2025 Ford Explorer: ABS light or ABS activating

Filed Oct 20, 2026 · Brakes, Driver assistance · VA

On October 19, 2026, I experienced a serious braking malfunction while driving my 2025 Ford Explorer ST at highway speed. While my foot was on the accelerator, the vehicle unexpectedly began braking repeatedly without me pressing the brake pedal. The vehicle jerked and pulsated as though the ABS was activating. When I attempted to brake, the pedal felt unusually loose and did not immediately respond to the pressure I applied. I eventually managed to slow down and pull onto the highway shoulder. This created a dangerous situation that put me and other motorists at risk. Multiple warnings appeared, including Anti-Lock Brake System Fault, Electronic Parking Brake, Pre-Collision Assist Not Available, and Powertrain Malfunction/Reduced Power. The dashboard also displayed “Park Brake Not Applied,” although I had not activated the parking brake. FordPass reported that the ABS control module was sending invalid information to other vehicle modules and that the electronic parking brake had a fault. This was the second nearly identical incident. On September 29, 2026, I experienced similar unexpected braking and difficulty controlling the brakes. The dealership diagnosed a software glitch and charged approximately $690 for a system reboot and update, which they stated was not covered under warranty. Despite that repair, the dangerous braking malfunction returned less than three weeks later. The vehicle was towed back to the Ford dealership on October 19 and is awaiting further diagnosis. I am concerned about this recurring braking malfunction and the risk of a serious collision. I request that the federal safety agency investigate this potential safety defect.

Filed Jul 30, 2026 · Brakes, Electrical · TN

On XXX at approximately 4:30pm, while driving through a parking lot (between 5-10mph), I tapped my brakes and then the parking brake activated and caused several errors on my dash, such as the ABS light, a brake failure error, a service Advance-Trac error, and others. The brakes became incredibly stiff and would not work when I pressed them. The car would continue to roll and stop randomly. I was able to pull into a parking spot out of traffic and when attempting to disable to parking brake, it would not work. I had to attempt to disable it, turn off my car, and then turn it back on. After a few seconds, the parking brake audibly unlocked and then my brake pedal became usable again. I called Two Rivers Ford in [XXX] the next day and they advised that they would look at it, but it would be the end of July before they had a service loaner available. I brushed it off as an electrical glitch. On XXX at approximately 7:30pm, my car did the exact same thing again while coming to a stop on a highway. This again occurred around 10mph. I was able to get off the highway and reset the parking brake again by turning the car on and off and was able to begin driving again with no issues. On XXX I called the same dealership again and they were able to provide me with an emergency service loaner same day due to the urgency of the situation. They advised that this had happened to 5 other Explorers in the country prior, the first step is to reset the ABS Module, if that doesn't fix it, they will replace the brake booster. On XXX at approximately 9:45am, while braking prior to turning in an intersection, at approximately 30mph, the same issue occurred again. This time I rolled into the middle of the intersection, because my brakes wouldn't work. On XXX, I called the dealership and they provided me with another service loaner to attempt to replace the brake booster. This is a major safety issue due to loss of brakes. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 15, 2026 · Brakes · WA

Deputy driving the vehicle reported to Fleet of Little to no power brake assist. Fleet found ABS fault codes C0020:64:68 present and sent to the dealer. Dealer is reporting back of possible ABS HCU fault.

Filed Feb 11, 2026 · Brakes, Electrical · DC

I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading to a second, more severe event that nearly resulted in a fatal high-speed collision on February 9, 2026. Incidents Summary: 1. Total Power Loss: Engine and all electrical systems shut down while in motion (40 km/h), losing steering and braking assistance. 2. Brake System Failure: At 70 km/h, The vehicle presented a multi-system failure of sensors, audible alarm and illumination of warning lights (ABS, Traction Control, Pre-collision Assistant, hill start assist not available, check brake system, BRAKE, ESC check, driving modes not available). the vehicle experienced a total loss of brake pedal response followed by a sudden, uncontrolled autonomous "hard braking" event. This happened on a high-traffic highway (Autopista Norte). Global Safety Concern: I am formally requesting a Global Technical Investigation into this unit and the 2025 Explorer Active series. The failure of the electronic brake booster and the total system shutdown represent a "Product Liability" risk that could lead to mass-casualty events. I demand: • Direct intervention from Ford Global to Ford Colombia. • A formal safety alert or recall investigation for similar units. Sincerely, [XXX] MAIL [XXX] bogota colombia phone [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 26, 2025 · Transmission · 8,967 miles · GA

The contact owns a 2025 Ford Explorer. The contact stated that while driving at an undisclosed speed through a drive-thru, the Auto Hold feature was activated, but the vehicle failed to respond. No warning light was illuminated. The contact opened the front driver's side door, causing the transmission to inadvertently shift to park (P), and the vehicle turned off. The vehicle failed to restart until a tow truck driver had disconnected and reconnected the battery. The vehicle was taken to the dealer, who updated the software for the SYNC module (APIM), gear shift module, powertrain control module (PCM), and Anti-Lock Brake System (ABS) module, as well as an oil change. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 8,967.