated that the vehicle had overheated. The contact took the vehicle to the dealer who diagnosed that the water pump had failed. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 105,000.
No warning lights, took vehicle in for clicking noise - diagnosed ball joint repair. Also Ford dealers tells me my water pump is leaking and repair will cost over $3,500. I have read that this is a common problem and I would like to report it.
The contact owns a 2017 Ford Explorer. The contact stated that the engine overheating warning message would appear on the instrument panel while driving at various speeds. The vehicle was initially taken to an independent mechanic who discovered that the coolant reservoir was empty and linked the failure to a defective water pump. The mechanic then referred her to a dealer for assistance. The dealer was notified of the failure and provided an estimate for a diagnostic test. The manufacturer was also notified of the failure and informed the contact that they might help if a diagnostic test was performed by the dealer. The vehicle was taken back to the independent mechanic where it remained in their possession. The vehicle was not repaired. The failure mileage was approximately 66,000.
I took my Vehicle in because the AC stop blowing cold air, and the overheating lights kept coming on. After waiting for a week, I was told it was a water pump but that did not fixed the AC being at all, couple days later I got a call from the dealership (GRAPEVINE FORD) that the compressor went out. After 3 weeks of waiting, I end up paying out of pocket what is supposed to be covered based of this letter I received from FORD. I feel like I should not have to pay for something that FORD should have covered. Letter below explained the very issues I had with the vehicle, including OVERHEATING and damages like bad cooling relay would cause.
The contact owns a 2017 Ford Explorer. The contact stated that while driving approximately 10 MPH, warning message regarding the engine cooling was displayed before the vehicle stalled. The vehicle was towed to the local dealer who diagnosed that the water pump was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The VIN was not available. The failure mileage was 70,000.
The contact owns a 2017 Ford Explorer. The contact stated while walking up to the vehicle parked in the driveway, she noticed a trail of fluid in the driveway. The dealer was notified of the failure and advised the contact to add water to the radiator and to bring the vehicle in to the dealer to be inspected. The vehicle was taken to the dealer where it was diagnosed that the water pump had leaked and caused coolant to leak into the engine, causing the engine to be damaged. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 69,891.
Carbon monoxide leaking into my car—tailgate area and through the front hvac. Weird sound from engine that sounds and smells like electrical burning or something overheating.
Ford Eco Boost Coolant Intrusion Issues. If the car sits an idles the coolant light will come on an say the coolant is too hotIf I run the air conditioning it will do the say, or drive it on the freeway. There are no leaks, no were. And you can smell the coolant, it smells really hot. My engine line is on.
Transmission is giving out has turned off while driving and sometimes it won't go reverse and Or won't go into gears Machine shows code p0731
Water pump failed and coolant leaked into the engine
The contact owns a 2017 Ford Explorer. The contact stated while driving 40 MPH, the coolant temperature warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the water pump weep hole was leaking, causing the water pump to be damaged. The vehicle was not repaired. The dealer was notified of the failure and advised the contact to take the vehicle in for a diagnostic test. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 81,000.
I have a 2017 Ford Explorer with a 2.3 EcoBoost Four-Cylinder with 59k mileage. Back in November of 2021 My Ford dealership said Coolant is leaking into the Cylinder head causing the car to misfile after a check engine light diagnoses. This causes the car to overheat and can cause major issues. Now i need my entire engine replaced. I have a read that this a know issue in other Ford SUVs in but not in a Ford Explorers, however I have the same engine type. This is a problem for the Ford EcoBoost four-cylinder engines produced since 2010.
Increasing the risk of a crash
car stops an air-conditioned Bell Brooking due to bearing inside a clutch on the AC compressor !! I was on the highway and the car just stops I almost got hit from behind
About a week ago I started smelling coolant after shutting down the engine, took the vehicle to my mechanic and was informed that the water pump is going bad.
The Electrical Water Pump failed. Had to replace the water pump and the Ford Dealer said my car isn't covered under the Customer Satisfaction Program 18L02. Which my vehicle is. Safe Concern is the car will over heat and the engine will cease. The Pump has been confirmed from a independent service center. The water pump has been inspected by my mechanic. When getting an oil change they said my coolant was really low. Went to my mechanic and they stated that the water pump is bad. He also stated that this was his 9th water pump replacement on the 2017 Ford Explorer.
While driving at highway speeds the vehicle lost power due to a main crankshaft bearing failure. The vehicle was repaired at a Ford Dealer and was not under warranty at the time. I was forced to pull off the road due to the loss of power while travelling on a busy highway creating an unsafe emergency situation. There was no warning lights or warnings of any given before the engine failure. It simply lost power and stopped working.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history