2025 Ford Explorer: false forward collision warnings

Filed Nov 7, 2026 · Brakes, Electrical · CA

Our first occurrence happened right after we pulled out of a parking space, then proceeded to drive; only to be alerted with numerous warnings, 1. Anti-lock brake fault. 2. Hill start assist warning. 3. Anti-lock brake system fault. 4. Electronic parking brake warning. 5. Pre-collision assist not available. It particularly was a bit scary at first, because we weren't going more than 10mph starting out, and the vehicle abruptly stopped on us, as was the steering became difficult. Luckily, there were not vehicles in front or behind us. The vehicle began to jerk forward and stop hard, if we proceeded, which we could do, limping the SUV, on back streets, only 1/2 mile from dealership. Once at dealership at Ford in Seaside, California, they ran diagnostics, and re-calibrated the faulty module(s), that may have caused this. Fast forward to XXX, while at stop sign in [XXX], we proceeded at slow speed, maybe 10mph or so, and SUV abruptly braked on us and came to complete stop, with warning on instrument display. We pulled over, shutoff vehicle for a minute or so, turned back on and were able to drive again normally. We took a chance, and a few days later, drove vehicle up to the dealership (The Ford Store, Morgan Hill, California) to diagnose. They had it for a few days, and determined the Electronic Brake Booster module needed replaced and whatever they did additionally, like re-calibrations, etc. We're crossing our fingers we don't encounter problem(s). SUV is under warrantly, still, and we did purchase an extended warranty when we purchased it, new, back in XX . We're just praying this doesn't happen if we're driving at a high speed. Never had problems with our three previous Ford Explorers. Of course, these 2025s and newer ones have extensive electronics. Needless to say, my wife is scared this issue might happen again. We can't be the only Ford Explorer or Ford vehicle that might have encountered these issues? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

Filed Oct 20, 2026 · Brakes, Driver assistance · VA

On October 19, 2026, I experienced a serious braking malfunction while driving my 2025 Ford Explorer ST at highway speed. While my foot was on the accelerator, the vehicle unexpectedly began braking repeatedly without me pressing the brake pedal. The vehicle jerked and pulsated as though the ABS was activating. When I attempted to brake, the pedal felt unusually loose and did not immediately respond to the pressure I applied. I eventually managed to slow down and pull onto the highway shoulder. This created a dangerous situation that put me and other motorists at risk. Multiple warnings appeared, including Anti-Lock Brake System Fault, Electronic Parking Brake, Pre-Collision Assist Not Available, and Powertrain Malfunction/Reduced Power. The dashboard also displayed “Park Brake Not Applied,” although I had not activated the parking brake. FordPass reported that the ABS control module was sending invalid information to other vehicle modules and that the electronic parking brake had a fault. This was the second nearly identical incident. On September 29, 2026, I experienced similar unexpected braking and difficulty controlling the brakes. The dealership diagnosed a software glitch and charged approximately $690 for a system reboot and update, which they stated was not covered under warranty. Despite that repair, the dangerous braking malfunction returned less than three weeks later. The vehicle was towed back to the Ford dealership on October 19 and is awaiting further diagnosis. I am concerned about this recurring braking malfunction and the risk of a serious collision. I request that the federal safety agency investigate this potential safety defect.

Filed Oct 15, 2026 · Brakes, Driver assistance · GA · 1 injury

I was driving at approximately 5mph when my car suddenly slammed on breaks. The pre collision warning popped up. There was no obstical in site. Happened approximately 30 mins ago. Had immediate pain in my shoulder, neck and head.

Filed Feb 11, 2026 · Brakes, Electrical · DC

I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading to a second, more severe event that nearly resulted in a fatal high-speed collision on February 9, 2026. Incidents Summary: 1. Total Power Loss: Engine and all electrical systems shut down while in motion (40 km/h), losing steering and braking assistance. 2. Brake System Failure: At 70 km/h, The vehicle presented a multi-system failure of sensors, audible alarm and illumination of warning lights (ABS, Traction Control, Pre-collision Assistant, hill start assist not available, check brake system, BRAKE, ESC check, driving modes not available). the vehicle experienced a total loss of brake pedal response followed by a sudden, uncontrolled autonomous "hard braking" event. This happened on a high-traffic highway (Autopista Norte). Global Safety Concern: I am formally requesting a Global Technical Investigation into this unit and the 2025 Explorer Active series. The failure of the electronic brake booster and the total system shutdown represent a "Product Liability" risk that could lead to mass-casualty events. I demand: • Direct intervention from Ford Global to Ford Colombia. • A formal safety alert or recall investigation for similar units. Sincerely, [XXX] MAIL [XXX] bogota colombia phone [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 9, 2026 · Driver assistance · FL

The vehicle failed the inspection related to Recall 25C42. Since owning the vehicle, I have experienced repeated intermittent failures of multiple safety and driver-assistance systems, which raise serious safety concerns. The Pre-Collision Assist system has activated without any apparent reason on four separate occasions, including situations where there were no vehicles, pedestrians, or obstacles present. These unexpected activations are alarming and could increase the risk of a collision. I fear for my safety when driving the vehicle due to these unpredictable safety system activations. Additionally, the Rear Cross Traffic Alert system functions intermittently and does not activate consistently when vehicles are present, further reducing confidence in the vehicle’s safety systems. While driving, the vehicle’s phone connectivity system has disconnected unexpectedly, and during these events the GPS/navigation system became unavailable, preventing the use of turn-by-turn directions. These failures occur while the vehicle is in motion and contribute to driver distraction and safety concerns. The vehicle was inspected for Recall 25C42, and I was informed that the required repair cannot be completed because the replacement part is on backorder until June. As a result, the vehicle continues to be operated with known and unresolved safety-related defects for an extended period of time. These issues occur intermittently and without warning, making them difficult to reproduce or diagnose. Due to the ongoing malfunction of critical safety systems and the delay in recall repairs, I fear for my safety while driving this vehicle.

Filed Jan 20, 2026 · Driver assistance · 11 miles · NY

The contact owns a 2025 Ford Explorer. The contact stated that on the first day after the vehicle was purchased, the pre-collision camera failed to function as intended. The contact stated that the alarm failed to beep as intended when a person or an object was in front of or passing by the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. A diagnostic test was performed, and it was determined that the pre-collision camera worked as designed. The contact stated that the manager at the dealer took the vehicle home and confirmed that the pre-collision camera sensor had failed to function as intended; however, the vehicle was not repaired. The vehicle was taken to Biener Ford; however, no cause for the failure was found. The contact stated that on a separate occasion, while driving at an undisclosed speed in the snow, the message "Pre-collision Camera Blocked" was displayed. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 11.

Filed Oct 22, 2024 · Driver assistance · NY

I am concerned that the Forward Collision Warning and Automatic Emergency Braking are not working sensitive enough to assist in preventing a collision. I had a 2021 Explorer with these features on it and it would give an audible warning at least 8-10 feet if a vehicle was slowing down ahead, this new Explorer does not give an audible warning until about 4 feet near a vehicle slowing down and no braking for at least 3 feet before a collision. I believe anyone in my vehicle are at risk of a collision. I have taken it to the dealer with this concern, it was put on the diagnostic and they found nothing wrong. The sales manager took my vehicle out to verify this problem, following another vehicle that had stopped to make a left turn and if we would have been going any faster we would have hit them, the audible went off and the braking worked at the same time , within 3-4 feet of hitting that car. I drive this car everyday and have never had any kind of warning given to me . I believe the settings are NOT sensitive enough to work properly. I am to the point as to why did I order and pay for these features if I don't get the benefit of them. I have become very fearful for my family with the way these features aren't working as they did on my prior Explorer. I asked the technician at the dealership if they could change the sensitivity and he said no , unless Ford said to do this. I think the warning should be sooner.