2025 Ford Explorer brakes problems

Filed Nov 7, 2026 · Brakes, Electrical · CA

Our first occurrence happened right after we pulled out of a parking space, then proceeded to drive; only to be alerted with numerous warnings, 1. Anti-lock brake fault. 2. Hill start assist warning. 3. Anti-lock brake system fault. 4. Electronic parking brake warning. 5. Pre-collision assist not available. It particularly was a bit scary at first, because we weren't going more than 10mph starting out, and the vehicle abruptly stopped on us, as was the steering became difficult. Luckily, there were not vehicles in front or behind us. The vehicle began to jerk forward and stop hard, if we proceeded, which we could do, limping the SUV, on back streets, only 1/2 mile from dealership. Once at dealership at Ford in Seaside, California, they ran diagnostics, and re-calibrated the faulty module(s), that may have caused this. Fast forward to XXX, while at stop sign in [XXX], we proceeded at slow speed, maybe 10mph or so, and SUV abruptly braked on us and came to complete stop, with warning on instrument display. We pulled over, shutoff vehicle for a minute or so, turned back on and were able to drive again normally. We took a chance, and a few days later, drove vehicle up to the dealership (The Ford Store, Morgan Hill, California) to diagnose. They had it for a few days, and determined the Electronic Brake Booster module needed replaced and whatever they did additionally, like re-calibrations, etc. We're crossing our fingers we don't encounter problem(s). SUV is under warrantly, still, and we did purchase an extended warranty when we purchased it, new, back in XX . We're just praying this doesn't happen if we're driving at a high speed. Never had problems with our three previous Ford Explorers. Of course, these 2025s and newer ones have extensive electronics. Needless to say, my wife is scared this issue might happen again. We can't be the only Ford Explorer or Ford vehicle that might have encountered these issues? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

Filed Oct 20, 2026 · Brakes, Driver assistance · VA

On October 19, 2026, I experienced a serious braking malfunction while driving my 2025 Ford Explorer ST at highway speed. While my foot was on the accelerator, the vehicle unexpectedly began braking repeatedly without me pressing the brake pedal. The vehicle jerked and pulsated as though the ABS was activating. When I attempted to brake, the pedal felt unusually loose and did not immediately respond to the pressure I applied. I eventually managed to slow down and pull onto the highway shoulder. This created a dangerous situation that put me and other motorists at risk. Multiple warnings appeared, including Anti-Lock Brake System Fault, Electronic Parking Brake, Pre-Collision Assist Not Available, and Powertrain Malfunction/Reduced Power. The dashboard also displayed “Park Brake Not Applied,” although I had not activated the parking brake. FordPass reported that the ABS control module was sending invalid information to other vehicle modules and that the electronic parking brake had a fault. This was the second nearly identical incident. On September 29, 2026, I experienced similar unexpected braking and difficulty controlling the brakes. The dealership diagnosed a software glitch and charged approximately $690 for a system reboot and update, which they stated was not covered under warranty. Despite that repair, the dangerous braking malfunction returned less than three weeks later. The vehicle was towed back to the Ford dealership on October 19 and is awaiting further diagnosis. I am concerned about this recurring braking malfunction and the risk of a serious collision. I request that the federal safety agency investigate this potential safety defect.

Filed Oct 15, 2026 · Brakes, Driver assistance · GA · 1 injury

I was driving at approximately 5mph when my car suddenly slammed on breaks. The pre collision warning popped up. There was no obstical in site. Happened approximately 30 mins ago. Had immediate pain in my shoulder, neck and head.

Filed Sep 25, 2026 · Acceleration, Airbags · 27,954 miles · AL · crash · 1 injury

The contact owned a 2025 Ford Explorer. The contact stated that while his wife was making a right turn into a resident carport, the vehicle surged forward and crashed into the house at approximately 10-15 MPH. The brake pedal was depressed during the failure. The contact was following his wife at the time and became aware that the brake pedal was being depressed. The air bags deployed on the driver's and passenger's sides, steering, curtain, and footwell. The driver sustained bruises from the air bag and seat belt. The vehicle was towed. The EMT provided medical attention at the scene. A Police report was filed but the police report number was not available. The manufacturer was contacted by phone and opened a case. The vehicle was inspected and totaled by the insurance company. The failure mileage was approximately 27,954.

Filed Aug 11, 2026 · Airbags, Brakes · 20,000 miles · TX · crash · 1 injury

The contact owns a 2025 Ford Explorer. The contact stated that while driving 50 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The vehicle crashed into the driver's side of another vehicle. The air bags failed to deploy. The vehicle was towed to a local tow yard. The contact was transported to the local medical center for medical attention. The contact sustained bruises and contusions during the crash. The contact sustained a continuous headache after the crash. The contact was receiving continuous medical treatment. A Police report was filed. The vehicle was scheduled for an inspection by the insurance company within days. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 20,000.

Filed Aug 4, 2026 · Brakes · GA

On repeated occasions the vehicle’s braking system has malfunctioned without driver input, including uncommanded automatic brake engagement at highway speed and, most recently, a failure of the braking system to respond as commanded. These malfunctions occur without warning and directly impede my ability to control and safely operate the vehicle. On at least one occasion the malfunction occurred while I was driving on the highway with my three minor children in the vehicle and nearly resulted in a major collision.

Filed Jul 30, 2026 · Brakes, Electrical · TN

On XXX at approximately 4:30pm, while driving through a parking lot (between 5-10mph), I tapped my brakes and then the parking brake activated and caused several errors on my dash, such as the ABS light, a brake failure error, a service Advance-Trac error, and others. The brakes became incredibly stiff and would not work when I pressed them. The car would continue to roll and stop randomly. I was able to pull into a parking spot out of traffic and when attempting to disable to parking brake, it would not work. I had to attempt to disable it, turn off my car, and then turn it back on. After a few seconds, the parking brake audibly unlocked and then my brake pedal became usable again. I called Two Rivers Ford in [XXX] the next day and they advised that they would look at it, but it would be the end of July before they had a service loaner available. I brushed it off as an electrical glitch. On XXX at approximately 7:30pm, my car did the exact same thing again while coming to a stop on a highway. This again occurred around 10mph. I was able to get off the highway and reset the parking brake again by turning the car on and off and was able to begin driving again with no issues. On XXX I called the same dealership again and they were able to provide me with an emergency service loaner same day due to the urgency of the situation. They advised that this had happened to 5 other Explorers in the country prior, the first step is to reset the ABS Module, if that doesn't fix it, they will replace the brake booster. On XXX at approximately 9:45am, while braking prior to turning in an intersection, at approximately 30mph, the same issue occurred again. This time I rolled into the middle of the intersection, because my brakes wouldn't work. On XXX, I called the dealership and they provided me with another service loaner to attempt to replace the brake booster. This is a major safety issue due to loss of brakes. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 15, 2026 · Brakes · WA

Deputy driving the vehicle reported to Fleet of Little to no power brake assist. Fleet found ABS fault codes C0020:64:68 present and sent to the dealer. Dealer is reporting back of possible ABS HCU fault.

Filed Feb 11, 2026 · Brakes, Electrical · DC

I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading to a second, more severe event that nearly resulted in a fatal high-speed collision on February 9, 2026. Incidents Summary: 1. Total Power Loss: Engine and all electrical systems shut down while in motion (40 km/h), losing steering and braking assistance. 2. Brake System Failure: At 70 km/h, The vehicle presented a multi-system failure of sensors, audible alarm and illumination of warning lights (ABS, Traction Control, Pre-collision Assistant, hill start assist not available, check brake system, BRAKE, ESC check, driving modes not available). the vehicle experienced a total loss of brake pedal response followed by a sudden, uncontrolled autonomous "hard braking" event. This happened on a high-traffic highway (Autopista Norte). Global Safety Concern: I am formally requesting a Global Technical Investigation into this unit and the 2025 Explorer Active series. The failure of the electronic brake booster and the total system shutdown represent a "Product Liability" risk that could lead to mass-casualty events. I demand: • Direct intervention from Ford Global to Ford Colombia. • A formal safety alert or recall investigation for similar units. Sincerely, [XXX] MAIL [XXX] bogota colombia phone [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 3, 2026 · Brakes, Driver assistance · NJ

Ever since I bought that vehicle, it's had system malfunctions. I received three letters directly from Ford explaining the problems this vehicle had or could have. But he and the dealerships, where I took my vehicle for repairs, never did them. They always denied that it had any problems and said that my vehicle was new and had nothing wrong with it.