2022 Ford F-150 lights problems

Filed Oct 30, 2026 · Lights · NJ

The factory daytime running light (DRL) LED signature strip on the front headlight assembly failed prematurely and went completely dark. Because the DRL is integrated into a sealed headlight unit, the individual lighting component cannot be repaired or serviced. Replacing the single failed DRL requires discarding and replacing the entire headlight assembly at an out-of-pocket cost exceeding $1,000 to $1,500.

Filed Oct 23, 2026 · Lights · OK

A segment of the daytime running lights went out at 60,000 miles. Another segment went out at approximately 70,000 miles. I have hundreds of other trucks with the LED reflector headlights have DRL segments out.

Filed Sep 20, 2026 · Lights · NC

The passenger side daytime running light has now failed leaving the vehicle less visible during low visibility times like fog or dawn and dusk. Problem can be reproduced but has not been inspected yet. No warning lamps or symptoms prior to failure. Problem occured 9-19-2026

Filed Sep 19, 2026 · Lights · OK

Daytime lights failed while driving

Filed Sep 18, 2026 · Lights · MO

My F 150 is 2022 Xlt my headlights are going bad already I’ve taken it to the dealership and said both complete headlight assembly need replaced to the tone of 4.000 dollars

Filed Sep 7, 2026 · Lights · NC

The daytime running lights are out. Vehicle is available for inspection. This puts my safety and the safety of others at risk by not being o by reducing visibility of the vehicle during low light scenarios where the headlights are off. Example I live in an area with lots of fog and drive a gray vehicle that is not clearly visible if headlights are off due to light exposure. Problem is consistent and able to be reproduced for inspection. Vehicle has not been inspected by any agent to this point but it is available and will be noticed upon inspection by direction. There are no warning lamps or messages alerting driver of malfunction which poses another safety risk. Problem has been consistent for past 3 weeks upon every start.

Filed Sep 4, 2026 · Electrical, Fuel system · 20,000 miles · PA

The contact owns a 2022 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds on several occasions, the vehicle experienced a temporary loss of motive power while accelerating and turning. The contact stated that the failure was a recurring failure, and the contact needed to maintain a fuel level above half tank. The vehicle was taken to a dealer, where it passed the State Inspection, and the contact was advised to wait until the recall part was available for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact became aware that the VIN was included in the federal safety agency Campaign Number: 26V104000 (Electrical System, Exterior Lighting); however, the contact had not received the recall notification. The failure mileage was approximately 20,000.

Filed Aug 31, 2026 · Lights · GA

Daytime running lights (LED) in headlights burn out/quit working. Currently it is only the pasenger side of my vehilce but its a common issue and eventually both passenger and driver side DRL's quit working. there is no repair for this, only option for the owner is to replace the entire headlight assembly and that is extremely costly.

Filed Aug 7, 2026 · Lights · SC

LED strip for the headlight assembly burned out. No known repair other than to replace the whole headlight assembly for $2500. This is a common issue with a poor design from ford and can cause visibility and safety issues with the vehicle. The dealership at beach ford in myrtle beach, sc swapped LED modules to make sure it wasn’t a programming or module issue, the symptom did not change headlights.

Filed Jun 29, 2026 · Lights · FL

I am submitting this complaint regarding the premature failure of the LED Daytime Running Lights (DRLs) on my 2022 Ford F-150. The vehicle's LED daytime running light on one side has completely failed, while the corresponding light on the opposite side has significantly faded and appears to be nearing failure as well. The vehicle has approximately 60,000 miles, which is well below the expected service life of a modern vehicle and its lighting system. Ford markets the LED Daytime Running Lights as an important safety feature because they improve vehicle visibility to other drivers during daylight conditions. However, when these LEDs fail, Ford does not offer any serviceable replacement for the failed LED components. Instead, owners are required to replace the entire headlamp assembly, despite the failure being limited to the integrated LED daytime running light. The cost to replace both headlamp assemblies can exceed $3,000, creating a significant financial barrier to restoring a safety feature that Ford itself promotes as enhancing vehicle visibility and safety. There is no replaceable bulb or reasonably priced repair option available. This raises two concerns: A safety-related lighting feature is failing prematurely at relatively low vehicle mileage. The design of the headlamp assembly makes repair unnecessarily expensive because a minor LED component failure requires replacement of the entire headlamp assembly. As a result, many owners may choose to continue operating their vehicles with failed daytime running lights rather than incur thousands of dollars in repair costs. This undermines the intended safety benefit of the daytime running light system. I respectfully request that the federal safety agency investigate whether the premature failure of these integrated LED daytime running lights, combined with the inability to repair the failed components without replacing the complete headlamp assembly, constitutes a safety-related defect warranting further review.