The contact owns a 2019 Ford F-150. The contact initially stated that upon checking the oil level, the oil level was a quart lower. The contact then stated that while driving up a hill at a moderate rate of speed, an abnormal knocking sound began to emit from the vehicle as the vehicle started to lose power. The vehicle was taken to the dealer where the mechanic reprogrammed the Powertrain Control Module (PCM) software and changed the oil. The contact was then instructed to bring the vehicle back every 1,000 miles to monitor the oil consumption. The manufacturer was also notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The vehicle was not repaired. The failure mileage was 23,504.
2019 Ford F-150 engine complaints
Page 10 of 14: complaints 251 to 280 of 379, newest first, as owners wrote them.
The contact owns a 2019 Ford F-150. The contact stated while driving 40 MPH, the contact heard an abnormal rattling sound coming from the engine compartment, after which the vehicle lost motive power. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the cam phasers, resulting in damage to the engine and requiring the engine to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 139,000.
The contact owns a 2019 Ford F-150. The contact stated that upon starting the vehicle, he briefly heard an abnormal rattling sound emanating from the engine compartment. The contact stated that while driving at an undisclosed speed, he also heard a ticking sound emanating from the engine compartment. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N03. The manufacturer was notified of the failure but referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 69,000.
Tapping noise on cold start and then loss of power triggered P052D-00 code "Cold start camshaft position timing over0retarted bank 2"
The variable camshaft timing (VCT) solenoid becomes gummed up, causing the engine to lag. Specifically after driving on the interstate or highway and then sitting at a red light. The VCT does not perform properly and the engine idle drops, causing the truck to stall and die at the light. Online forums show this to be a common problem for the past couple generations of this Ford 5.0 L motor and always seems to occur between 80,000 and 100,000 miles.
The contact owns a 2019 Ford F-150. The contact stated that at vehicle start-up, there was an abnormal rattling sound coming from the engine. There was no warning light illuminated. The vehicle was taken to an independent mechanic where a diagnostic test determined that the cam phasers were defective and needed to be replaced. The dealer was notified of the failure and an appointment was scheduled. The manufacturer was also notified of the failure and a case was filed and the contact was referred to the federal safety agency Hotline. The vehicle was not repaired. The failure mileage was 67,562.
The contact owns a 2019 Ford F-150. The contact stated that during cold starts, there was a loud knocking sound coming from under the hood of the vehicle. The vehicle was taken to the local dealer who diagnosed that the engine cam phasers were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 135,000.
Unknown Cam position sensor throwing code p0345. Replaced part week later came back. Alternator battery and starter tested fine. Started rattling week later
An intermenttent loss of the transmission output speed sensor signal to the powertrain control module resulting in a unattended downshift into first gear when accelerating.
The contact owns a 2019 Ford F-150. The contact stated while driving 35 MPH, the check engine warning light illuminated, prompting the contact to pull over to the shoulder of the roadway. The contact became aware that the vehicle was idling rough. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the cam phasers. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N03(Cam phaser replacement), but the VIN was not included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 105,000.
Ford has done a service bulletin on the cam phasers once before. The issues are still not fixed and all they say is it's normal. An engine rattling due to a part they installed is not considered normal. Wrong parts were used and the problem still persists. Ford needs to be made to recall 2015 to 2019 f150 trucks as well as any other series that have the issue. The service bulletin only gave people a certain amount of time to come in and have it fixed the first time which left a lot of people out of luck due to lack of communication to the owners of said vehicles.
12/26/2023 Re: VIN: Case#:[XXX] I purchased this truck new 4/1/2019 and purchased a Ford Extended warranty(Ford Protect) the following month for 5 years/125K miles. This was my second F150 with the 3.5 ecoboost engine. Since that time it has been serviced continuously by Ford Dealerships . At no time during that time period under warranty has any Ford dealership mentioned that there were service bulletins out to the dealerships with regard to failing Cam phasers. From research that I have done over the weekend there is apparently a New type phaser being used on F150’s since 2021 that corrects the problem. If Ford and all of the Ford dealerships knew of this common problem why were not the Ford customers notified of the issue? I went in for an oil change last week and the technician noted a tiny sound when the engine started. I went back the following week to have a sensor replaced and the mechanics indicated that there was a camshaft/phaser problem that would cost $4200 to fix. That issue could have been fixed at any time under the extended warranty from 2021-2022 if the dealerships had notified the Ford customer by using the same phasers installed on new trucks. I received a follow up call from a Ford rep 12/28/2023 who denied that I had a Ford Protect extended warranty. I verified the policy 12/29/2023 and called Ford again who again stated that I did not have a Ford Protect Policy. Finally it took a conference call with the dealer to convince Ford who still would not agree to fix the issue. The Dealer offered to extend the policy until realizing that it had been diagnosed with a cam phaser failure stating they could not warrant an existing issue. That is exactly what the dealer did in 2019 when they sold the extended warranty on a known issue. Phasers are the critical feature that controls the timing and computer controlled oxygen input and exhaust for ecoboost engines. When they start to break down it affects the health of the engine itself. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATI
12/26/2023 Re: VIN: Case#: I purchased this truck new 4/1/2019 and purchased a Ford Extended warranty(Ford Protect) the following month for 5 years/125K miles. This was my second F150 with the 3.5 ecoboost engine. Since that time it has been serviced continuously by Ford Dealerships . At no time during that time period under warranty has any Ford dealership mentioned that there were service bulletins out to the dealerships with regard to failing Cam phasers. From research that I have done over the weekend there is apparently a New type phaser being used on F150’s since 2021 that corrects the problem. If Ford and all of the Ford dealerships knew of this common problem why were not the Ford customers notified of the issue? I went in for an oil change last week and the technician noted a tiny sound when the engine started. I went back the following week to have a sensor replaced and the mechanics indicated that there was a camshaft/phaser problem that would cost $4200 to fix. That issue could have been fixed at any time under the extended warranty from 2021-2022 if the dealerships had notified the Ford customer by using the same phasers installed on new trucks. I received a follow up call from a Ford rep 12/28/2023 who denied that I had a Ford Protect extended warranty. I verified the policy 12/29/2023 and called Ford again who again stated that I did not have a Ford Protect Policy. Finally it took a conference call with the dealer to convince Ford who still would not agree to fix the issue. The Dealer offered to extend the policy until realizing that it had been diagnosed with a cam phaser failure stating they could not warrant an existing issue. That is exactly what the dealer did in 2019 when they sold the extended warranty on a known issue. Phasers are the critical feature that controls the timing and computer controlled oxygen input and exhaust for ecoboost engines. When they start to break down it affects the health of the engine itself.
The contact owns a 2019 Ford F-150. The contact stated that while starting the vehicle, there was a rattling and knocking sound coming from the vehicle. The contact stated that engine cam phaser started but was not fired up and the contact was able to drive the vehicle. No warning light was illuminated. The vehicle was not diagnosed. The manufacturer was made aware of the failure. The failure mileage was approximately 65,000.
Transmission jerks, and stalls. Drive train noise. Engine cuts out and has rough idle.
The vehicle has given codes P0018 and P0021 on multiple occasions. These codes are likely due to an issue with the cam phasers. This is a known issue due to a design flaw.
I drive a 2019 Ford F-150 XLT 4WD (8 Cylinders 5 5.0L FI FFV DOHC 302 CID). During November 2023, I was experiencing the truck bucking and jerking and shutting off at red lights and stop signs. I took my truck to the dealership on November 22 to have them look at it. They replaced the starter, an almost dead battery, and a PDM reset. The PDM reset and starter were covered under my extended warranty. Upon driving my truck home, the problem continued to exist and this time much worse. I returned to the same dealership on Friday, November 24, 2023. After a diagnostic test, they found nothing, then stated a couple of people drove the vehicle and could not duplicate the problem I was complaining about which was stressful and frustrating because this problem exists almost every time I drive the vehicle, regardless of how long my trip. Driving this truck has now become a safety hazard as I almost got struck by other vehicles on more than one occasion. When I pull out from a traffic light or any business establishment, I have to keep tapping the gas peddle to get the truck moving and it doesn't move, leaving me stranded in the intersection. When the truck does move, it jerks so hard that it gives you "whiplash". This jerking motion continues during the duration of my trip, including my hour-long drive both to and from work. I took my Ford to another mechanic on December 19, 2023. The establishment sent one of their technicians to ride along with me to experience the problem for himself. I drove out of the driveway for just a few feet when again, I kept tapping the gas pedal to get the truck to move and when it did, the truck jerked violently. The technician saw what he wanted to see. I get no warning lights or messages about the failure. The technician said it was a transmission problem that he has been seeing with the years of 2017-2019 F-150 and Ford is aware of the problem but does nothing about it.
Approximately 2 weeks after purchasing the truck I noticed some harsh shifting, jerking, and sudden acceleration, and hesitation issues. They were intermittent and I was advised this is not uncommon with this model vehicle. However, these issues have become more frequent and severe. Next, I noticed the gears began slipping and the truck seemed to not be able to “find” the gear it needed to be in. The transmission would slam into gear or begin slipping under acceleration. There is no rhyme or reason to it, I have not been able to pinpoint it to a specific gear or up/down shift. It simply loses power and neither the gas nor brake work. It will coast until the wrench (check engine?) symbol comes on and then the gas will function. This week the transmission has started intermittently locking into a specific gear without the ability to shift. It’s now happened 3 times. You cannot reverse or drive, the transmission puts itself in park while the dash still indicates its in drive or reverse. After parking the truck for a couple of hours, I could start and drive as usual. Most importantly, twice Saturday the truck seemed to shift out of gear, so hard my head hit the steering wheel, and lost power going 70mph on I64. I have attempted to video these events to help diagnose the issues, but obviously driving and recording are dangerous and difficult.
The contact owns a 2019 Ford F-150. The contact stated that the vehicle experienced excessive oil consumption and approximately two quarts of oil was added to the engine each month to maintain to top off the oil level. Additionally, while operating the vehicle in 4WD, the vehicle jerked and hesitated. The cause of the failures was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 5,000.
The contact owns a 2019 Ford F-150. The contact stated while driving at an undisclosed speed and attempting to accelerate, the vehicle shifted abnormally, jerking, and hesitating to shift into gear. Upon pulling to the shoulder of the roadway, the contact was able to continue driving after activating manual drive mode. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a general transmission failure. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 77,000.
The contact owns a 2019 Ford F-150. The contact stated while driving approximately 65 MPH, the check engine warning light was illuminated. The contact stated that there was an abnormal rattling sound while depressing the accelerator pedal. The vehicle was driven to the dealer however, the failure was not duplicated. The contact stated that there was an abnormal sound that was intermittent but became a constant failure. The contact drove the vehicle back to the same dealer who determined that the engine needed to be replaced. The vehicle was not repaired. The contact was advised by the dealer that the engine was on a national backorder. The manufacturer was informed of the failure. The failure mileage was 85,451.
Truck uses an excessive amount of oil that would not be corrected by Ford. Due to this issue the truck failed to operate normally. It stalled in the middle of an incredibly busy intersection, causing traffic back up as well as increase safety concern for the drive of the truck as well as other drivers on the road. This has happened multiple times. Ford is aware of the engine oil consumption issue. Has expressed multiple times that it was not a problem. Attempted to fix by selling a new longer dip stick to attempt to hide the problem with excessive oil consumption.
The contact owns a 2019 Ford F-150. The contact stated he heard an unusual rattling noise that came from the engine compartment when he started the vehicle. The contact stated the rattling noise had gotten worse over the past year. The contact stated he contacted the dealer by phone and was informed that the vehicle was not associated with any recalls. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to report the failure to the federal safety agency. The failure mileage was approximately 35,000.
Vehicle engine, cooling, and exhaust. Cam Phasers noise when starting
My engine light came on and within the same day my vehicle shifted extremely slow. it was difficult to merge into traffic and almost caused an accident. I took the vehicle to Mechanic and they advised the engine light was consistent with the timing chain failure . I called a local local Ford dealer. They seem to be familiar with the issue and said it would cost $4000 to fix.
10 speed transmission loses power when passing other vehicles, shifts very hard between speeds, loud banging from transmission,very dangerous situations.
The contact owns a 2019 Ford F-150. The contact stated that on multiple occasions after the vehicle was started, he heard a rattling sound at the hood of the vehicle. The contact then stated that at times after attempting to start the vehicle, he had to wait for several minutes before the engine would turn over. No warning light was illuminated. The contact stated that he notified a tow truck company to remove the vehicle off the road. The contact was then able to restart the vehicle. The vehicle was taken to the dealer where it diagnosed that the cam phaser failed and needed to be updated and replaced. The vehicle as not repaired. The manufacturer was notified of the failure and the contact was provided a case number and advised to contact the federal safety agency Hotline. The failure mileage was approximately 75,567.
The contact owns a 2019 Ford F-150. The contact stated that while starting the vehicle, the engine made abnormal rattling sounds. The vehicle was taken to the dealer, where it was diagnosed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The contact related the failure to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement); however, the vehicle was not included. The failure mileage was approximately 42,000.
The contact owns a 2019 Ford F-150. The contact stated that during cold starts, there was a loud engine rattle present. The vehicle was taken to the local dealer who diagnosed that the cam phasers were faulty and needed to be replaced. The cam phasers were replaced under an Extended Service Campaign however, recently the failure reoccurred. The vehicle was taken back to the dealer who diagnosed that the cam phasers were faulty again and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 60,000.
Failed camshaft phasers and VVT solenoids. Mechanic shop has confirmed the problem and has said this is far from the first failure they have seen with Ford trucks and these parts. No warning lights to indicate the problem to the driver. Will lead to major engine failure.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history