2015 Ford F-150 airbags problems

Filed Sep 4, 2026 · Airbags, Electrical · CA

This is a supplemental complaint to my earlier report regarding the federal safety agency Campaign 26V237 / Ford Safety Recall 26S28. The recall remedy (PCM software update) was performed at W.C. Sanderson Ford in Healdsburg, CA on XXX. The original downshift defect recurred within weeks, including a near-miss where I nearly lost control of the vehicle with my [XXX] son inside. Since then, I have had the vehicle independently scanned twice, including a full all-systems diagnostic scan. The scan shows a communication fault (U0401, "Invalid Data Received From PCM") present across five separate control modules: ABS, Airbag/Occupant Classification System, Power Steering Control Module, Tire Pressure Monitoring/Body Control, and the engine module. The scan's own assessment recommends repairing CAN-BUS wiring and connections. I believe this network-wide wiring fault may be the actual underlying cause of the condition recall 26S28 was intended to fix — the recall's software update assumes a signal-loss problem can be resolved in software, but if the root cause is physical wiring, the remedy would not correct it. This would explain why the defect recurred so soon after the software update was installed. A second code, P2112 (Throttle Actuator Stuck Closed), also appeared spontaneously while the vehicle was parked. This code is documented in Ford's own Technical Service Bulletin 16-0139 (issued 2018), indicating Ford had prior knowledge of related fault patterns on this vehicle range. Of particular concern, the Airbag/Occupant Classification System is affected by the same communication fault. This system governs airbag deployment behavior based on occupant detection, and my son rides in this vehicle regularly. The vehicle is currently not safe to drive. I am requesting the federal safety agency evaluate whether the 26S28 remedy adequately addresses the underlying defect, given evidence that a wiring-level fault — not solely a software issue — may be the true root cause. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)

Filed Jul 19, 2026 · Acceleration, Airbags · IA

The clock spring in the steering has failed causing the airbag to no longer work on the driver side. The cruise control turns on and shuts off on its own. Sometimes won’t even let you set it. Volume controls no longer work. Horn no longer works. Steering has a clicking catching sound now when turning. Steering controls no longer light up and none of the buttons work.

Filed Aug 29, 2025 · Airbags, Electrical · NC

This is the 2nd time this has happened in 2 years. I have my truck turned off completely and locked and go to get back in it a few hours later and I open my door and the gas from the airbag has completely filled up the cab of my 2015 f150. I turn the truck on and it’s like it’s been in a wreck, all the lights on the dash are on, and it’s saying my airbags are deployed which the gas that fills the airbag did deploy, and it keeps telling me to contact 911. How does this keep happening without ford making a recall or not taking responsibility. It could seriously hurt or I hurt me or my family.

Filed Jul 10, 2024 · Airbags, Seat belts · 191,845 miles · IL

The contact owns a 2015 Ford F-150. The contact stated that while his son was driving at an undisclosed speed, white smoke was coming from the base of the driver's seat belt clip. The contact stated that the air bags warning light illuminated with a message that the driver's side door was opened; however, the door was not open. The contact's son was able to safely pull the vehicle to the side of the road and the vehicle was towed back to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the local dealer. The contact related the failure with an unknown recall; however, the manufacturer confirmed that the vehicle was not included in the recall. The contact was referred to the federal safety agency Hotline for assistance. The failure mileage was approximately 191,845.

Filed Oct 1, 2023 · Airbags, Steering · PA

The airbag cover on the steering wheel is separating/cracking along the mould lines and near the emblem.

Filed Sep 10, 2023 · Airbags · FL · crash · 1 injury

On September 13, 2020, my father was driving his 2015 Ford F150, with me in the passenger seat. We were hit in a high speed head-on collision on I-55/I-240 in Memphis, TN by an oncoming driver, which killed both my father (the driver), and the oncoming vehicle driver, and I was taken to the hospital with injuries in critical condition. My father was extracted from the vehicle and taken to the morgue, but when I was able to return to the truck at the impound lot, I found no drivers side airbag in the truck. While EMTs informed me that the airbag was cut, it was odd that the airbag was not still in the truck. His cause of death was blunt force trauma, and if the airbag did deploy, it would have had to have been a part of the immediate fatality. If it did not deploy, it would also have been a factor. On the passenger side, where I had been, all airbags were still attached, but cut in order to extract me. In the days immediately following the accident, my lip was swollen from hitting the airbag, but there was also a piece of shrapnel lodged in my lip, confirmed by XRay, which later came out. I am concerned about both my father's fatality, and how the airbag deployed and what role it played in the fatality, as well as the injury of shrapnel getting embedded in my lip. I believe that the airbag could be a contributing factor in both issues.

Filed Aug 22, 2023 · Airbags, Brakes · 130,000 miles · MI · crash

The contact owns a 2015 Ford F-150. The contact stated that while driving approximately 45 MPH the braking system had malfunctioned and while pressing the brake pedal the vehicle did not stop causing the driver to lose control of the vehicle and crash into a ditch. The front end of the vehicle was damaged, but the air bags did not deploy. The driver sustained a right leg injury which did not require medical attention. The front passenger sustained a right knee injury and the rear driver's side passenger sustained and left shoulder injury, both required medical treatment. A police report was taken at the scene and the vehicle was able to be driven home. The cause of the failure was not determined. The manufacturer was notified of the failures. The local dealer was not contacted. The failure mileage was 130,000.

Filed Mar 7, 2023 · Airbags, Electrical · SC

My airbags deployed while my truck was parked overnight. No known cause, no collision. Also when I put the keys in the truck all my dash lights were on no power steering. The truck is currently sitting at the dealership.

Filed Sep 30, 2022 · Airbags · 85,000 miles · MI

The contact owns a 2015 Ford F-150. The contact stated that soon after starting the vehicle, the passenger’s side curtain air bag deployed independently. No warning lights were illuminated. The vehicle was then towed to a local dealer where the contact was informed that the air bag failure was related to corrosion located around the front passenger’s side kick pad area. Additionally, the contact was informed that the passenger’s side curtain air bag and the engine wiring harness and body harness needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and a case opened. The approximate failure mileage was 85,000.

Filed Sep 30, 2022 · Airbags · MI

I started the the truck and the right siside airbags deployed