Ford Explorer won't start problems

Filed Oct 19, 2026 · Transmission · SC

I was driving to work on XXX. My explorer slipped out of gear while driving. I was a minute from work so I went and parked it. The vehicle wouldn’t shift out of gear or into park. The symptoms seemed to be tied to recall 26S48 / the federal safety agency Recall 26V402 so I had the car towed to a ford dealership. The service guy said it would be diagnosed in 1-2 weeks. It was finally diagnosed 3 weeks later. The service person told me I’d need a new transmission and it would cost 9800 to replace. I asked for the mechanics notes and diagnostic codes. They sent this: “Concerns verified, no crank no start the vehicle is stuck in park setting dtc P07E4. Found ssm 49685 and checked ground G210 and G214. Both grounds are not loose continued normal diagnosis. Completed work shop manual pinpoint test I. Found no issues with PCM or transmission harness wiring. Removed the transmission fluid pan for further testing. Found that the transmission fluid is black in color and is contaminated with metal debris. Found large chunks of steel within the transmission fluid pan. With further inspection found that the park pawl actuator rod has broken and has caused damage to the parking pawl causing the vehicle to hang in park. Dtc P07E4 sets because the vehicle cannot physically shift out of park. This failure has caused fluid contamination and has caused further damage to the transmission. Catastrophic failure is present. Transmission replacement is recommended along with replacing the transmission fluid cooler as fine metal debris may not be able to flushed from the cooler. -- [XXX]” I believe that the park pawl breaking is exactly the recall issue. I called ford corporate and they said they can’t do anything until the final remedy notice letter comes out at the end of this week 10/23 and can’t do any interim repairs until the recall is finalized. I texted the dealership to hold the vehicle until the letter is released. I’ve been out of a vehicle for a little over 3 weeks and frustrated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

Filed Oct 5, 2026 · Electrical, Engine · IN

On approximately 09/02, I took my 2016 Ford Explorer to an authorized Ford dealership for recall-related PCM service. After the recall service was completed, I experienced additional problems with the vehicle and returned on 09/4 and I also called the same dealership that same day because I believed something was wrong following the repair. The dealership replaced the battery but did not perform additional diagnostics unless I paid out of pocket. I was unable to immediately afford those diagnostic charges, so I later sought additional diagnosis. The vehicle continued to experience drivability/electrical problems, including misfire symptoms and eventually a no-start condition. After further testing, another authorized Ford dealership diagnosed the PCM as faulty. I contacted Ford Motor Company because I am concerned that the recall service, programming, or work performed during the recall may have contributed to the PCM failure. Ford closed my case because the recall was marked completed and stated that my vehicle is outside its warranty period. I returned the vehicle two days after servicing dealership as the recall repair to report problems. I am requesting that this be reviewed as a possible recall-repair-related safety issue. The PCM failure and associated engine/electrical problems could affect drivability and the vehicle’s ability to operate safely. The vehicle and related repair records are available for inspection.

Filed Sep 5, 2026 · Engine, Fuel system · TX

I have a loss of fuel pressure and flow from the fuel tank due to fuel pump failure. Sometimes my engine stalls while driving, and when I go to fill my tank with gas, the engine will not start. I have to engage it for about 15 minutes before it will start. My check engine light comes on, and I will get the low fuel indicator light. But more importantly I cannot pass inspection. I need my car, I am a health care professional I have contacted my dealership, a Ford Motor company representative, and the only response and action I get in return is that they are still waiting on the part to come in. It has been over a year. I need this recall to be completed as indicated by Ford Motor corporation and its dealerships, please. My contact information is [XXX], [XXX], my email is [XXX]. My vehicle is the 2022 FORDÂ EXPLORER, VIN:Â [XXX], my Cell number is [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 13, 2026 · Electrical · TN

On XXX, my 2025 Ford Explorer Platinum experienced a complete unexplained no-start failure while approximately six hours from home. The vehicle had less than 1/4 tank of fuel but was not empty and was parked on a slight decline. It remote-started normally and ran for approximately 10 minutes before automatically shutting off. Afterward, it would not restart, repeatedly displayed "Accessory Power Only," and later displayed and audibly announced "System Failure, Contact Dealer." Multiple jump-start attempts failed and the vehicle required towing to Lugoff Ford in [XXX]. Lugoff Ford documented fuel and transmission-related codes and initially advised that the vehicle appeared to need a transmission replacement. That explanation later changed, and the vehicle was returned without an identified cause or repair. I subsequently took the vehicle to Cleveland Ford in [XXX] for a second evaluation. Their repair order specifically states that Ford connected data showed a fuel-pressure code on the day of the failure, but they found no active DTCs and could not duplicate the condition. The vehicle was again returned without diagnosis or repair. I am concerned that an intermittent defect involving the fuel system, transmission controls, electrical system, software, or related components could cause another sudden disabling event. Two Ford dealers have evaluated the vehicle, evidence of the original failure exists, and the underlying cause remains unidentified and unrepaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 18, 2026 · Fuel system · KY

I parked my car and when I returned to it the car would not start. Diagnosed as a faulty fuel pump. Had this problem occurred while I was driving it could have caused serious injury or death. There is an active recall on fuel pumps for the 2021 Ford Explorer that does not apply to my VIN number so Ford will do nothing to remedy the situation and parts are impossible to find as dealers scramble to fix the vehicles included in the recall.

Filed Jul 12, 2026 · Fuel system · WI

I was traveling on an 8 hour drive after just getting a new battery and fresh oil change, I also had a full diagnostic ran the week before travel and no issues were found in my vehicle. When we arrived at our destination we stopped 1 final time and attempted to start our vehicle to go to dinner and the car would not turn over. There were not any warning lamps or messages that appeared. We used roadside assistance to tow it to the [XXX] dealership and they ran another full diagnostic that showed "replace fuel pump and fuel pump driver". When I called my local dealer back home, Evansville Ford ([XXX]) they pulled the previous week diagnostic and confirmed nothing showed up regarding the fuel pump at that time. 1 week later is when we had it in [XXX], and the fuel pump failed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 10, 2026 · Fuel system · OH

Fuel pump and module failure. Driving on the highway at 70 miles an hour and the fuel pump failed. Causing me to have zero acceleration. Thus losing speed rapidly in the center lane. No warning lights were present before or after. One previous symptom of a crank no start. Dealership was able to replicate the crank no start situation. Resulting in the problem being a fuel pump failure and module needing replaced, at 83,000 miles on the vehicle. Though I know normal wear and tear can and does happen, there was no warning. And losing engine power at high speeds on a highway is unsafe.

Filed Jun 16, 2026 · Electrical, Engine · CA

Description On your vehicle, it may be possible that one or more engine camshaft roller finger followers were not properly installed at the time of engine assembly. Safety Risk An improperly installed engine camshaft roller finger follower may result in engine failure, resulting in a no-start condition or a loss of motive power. A loss of motive power increases the risk of a crash. Your vehicle may also experience engine ticking or tapping noise, and or a low-volume oil leak due to this condition. Remedy A remedy is not yet available. Ford Motor Company is working to provide parts for this repair. When the remedy becomes available, Ford Motor Company will notify you via mail to schedule a service appointment with your dealer for repairs to be completed free of charge. The remedy is anticipated to be available 4TH quarter of 2026. Next Steps Contact your dealer for more information to schedule the free service.

Filed Jun 15, 2026 · Engine · OH

While stopped at a stop sign my engine suddenly died, before restarting a low oil pressure light came on but went out immediately. I was approximately 40 miles from home when I got to my destination. The car was showing no signs of issues, no warning lights or errors. When I went back out to start it and head home it would not start. I had to pay additional expense beyond my insurance road side coverage due to the distance. I have had an independent mechanic going over the vehicle since it died. Starter has been replaced because it appeared to be the issue. (the original was bad) Once replaced while attempting to start it he found out the engine had locked up. I bought the vehicle March 30, 2026 & this happened on June 10, 2026. The vehicle had 132,344 miles on it when bought and 135,716 when it seized up. After looking through other reports I have found this to be a reported issue.

Filed Jun 9, 2026 · Engine · OK

Car was running fine then went to start and received warning about car being too hot. Checked coolant and it was low. Refilled and drove home. Upon arriving engine light came on. PO301 code. There was coolant intrusion into the cylinders, leading to engine failure. Rough idle when starting. Did not drive after this. Went to start and car will not start at all. Symptoms include: Coolant loss with no visible leaks White exhaust smoke Rough idle or misfires P0300 / P0301 / P0302 codes Hydro-locked or destroyed engines