2023 Ford Explorer: jerking or lurching

Filed Jun 24, 2026 · Electrical, Engine · AK

Vehicle: 2023 Ford Explorer ST VIN: [XXX] I am reporting ongoing safety-related powertrain and drivability defects that continue despite numerous repair attempts, including complete engine and transmission replacement. Since approximately June 2025, my vehicle has experienced delayed acceleration, hesitation, erratic RPM behavior, harsh shifting, loss of power, and intermittent warning lights. The vehicle has also stalled, jerked during acceleration, and exhibited transmission shuddering and lurching. The problems have been repeatedly reproduced, documented, inspected, and repaired by Kendall Ford of Anchorage, Alaska, the sole servicing Ford dealership involved. Repairs have included replacement of fuel injectors, cylinder heads, a complete engine assembly, and a complete transmission assembly. Despite these repairs, the safety concerns remain. Current symptoms include: • 1-4 second delay in throttle response. • Vehicle may fail to accelerate below approximately 30 mph. • Engine RPM rises significantly without proportional vehicle acceleration. • Erratic shifting, surging, and harsh jolts. • Intermittent check engine lights, FordPass alerts, and electrical warnings. These conditions create a significant safety risk because the vehicle may fail to accelerate when entering the highway, merging into traffic, crossing traffic, making left turns, or avoiding hazards. The delayed throttle response and sudden acceleration after the delay increase the risk of a crash. Attached service records document stalling, misfires, loss of propulsion concerns, and repeated powertrain failures requiring replacement of both the engine and transmission, yet the drivability concerns continue. I believe this may involve a defect in the powertrain, transmission controls, engine management system, electronic throttle control system, or related vehicle control modules. I respectfully request that the federal safety agency investigate these recurring safety-related defects. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C

Filed Jun 12, 2025 · KY

Request for Inspection and Service – Transmission & Water Leak Issues on 2023 Ford Explorer I’m reaching out regarding my 2023 Ford Explorer, as I’ve recently experienced two concerning issues that I’d like to have inspected and resolved: Transmission Behavior: The vehicle has been showing signs of abnormal transmission performance, including -- “hesitation when accelerating,” “jerky gear shifts at low speed,” or “delayed engagement when shifting from park to drive”. These issues are becoming more noticeable and impact the vehicle’s drivability and safety. Water Leak: I've also discovered a water leak, going down second row seat belts and getting water in corner of sunroof itself. I suspect it may be related to sunroof coming to a complete seal when shut via the buttons on vehicle even though it should be sealed, which I've read may be a known problem on this model. The vehicle is still under warranty, the vehicle has less than 36k milese on it, and I would like to schedule an inspection at your earliest convenience. If there are any recalls, service bulletins, or warranty coverages related to these issues, please let me know. I’d also appreciate a diagnostic without incurring fees for problems that may fall under warranty or known concerns. Thank you in advance for your attention to these matters. I look forward to your reply with next steps. Best regards, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 14, 2025 · Driver assistance, Steering · FL

What component or system failed or malfunctioned, and is it available for inspection upon request? The steering system failed completely while the vehicle was in motion. It is currently at the Ford service center in Cocoa, Florida, and is available for inspection upon request. How was your safety or the safety of others put at risk? My wife and our two children (ages [XXX] and [XXX] ) were nearly killed due to this catastrophic steering failure. While traveling at approximately 70 MPH on [XXX] near West Melbourne, Florida (between exits XXX and XXX) in the far right lane, the vehicle suddenly and without warning jerked aggressively to the left, crossing into the center lane, nearly causing a high-speed collision with a semi-truck. The truck driver was able to swerve just in time to avoid an accident. At that point, the vehicle became extremely difficult to steer. It continued to pull to the left, and it required all of my wife's strength to get it off the highway and safely stopped on the shoulder. The safety of multiple drivers on the interstate was compromised due to this failure. Has the problem been reproduced or confirmed by a dealer or independent service center? We are currently awaiting confirmation. The vehicle is in the possession of the Ford service center in Cocoa, Florida, and they are attempting to diagnose the issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle is currently with Ford. We were told they are trying to recreate the issue by driving it in a field behind the dealership, but as of now, they have not taken the vehicle back out on the road or highway for testing. The Florida Highway Patrol was called at the time of the incident, but they did not dispatch a trooper since there was no crash or contact with another vehicle. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No. There were no INFORMATION REDACTED PURSUANT TO THE FREEDOM OF

Filed Apr 18, 2024 · Transmission · 1,200 miles · SC

The contact owns a 2023 Ford Explorer. The contact stated while driving 45 MPH, the transmission slipped and unexpectedly downshifted to first gear, causing the vehicle to jerk. The contact pulled to the side of the road and parked the vehicle. The contact revved the engine, shifted the transmission to drive(D), and drove to the destination. Additionally, on a separate occasion, the vehicle lost motive power while driving. A bystander helped the contact by pushing the vehicle to the side of the road. The vehicle was able to be restarted. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The failure recurred and later the vehicle failed to restart. The vehicle was towed to the dealer, but no diagnostic trouble codes were retrieved. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and a case was opened. The contact was informed that assistance would be provided with the release and substitution of the collateral agreement. The failure mileage was approximately 1,200.

Filed Jan 8, 2024 · Brakes, Steering · TX

There seems to be two issues of concern; 1. Braking system .. when you are in your car, you can hear constant clicking from the engine and the brake light keeps turning and on and off. The light keeps indicating that the brake is on. This happens continuously every day. 2. Steering… when you are switching lanes, it’s not a smooth transition. It feels like a jerk each time and feels like if you were to put the brake, the car will flip over. Very concerning. Happens all the time.

Filed Nov 29, 2023 · Electrical, Engine · CA

Every time i was traveling in sport mode, shifting was delayed & was very rough transition to next gear. Car was not accelerating or decelerating properly. Burning smell came from the engine. Car’s electrical momentarily went haywire. Wrench light came on. This happened within 18 hours of purchasing this NEW car. And several times over the subsequent week. Indicator light went on intermittently & so did same problems described above. My safety was put at risk because my car was not driving properly which caused distraction. I was confused about what to do. It also made it difficult to change lanes or speed up/slow down because it was jerky. The dealership i bought it from said a ford engineer came out to inspect the car & that several parts were ordered to fix it, including a battery for the electric motor & a wiring harness. They said it was a big issue and those parts were hard to come by, but i only learned this after 30+ days of the vehicle being under their control. I only dropped it off for a “test.” They did not make documentation of any of this work and would not release records to me. They also declined to release the car to me when i was tired of the lack of transparency. They said they couldnt give it back j til it was fixed but never provided work order with estimate or details of coverage. I never signed anything giving them permission to replace or repair the parts, especially because they would not disclose the ford engineer’s findings to me until a few weeks later after i threatened to invoke my rights under lemon law. They had already taken the car apart & ordered parts by then-without my informed consent.

Filed Nov 3, 2023 · Engine · MD

Vehicle purchased in May 2023 (51323) at koons silver spring. Vehicle had computer and 'random stalling' issues where the car would not start/stay on in August 2023. Called dealership, vehicle towed to Koons for repair. Service team said they could not replicate issue. Vehicle continued having intermittent issues, vehicle dropped off for repair in sept 2023 - service team repaired main computer system. Oct 3 2023 check engine light came on and vehicle continued random stalling/jarring/jerking forward for amount of time that vehicle had to be driven back to residence (<1.0 miles from time/location when check engine light came on) tech came out to the residence to check the engine system, they identified a misfire but unable to determine why?. as of 11/3/23 vehicle remains at dealership, notified that Ford Safety Engineers (FSE) was notified of the issue, and no solution is available at this time. Can is unusable and is under 9,500 miles. I have not been able to have consistent use of my vehicle and have continued payments as expected. Dealership has no anticipated return date or repair date for my vehicle and this seems to fit the maryland lemon law criteria (car purchased in maryland, resides in maryland).

Filed Jul 17, 2023 · Brakes, Driver assistance · MI

-parking brake is auto engaged 100% of the time at start or while shifting out of park or shifting between gears. Drive or reverse -to disengage the park brake you have to depress the accelerator pedal. -pressure on the accelerator to disengage is inconnsistent every time. -vehicle lurches uncontrollably when releasing the vehicle off the emergency parking brake setting. -the jolt of the vehicle from the depress pressure is so significant and dangerous causing the risk to hitting any parked vehicle while parallel parking or hitting structure/garage when parking, jolting into traffic from a stopped/parked position or to people walking near the vehicle while trying to manipulate the vehicle. -when the auto hold feature is turned on, it can be assumed to be engaged by pressing the brake pedal but if the pedal isn't engaged with enough full pressure the auto hold will not fully activate. In notification when on is in small green text that can be easily missed/confused with the green symbol similar in size to the green auto headlight setting in the same zone. This can cause someone to believe auto hold in engaged when using peripherial vision for the indicator que without directly taking eyes off the forward condition. This gives the driver a false confidence to remove their foot from the brake and have the vehicle creep forward and can lead to accident or injury.

Filed Apr 16, 2023 · Driver assistance, Steering · NC · crash · 3 injuries

I rented a 2023 Ford Explorer. I had many issues with the added safety features while renting it, ultimately resulting in an accident. Firstly, the lane keeping assist did not function properly. In construction zones, back roads, and during rainy weather, the vehicle would jerk very hard to one side of the other. Even after trying to shut off the lane keeping assist feature, it it would automatically turn back on. Luckily, most of those incidents would happen in low traffic areas. Until the final time it happened, resulting in a head on collision with another vehicle. Additionally, the screen that displayed the lane assist activity would go blank randomly while driving. Also. There was a constant issue with the a pop up screen saying to keep holding the steering wheel. Even when I would have both hands on the steering wheel, it would pop up, and sometimes, if it wouldn’t disappear in time, the vehicle would start to automatically brake and slow down the vehicles, even if I was going 70+ miles per hour. The last 12 hours of the vehicle rental drive time, the “keep hold of steering wheel” pop up would pop up more and more frequently. To the point where I would have to constantly let go of the steering wheel and re grab it over and over until it eventually disappear.