2025 Ford Explorer transmission problems

Filed Oct 20, 2026 · Brakes, Driver assistance · VA

On October 19, 2026, I experienced a serious braking malfunction while driving my 2025 Ford Explorer ST at highway speed. While my foot was on the accelerator, the vehicle unexpectedly began braking repeatedly without me pressing the brake pedal. The vehicle jerked and pulsated as though the ABS was activating. When I attempted to brake, the pedal felt unusually loose and did not immediately respond to the pressure I applied. I eventually managed to slow down and pull onto the highway shoulder. This created a dangerous situation that put me and other motorists at risk. Multiple warnings appeared, including Anti-Lock Brake System Fault, Electronic Parking Brake, Pre-Collision Assist Not Available, and Powertrain Malfunction/Reduced Power. The dashboard also displayed “Park Brake Not Applied,” although I had not activated the parking brake. FordPass reported that the ABS control module was sending invalid information to other vehicle modules and that the electronic parking brake had a fault. This was the second nearly identical incident. On September 29, 2026, I experienced similar unexpected braking and difficulty controlling the brakes. The dealership diagnosed a software glitch and charged approximately $690 for a system reboot and update, which they stated was not covered under warranty. Despite that repair, the dangerous braking malfunction returned less than three weeks later. The vehicle was towed back to the Ford dealership on October 19 and is awaiting further diagnosis. I am concerned about this recurring braking malfunction and the risk of a serious collision. I request that the federal safety agency investigate this potential safety defect.

Filed Apr 30, 2026 · Transmission · WA

Hybrid Fault - Service charging system fault displayed. Verified concern. Hooked up IDS and checked for codes. Multiple codes in multiple modules present for engine restart, battery, and low voltage conditions. Hooked up Ford battery tester and performed battery test on both the 12-volt main and auxiliary batteries - main 12-volt battery failed at 70cca. Received warranty code: 11VBE9140L3K and ACES code: HG1HR. Replaced 12-volt main battery and reassembled vehicle. Performed BMS reset, cleared codes, and retest, OK.

Filed Apr 30, 2026 · Transmission · WA

2025 Hybrid PIU/Explorer) for a CEL with PCM codes P0A1E:00:A8 for a starter/generator control module fault.

Filed Apr 30, 2026 · Transmission · WA

Vehicle shut down while driving. Stop safely now, red triangle on IC, and engine disabled. PCM code P1A0C:00:28 Hybrid Powertrain Control Module - Engine Disabled.

Filed Mar 3, 2026 · Acceleration, Transmission · WI

On March 2nd 2026, while operating my 2025 Ford Explorer ST at highway speeds of approximately 78 MPH, the vehicle experienced a sudden, uncommanded shift from Drive into Neutral. This resulted in an immediate and total loss of motive power in live traffic, creating a life-threatening safety hazard as I was unable to maintain speed or accelerate away from surrounding vehicles. Notably, the dashboard displayed no warning lights, wrench icons, or error messages during or after the event. I was forced to coast across lanes of traffic to reach the shoulder. This is the 7th significant warranty-related issue this vehicle has experienced since purchase in May 2025, representing a substantial impairment to the vehicle's safety, use, and market value under Wisconsin Lemon Law.

Filed Jan 2, 2026 · Transmission · MI

Parked vehicle on snowy driveway, went to back to unload personal items from liftgate, and vehicle began sliding backwards towards me. Ran to the driver‘s door, got in, put on brakes, started vehicle and pulled it forward. Put it in park, and as I was exiting the vehicle, it began sliding backwards again. Rear wheels were locked. However, the front wheels were rolling. Apparently the transmission park pawl did not engage. I took pictures of the tires after the last roll. Front tracks show clear tread in the snow (rolling); rear show lines and pushed show (sliding)

Filed Dec 2, 2025 · Fuel system, Steering · FL

I would need to change many more of the points on the top, see report.

Filed Oct 29, 2025 · Transmission · VA

Stopped at traffic light when changed to green pushed on the gas started to roll backwards . Got it stopped and pushed on gas would barely go sounded like transmission slipping. Finally got it thru the stoplight and it started again. Got it home called local dealership took it in and have to take it back Friday morning at 8. Scary!

Filed Oct 14, 2025 · Engine, Transmission · TX

My 2025 Ford Explorer ST-Line is up to date on recalls as of October 7, 2025. However, I am still experiencing engine "shudder" and hesitation at low RPMs (between idle and 1500 RPM) when accelerating. The 10 speed transmission is also continuing to shift harshly at times. I am very concerned that the hesitation and shudder could be an issue when pulling out into traffic. By comparison, my previous 2017 Explorer did not exhibit this behavior, whichh I consider disconcerting. Also, this car (and all 2025 Explorer models ) injects Fake Engine Noise into the audio speakers to make the 2.5L engine sound more powerful. These fake "bass tones" are disturbing to some passengers with hearing aides, and per Ford's website there is no way to disable the fake noise. Thus, some people with a hearing disability cannot ride in my car without removing their hearing aides. It should be unacceptable to not be able to disable that feature. Note updated form dated 8/1/25 states Fake Noise cannot be turned off.

Filed Sep 2, 2025 · Transmission · TX · crash · 1 injury

Automatic Return To Park safety feature failed to stop vehicle from forward rolling causing vehicle to crash into open garage. The drivers door hit side of garage frame, closing onto my left leg causing calf muscle pain and bruising.